Summary of Contents for STEELFORT LawnMaster LMWPWG20
- Page 1 WATER TRANSFER PUMP SAFETY AND OPERATING MANUAL PLEASE READ THIS MANUAL CAREFULLY BEFORE OPERATING THE UNIT LMCG260EH LMWPWG20 PROUDLY A STEELFORT PRODUCT NZ OWNED...
-
Page 2: Table Of Contents
Discharge Hose Installation Pump Water Operating Condition Engine Oil/Fuel Starting & Stopping Pump MAINTENANCE Maintenance Schedule Engine Oil Changing Oil Double Filter Foam & Paper Filter Spark Plug Spark Arrester Adjustment TROUBLE ANALYSIS & TROUBLESHOOTING STORAGE & TRANSPORTATION WARRANTY A STEELFORT PRODUCT... -
Page 3: Operator Safety
LawnMaster LMWPWG20 Water Transfer Pump. possessed by the operator. PLEASE READ THIS MANUAL CAREFULLY BEFORE DANGER USING THE UNIT. -
Page 4: Hot Surface
Keep hands and body far away from discharge of the pump. Fix the transport pipe the pump so that it can stable during operation. Never put hand or body into the operation pump or transport pipe. • A STEELFORT PRODUCT... -
Page 5: Features & Technical Data
FEATURES & TECHNICAL DATA Throttle Control Fuel Cap Inlet Choke Lever Outlet Outlet Drain Plug Fuel Switch Frame Inlet Water Plug Recoil Starter Oil Dipstick Air Filter Muffler Oil Drain Remote On/Off Switch A STEELFORT PRODUCT... - Page 6 Rated Suction Head Self-Priming Time at 5m (s) Max Speed (r/min) 3800 Note: Any engine and related data of pump changes may not be informed. Engine may difference in various areas, please contact your local dealer for engine information. A STEELFORT PRODUCT...
-
Page 7: Operation & Assembly
Place the water pump in a hard horizontal surface 5. Hose Clamp before running it, and the pump setting location and 6. Suction Hose its water lift should not over the limited, or it will damage the sealing caused by overheated. DISCHARGE HOSE INSTALLATION A STEELFORT PRODUCT... -
Page 8: High Altitude
Oil is a major factor affecting performance and Remove any excessive dirt or debris, especially service life. Use 4 stroke SAE 10w-30 oil which is around the muffler and recoil starter. recommended in the Maintenance section of this manual. ENGINE OIL A STEELFORT PRODUCT... -
Page 9: Engine Fuel
Use gasoline outdoors in a well-ventilated area. • Wipe off spills and ensure fuel is dry before starting equipment. • Never operate machinery with fuel leaks. • Store fuel safely, away from heat sources. • Empty fuel tanks before storage or transport. A STEELFORT PRODUCT... -
Page 10: Recoil Start
The filter element may contains PAHs, PAHs are engines more 1-2 minutes. harmful for your health. Please wear gloves for Turn the switch to OFF position or O position to protection during air filter maintenance. stop the pump. A STEELFORT PRODUCT... -
Page 11: Maintenance Schedule
Pump Cooling Fan Check Pump Water Check Intake Valve * 1: More frequent maintaining is required when engine run in the multi-dust or severe condition. * 2: All maintaining should be done by a LawnMaster Service Dealer. A STEELFORT PRODUCT... -
Page 12: General Maintenance
CAUTION Never brush the dirt, which may make the dirt into Change oil when the engine is warm from operation. paper filter. Change a new paper filter if it is too dirty. A STEELFORT PRODUCT... -
Page 13: Spark Plug
Carefully thread the plug into the engine by hand. After the spark plug seated, use spark plug wrench to tighten it. Spark plug tighten torque: 20-25 N.m Attach the spark plug boot to the plug. WARNING A STEELFORT PRODUCT... -
Page 14: Trouble Analysis & Troubleshooting
Engine works low speed speed If problems still not be solved according to above problem shooting or other problem caused during operation, contact your local authorised LawnMaster dealer for help. Unauthorised disassemble on the pump will void your warranty. A STEELFORT PRODUCT... -
Page 15: Storage & Transportation
/ or expenses resulting from any defect. If the unit requires further repairs or services please visit www.lawnmaster.co.nz to find your local LawnMaster dealer. For all other enquries contact Steelfort Customer Services +64 6 350 1350 A STEELFORT PRODUCT... - Page 16 FIND US www.lawnmaster.co.nz lawnmasternz Steelfort Steelfort Auckland 500 Rangitikei Street, Private Bag 11045 880 Great South Road, Penrose Palmerston North, 4412, New Zealand Auckland, 1061, New Zealand 06 350 1350 09 573 1324...
Need help?
Do you have a question about the LawnMaster LMWPWG20 and is the answer not in the manual?
Questions and answers