Page 1
PC7500 REVERSIBLE PLATE COMPACTOR OPERATING MANUAL Notice of Copyright Protection Copyright 2020, by U.S.SAWS . All rights reserved. This work may not be reproduced or disseminated in whole or in part by any means without the prior written permission of U.S.SAWS 11-19-2024...
& maintenance Max Travel Speed 52’/min (16m/min) of the PC7500 & to instruct you in safety practices for dealing with these Length/ Width/ Height 53” x 18” x 38” conditions. Keep all manuals provided with your machine in a safe place at all times.
You must be qualified for safe operation of the U.S.SAWS PC7500 machine. You must clearly understand the written instructions supplied by U.S.SAWS, be trained - including actual operation - & know the safety rules & regulations for the job site. It is a safety practice to point out & ex- plain safety signs &...
Keep children and visitors away Do not operate this machine unless you have received operational and from the work area. maintenance training from a U.S.SAWS representative or from an autho- rized distributor for U.S.SAWS. 4.12 KEEP FIRM GRIP ON MACHINE.
S A F E T Y I N S T R U C T I O N S 4.20 DO NOT USE DRUGS, ALCOHOL, MEDICATION. Do not operate machine while under the influence of drugs, alcohol, or any medication. 4.21 KEEP THE RIGHT PARTS IN THE RIGHT POSITIONS.
U.S.SAWS Plate Compactor. 6.2.1 The U.S.SAWS manual should be always kept in a place that is accessible to any persons working with the machine. Replacement manuals can be purchased from the equipment manufacturer or from your local dealer.
Page 7
NEVER perform maintenance on a running piece of equipment. Shut fuel cap for refueling. NEVER smoke while handling gasoline. If gasoline down the engine and allow it to cool before servicing a U.S.SAWS Plate is spilled anywhere on or around the equipment wipe it up and allow the Compactor, including mechanical work or lubrication.
MAINTENANCE Open fuel valve on gas tank. Set throttle lever to “Fast” idle position, Proper maintenance, inspection and storage of your U.S.SAWS Plate set choke to closed position, and start engine. Open choke slightly to prevent flooding. Move to “Open” or “Run” position when engine is warm, Compactor is vital to preserving the performance of your equipment.
R O U T I N E S E RV I C E & S TO R A G E ROUTINE SERVICE STORAGE Due to the nature and environment of use, plate compactors The following steps should be taken to prepare your plate compactor for could be exposed to severe operating conditions.
Warranty This document is to be used as a guide in determining warranty policies and procedures for U.S.SAWS and its U.S.SAWS products. It is to be used in determining whether a warranty is justified and as a procedural guide in completing a U.S.SAWS warranty claim form.
Page 11
FILL OUT THE ATTACHED CARD COMPLETELY AND ACCURATELY. WARRANTY REGISTRATION CARD IMPORTANT! To ensure that your U.S.SAWS machine is covered under warranty, please fill in the following information and mail or fax it to U.S.SAWS, 8004B E. Broadway Ave. Tampa, FL 33619, Fax No. 714-434-7299...
Need help?
Do you have a question about the PC7500 and is the answer not in the manual?
Questions and answers