Table of Contents

Advertisement

Quick Links

WAVE
SKYLIGHT, POPTOP, SRT
2025 Owner's Manual
REVISION DATE: 01/09/2025

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the WAVE SKYLIGHT 2025 and is the answer not in the manual?

Questions and answers

Summary of Contents for Westfalia WAVE SKYLIGHT 2025

  • Page 1 WAVE SKYLIGHT, POPTOP, SRT 2025 Owner’s Manual REVISION DATE: 01/09/2025...
  • Page 2 IMPORTANT First Time Owners Please report immediately if you did not receive a satisfactory walk around presentation of how to operate your new Westfalia Wave RV at the point you took retail delivery. Email: salessupport@roadtrekinc.com Pease provide the following: VEHICLE INFO: Your Selling Dealer’s Name:...
  • Page 3: Table Of Contents

    Emergency Weekend or After Business Hours specifications and capacities ......17 Warranty Repair Assistance ......8 owner and vehicle information and capacities 18 Obtaining Service Repair at a Westfalia Dealer Roadside Emergency ........19 ................8 If You Get a Flat Tire ........19 Replacement Parts ..........
  • Page 4 Chassis Battery ..........47 Propane Cooktop ..........33 Circuit Breakers and Fuses ......47 TRUMA COMBI ..........34 Battery Voltage ..........47 Outside Your WestFalia Wave ....... 34 AGM ..............47 Awning ............... 34 Lithium ............... 47 Garage Shower ..........37 What Charges Your Batteries ......
  • Page 5 Don’t ..............51 At Least Twice a Year ........59 On Board 120 Volt AC Power ......52 At Least Once a Year ........59 Standard 3000W Inverter ....... 52 Other Maintenance Checks ......59 Shore Power ............. 52 Seal Maintenance ..........60 Outlets ...............
  • Page 6: Consumer Information

    CONSUMER INFORMATION All agreements between your selling dealer and Westfalia are for the benefits of the selling dealer Dealer’s Responsibilities and Westfalia only. Third parties, including retail Your selling dealer is responsible for inspecting buyers motorhomes, third both factory and dealer installed components for beneficiaries of the Agreements, nor may they proper operation.
  • Page 7: Change Of Address Or Ownership

    However, if their Westfalia in writing by email or by fax (Attention: combined efforts are not satisfactory, please Registrations): send a letter describing the circumstances to: Email: sales@roadtrekinc.com...
  • Page 8: Suggestions For Obtaining Service

    • Vehicle serial number Assistance All work to be performed may not be covered by In an emergency, if an authorized Westfalia the Westfalia Limited Warranty or component dealer is not located nearby, please contact your manufacturer’s warranties. Discuss warranties selling dealer for assistance.
  • Page 9: Replacement Parts

    Roadtrek Inc., you may be liable for additional daily storage fees payable to Westfalia. Replacement Parts Roadtrek Inc. does not sell retail parts directly to consumers. Please contact your selling dealer for assistance in obtaining replacement parts and/or accessories.
  • Page 10: Introduction To Your Westfalia Wave

    Congratulations on the purchase of your • Distribute this manual complete with all its original unmodified content. Westfalia Wave and welcome to the Westfalia family. The information in this manual is meant Modify this manual for your own personal, •...
  • Page 11: Driving Your Westfalia Wave

    In the event you experience a flat tire while your your RV, but which vary between regions. Westfalia Wave RV is moving, do your best not to panic, stomp/slam on the brakes, or jerk your Service and Assistance foot off the accelerator.
  • Page 12: Child Passenger Safety

    death, you should immediately contact the restraint belt or anchor that enables securing a child safety seat, do not transport children National Highway Traffic Safety Administration requiring child safety restraints in that (NHTSA), as well as RoadtrekInc. If the NHTSA vehicle.
  • Page 13: Sumo Spring Package

    SUMO SPRING PACKAGE Refer to the chassis manufacturer’s owner’s Your Westfalia Wave is equipped with Sumo manual for additional and important information Springs on the rear for added comfort and regarding occupant and pet safety.
  • Page 14: Bicycle Rack (If Equipped)

    Thereafter, have be available through the online Westfalia alignment inspected periodically to maintain Owner’s Resource Information Service and vehicle steering performance and prevent Westfalia “How-to”...
  • Page 15: Reporting Safety Defects

    vehicle best and is interested in your satisfaction. Your dealer will provide quality maintenance and any other assistance that you may require during your ownership of this vehicle. If you need warranty repairs while traveling, you may take your vehicle to any authorized dealership and request their assistance.
  • Page 16: Explanation Of Data

    8. Westfalia model year and series/family name. 9. Model: Lists the Westfalia product model number of your vehicle. VEHICLE CERTIFICATION LABEL This label (picture 16.1) is affixed to the C pillar and is visible when the sliding side door is opened.
  • Page 17: Specifications And Capacities

    SPECIFICATIONS AND CAPACITIES WAVE SRT WAVE SKYLIGHT WAVE POPTOP Ram ProMaster L4H2 CHASSIS 3500 Ram ProMaster L5H2 3500 Ram ProMaster L5H2 3500 EXT LENGTH 19-7" 20-9" 20-9" EXT HEIGHT 9'5'' 9'5'' 9'5'' EXT WIDHT 6'11'' 6'11'' 6'11'' AWNING LENGTH INTERIOR HEIGHT 6'2'' 6'2'' 6'2''...
  • Page 18: Owner And Vehicle Information

    Notes: All information is based upon the most recent data available. Visit the Westfalia Inc web page – https://www.westfalia-americas.com – for the most current product information. The height of each model is measured to the top of the tallest standard feature and is based on the curb weight of a typically equipped unit.
  • Page 19: Chassis Service Center

    YOUR ROADTREK INC. DEALER/SERVICE CENTER: Name: Address: Contact: Phone: CHASSIS SERVICE CENTER: Name: Address: Contact: Phone: RV INSURANCE POLICY: Company: Policy Number : Agent: Phone: out side. ROADSIDE EMERGENCY DO NOT jerk your foot off the accelerator. • Just ease back on the accelerator slowly and Roadside Assistance: 1-844-515-4265 gently to continue momentum.
  • Page 20: Do's And Don'ts

    DO’S AND DON’TS Symbol Legend Information: Useful information knowledge. Warning: Not following this instruction may lead to negative results. Caution: You should follow this instruction. Danger: Do NOT perform this action. Doing so may result in injury, severe damage or death. Regulatory Warnings Overfilling propane container(s) can result in uncontrolled propane flow which could lead to a fire or explosion and result in death or serious injury.
  • Page 21: Information, Cautions And Warnings

    Gas cooking appliances need fresh air for safe operation. • Open vents or windows slightly or turn on exhaust fan prior to using cooking appliances. Warning Gas flames consume oxygen, which should be replaced to ensure proper operation. Improper use can result in death or serious injury. Do not fill propane containers to more than 80% of their capacity.
  • Page 22 Disconnect the inverter/charger prior to disconnecting the auxiliary battery. Battery The Westfalia Wave is supplied with a DC generator located underneath Generator the engine. Never submerge the generator. Use a spotter when launching a boat or crossing streams.
  • Page 23: Before You Head Out

    Your new Westfalia Wave is ready to go with just use it or not. Over time, the chlorine goes a little bit of preparation. To prepare for your first away, and the microbes come out to play.
  • Page 24 cabinet door is closed, press the latch button in to lock the cabinet. Do not attempt to close the cabinet doors while the latch button is pressed in. This will break the latch. Always make sure the button is out before attempting to close a cabinet door. Weight in each cabinet should not exceed 50 lb.
  • Page 25: Galley Cabinets

    The screw in the top part of the hinge nearest the Westfalia Wave point adjusts the vertical location of the door. Screw out to raise the door and fix stuck doors; screw in to lower the door and fix doors that will not stay shut when latched.
  • Page 26: Lights

    These are LED lights consume little electricity. Westfalia Wave is equipped with under cabinet lighting (picture 26.2), these are turned on via the Firefly and the rear lighting control (picture 26.3) and can be dimmed via the switch (pictures 26.4 and 26.5) 26.3...
  • Page 27 TABLE SET UP Table should be stowed when the vehicle is in motion. The table stows in the overhead above the driver and passenger seats (picture 27.1) To assemble the table the leg must be assembled by inserting the tab into the receiver (picture 27.2).
  • Page 28: Captain's Seats

    CAPTAIN’S SEATS The two captain's seats in the front of your Westfalia Wave are adjustable fore-and-aft by pulling up on the bar under the front of the seat and will swivel when the inside corner is pulled up (picture 28.1). Always return the seats to the forward-facing position when driving.
  • Page 29: Ventilation

    29.1 The Side Window Screens VENTILATION Your Westfalia Wave is equipped with a ceiling SLEEPING FACILITIES mounted Skylight (picture 29.3) Your Westfalia Wave has beds that can be configured as a king bed or twin bed. Experiment with different configurations to find what works best for you.
  • Page 30: Folding Bed

    BATHROOM FACILITIES Using the Toilet The enclosed bathroom in the Westfalia Wave has a cartridge toilet with a rotating bowl. To add water to the bowl, press the blue button (picture 30.1) found on wall behind the toilet, to flush the toilet, pull the lever located at the bottom of the front of the toilet bowl.
  • Page 31: Pop Top Sleeping Area

    Pop Top Sleeping Area designed to support any load above 20 kg or 44 lbs. The ladder can be installed before raising the pop top to facilitate undoing the latches. Ensure the ladder is secured in both mounts by twisting The Pop top has three window (two mesh, one the lock on the back of the ladder hooks.
  • Page 32: Shower

    32.1 The Lever is located on the front of the base 32.3 SHOWER Shower Drain Plug Remove the shower drain plug (picture 31.2) Slide the bathroom door along its track to enclose the shower space. (picture 31.1) pull on the tap handle and adjust the water temperature as desired.
  • Page 33: Appliances

    APPLIANCES at your house. It is probably lower powered, so cooking may take a bit longer. Refrigerator The microwave will run from the batteries The refrigerator is an electric compressor model through the inverter for reheating purposes or that runs on 12-volt DC power. When shore other brief use.
  • Page 34: Truma Combi

    (picture 35.2) These 34.3 are secured to the two attachment points on the side of the Westfalia Wave. Refer to the awning manual for the proper way of securing the awning supports to the attachments. To stow the...
  • Page 35 35.1 35.2...
  • Page 36 Please Note: These procedures cannot be If the van is turned on, then the awning used to extend the awning. controls on the Firefly will lock. Turn off the ignition to retract awning.
  • Page 37: Garage Shower

    37.2 37.1 Side Doorstep Your Westfalia Wave is equipped with a step that automatically extends when the side door is opened (picture 37.2) or easy entry and exit out of your vehicle. The switch is located to the right of the Firefly screen.
  • Page 38: Rear Door Screen

    Rear Door Screen The Westfalia Wave has a rear screen which allows you to open the rear doors to get fresh air and a better view, without bugs coming in or (attended) pets going out. (picture 38.3) The screen is attached to the rear door frame and cargo area floor.
  • Page 39: Side Door Screen

    Side Door Screen UTILITIES In addition to the rear door screen, there is also Just like your house, your Westfalia has fresh a side door screen which will allow you to keep water, electricity, wastewater disposal, heating, the side door open for ventilation without and cooling systems.
  • Page 40: Water Pump

    Water Pump There is a pressure regulator in the To use the water in the tank, you need to turn on connection. the water pump using the Firefly Control Panel. (picture 38.3) 40.3 40.1 Wastewater Gray Tank Galley sink, bathroom sink, and shower drain water drains into the gray water tank.
  • Page 41: Gate Valves And Hose Location

    41.1 41.2 Fold Down Access Door Ensure that the grey water gate valve is closed before using the wastewater system. It is possible for the valve to open slightly especially after extensive driving. Grey water dump valve is accessed through the driver side storage door. Debris, minerals, and moisture will affect readings.
  • Page 42: Heating And Cooling

    Flexible Hose HEATING AND COOLING Air Conditioning The Truma Aventa air conditioner (AC) provides cooling for your Westfalia using electric shore Temperature Sensor power or the under-hood generator. The AC can be operated normally when you are plugged in to shore power.
  • Page 43: Main Shutoff Valve

    Do not forget to turn the valve back on to resume normal operations. The external BBQ connection is also located in this area (picture 41.2), while this is not a full tank pressure it is considered a high-pressure connection. Any BBQ connected to this must have their own built-in regulators, remove the yellow protective cap to access the connection.
  • Page 44: Propane Tank Filling

    The seven-gallon tank in substitute for formal training or instruction. your Westfalia Wave will hold 5.9 gallons / 22 liters when completely empty and filled to the Do not attempt to fill the tank unless you have correct 80% full level.
  • Page 45: About Propane

    Do not remove the batteries. Batteries The Westfalia Wave's propane tank is mounted are heavy and require under coach outside the vehicle and will vent propane where access.
  • Page 46: Further Information

    The two best defenses against sulfating and WARNING Before removing any battery cables or battery, make sure all 12-volt equipment in the motorhome is off and the power cord has been disconnected. Be sure to replace the battery terminal boot, if supplied, back onto the positive terminal after servicing.
  • Page 47: Chassis Battery

    Batteries – the system is made up of: after handling. avoid discharge or sulfating. Your Westfalia has a sealed AGM (absorbed glass mat) battery. Do not try to open it. There is To ensure that the battery will always accept and...
  • Page 48: What Charges Your Batteries

    What Charges Your Batteries Inverter Charger Your Westfalia Wave is equipped with a 3000- watt inverter-charger which converts 120-volt AC (household current) to 12 volts DC when you are connected to shore power. This 120-volt power is used to power your 12-volt DC appliances as well as charge your batteries.
  • Page 49: Battery Disconnect Switch

    This switch should be The batteries will automatically discharge to off when you are not using your Westfalia Wave. power the house bank system when needed. Battery runtime will vary depending on how much power is being used.
  • Page 50: Sleep Mode

    the Lithium Battery begins storing energy Turn each battery OFF, and then wake it up while the battery is being warmed up. During by tapping the battery icon twice on the this time, you can see the temperature rising Firefly screen. in the Smart BMS app, but the state of If the Battery ID remains greyed out in the charge may not be increasing yet.
  • Page 51: Off-Season Storage

    Each battery comes with a 2-year Limited storage: 50%. Warranty. For complete details, please see the 3. Recommended storage temperature: 15°C complete Operating manual available on our website. www.westfalia-americas .com to 35°C. Microgreen Customer Support: 4. Warranty-approved storage temperature: - 30°C to 45°C.
  • Page 52: On Board 120 Volt Ac Power

    The standard configuration includes a 3000-watt inverter. This inverter provides 120-volt AC (household current) for the outlets in your Westfalia Wave, running the TV, microwave, air conditioner and the Truma Combi. Turn off the inverter upon retiring at night or 52.2...
  • Page 53: Monitor Panel

    Shore power is the name for power supplied by a utility company that you plug into to provide power to your Westfalia Wave. Please visit the owner’s section of our website to read the HOW TO: Shore Power for a concise guide to plugging in and unplugging from shore power.
  • Page 54 Please note that all 12- volt appliances run off the battery which is powered by the solar panels and GU. Please note that to run any 120-volt appliances the inverter must be turned on.
  • Page 55: Distribution Panel

    For this reason, on each breaker. (Picture 55.1) When storing whenever the vehicle is occupied, particularly if your Westfalia Wave for the winter, turn off the you are asleep, the battery disconnect switch battery disconnect switch, the inverter, and all should be in the "on"...
  • Page 56: Low Battery Level

    Westfalia Wave. Fire Extinguisher Your Westfalia Wave comes equipped with a dry Refer to the maintenance plan on the following chemical fire extinguisher suitable for all fires. pages for the required maintenance intervals.
  • Page 57: Tires

    Appliance owner’s manuals are available for Inspect all seals around all doors and • download at www.westfalia-americas.com windows and if damaged in any way, have Tires them replaced immediately. • All seals should be inspected for cracks,...
  • Page 58: Exterior Finish

    Polishing and Waxing If you discover any areas where the flare panel may be pulling away or separating from the Part of the maintenance of your vehicle should vehicle body, cover the opening (e.g., with duct include polishing and waxing the exterior. This tape) until a repair can be completed.
  • Page 59: At Least Twice A Year

    • Check lap and shoulder belts for wear and best way to keep your Westfalia clean and shiny. function. Replace any belts with frayed spots or that do not smoothly retract into their Other Maintenance Checks holders.
  • Page 60: Seal Maintenance

    Seal Maintenance vehicle up to 100 miles (160 km) with a maximum speed of 50 mph (80 km/h). The tire service kit is Due to the nature of the sealants used in the RV found under the passenger seat. Full instructions industry and the ability for the RV to be used in for the use of the kit can be found on page 206 many...
  • Page 61 • The jack is designed to be used as a tool for changing tires only. The jack should not be used to lift the vehicle for service purposes. The vehicle should be jacked on a firm level surface only. Avoid ice or slippery areas.
  • Page 62 JACK AND TOOLS LOCATION • Only use the jack in the positions indicated and for lifting this vehicle during a tire change. Depending on vehicle trim level, the jack and tools are stored under the front passenger seat in a box or •...
  • Page 63: Jacking The Rear Of The Coach

    Jacking the rear of the coach Rear Jacking location Step 1: New jacking locations are ahead the rear wheels on the rear spring curved surface. Ensure the van is secured on a flat surface and have the van in park with the emergency brake activated during the process.
  • Page 64 Block Placed on Jack Step 5: Raise up the jack with the jack block attachment in position to match the curvature of the rear springs (located ahead the rear wheels). Rotate the jack and/or the attachment as required. Step 6: Follow the proper procedure for removing and replacing the wheel.
  • Page 65: Winterizing The Wave

    Winterizing the Wave Winterize – This uses the pump to draw Winterizing fluid into the pump and add it to the tank. Normal Operation – Use this to operate the items in the coach. When on city water connection the pressure is directed to the taps and toilet.
  • Page 66 Step 1: Draining the fresh water from the Close the ¼ turn valve located at the city water system connection. You can drain the water from the system 2 ways. From the Firefly screen turn on the water pump Draw Drain the water on the ground using the ¼...
  • Page 67 Wipe down any sink basins and the shower base, Ensure the AGM battery is fully charged prior to install sink plugs. putting the coach away for the winter. Step 4: House battery preparation for Step 5: Chassis Battery disconnect storage The starting battery is located in the floor The Lithium batteries in your Wave come with between the front seats.
  • Page 68: Roadtrek Inc. Two (2) Year Limited Warranty

    Purchaser shall road repair, towing, labor, meals notify their Westfalia Dealer within the warranty accommodations, etc. Such will not be period. The obligation of Roadtrek Inc. under this accepted if claimed under warranty. warranty expressly...
  • Page 69: Appliance Warranty

    Smoke alarm/Carbon monoxide detector. • 7. Purchasers are responsible for presenting Lithium modules • their motorhome to a Westfalia Dealer as AGM Battery Warranty soon as a problem exists. The warranty Batteries warranted battery repairs should be completed in a reasonable amount of time from date of authorization.
  • Page 70: Warranty Intent

    Roadtrek Inc. typically cannot initiate a The intent of this extended warranty is to ensure case with the chassis manufacturer, the owner the new owner of a Westfalia that it is worry free must do that. from manufacturer caused defects (excluding the chassis) for the first two (2) years of use.
  • Page 71: Car Or Trailer Towing

    Curb Weight = UVW + fuel at 6 lbs. per US gal GCW = GVW (including propane) + cargo weight for gas and 7 lbs. per US gal for diesel + water weight + passenger weight + trailer weight Cargo Weight includes passengers, cargo, optional equipment, and water at 8.3lbs per US GCWR (Gross Combined Weight Rating) is the gal.
  • Page 72: Trailer Wiring Connector

    Towing will affect vehicle handling, durability, Finally, do not forget to consider the actual and fuel economy. Exceeding any of the listed tongue weight. This should not exceed the stated Gross Weight Ratings will result in unacceptable hitch vertical load for your vehicle. This weight is overall vehicle performance.
  • Page 73: Towing Guidelines

    2 years of the limited warranty this definition, the “trailer” can be a trailer, a upon registration of your Westfalia. The roadside vehicle towed on a dolly, or a vehicle towed by assistance plan is transferrable to subsequent means of a tow bar.
  • Page 74: Aftermarket Disclaimer

    If you believe that your vehicle has a defect For access to more information on how to which could cause a crash or could cause injury perform general functionalities of your Westfalia or death, you should immediately inform the Wave,...

This manual is also suitable for:

Wave poptop 2025Wave srt 2025

Table of Contents