ELEMENT 4 Ovation Bio Installation, Operation And Owner's Manual
  1. Manuals
  2. Brands
  3. ELEMENT 4 Manuals
  4. Indoor Fireplace
  5. Ovation Bio
  6. Installation, operation and owner's manual

ELEMENT 4 Ovation Bio Installation, Operation And Owner's Manual

Bioethanol fireplace
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from the hot viewing glass is provided with this appliance and shall be installed
for the protection of children and other at-risk individuals.
Une barrière conçu pour réduire le risque de brûlure par le verre de visualisation chaude est fournie avec cet appareil et doit
être installé pour la protection des enfants et autres personnes à risque.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result
in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Installation, Operation and
Owner's Manual
Ovation Bio
Bioethanol Fireplace
Une surface vitrée chaude
peut causer des brûlures.
Laisser refroidir la surface
vitrée avant d'y toucher.
Ne permettez jamais á un enfant
de toucher la surface vitrée.
AVERTISSEMENT:
INCENDIE OU D'EXPLOSION
Le non-respect des avertissements de sécurité à la
lettre pourrait entraîner de graves blessures , la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d'essence ni d'autres vapeurs
ou liquides inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- Installation et l'entretien doivent être effectués par un
installateur qualifié, une agence de service ou le fournisseur
de gaz.
INSTALLATEUR: Laissez cette notice avec l'appareil.
CONSOMMATEUR: Conservez cette notice pour
consultation ultérieure.
December 2024

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Ovation Bio and is the answer not in the manual?

Questions and answers

Summary of Contents for ELEMENT 4 Ovation Bio

  • Page 1 Installation, Operation and Owner’s Manual Ovation Bio Bioethanol Fireplace HOT GLASS WILL Une surface vitrée chaude CAUSE BURNS. peut causer des brûlures. DO NOT TOUCH GLASS Laisser refroidir la surface UNTIL COOLED. vitrée avant d’y toucher. NEVER ALLOW CHILDREN Ne permettez jamais á un enfant TO TOUCH GLASS.
  • Page 2 I N S T A L L A T I O N M A N U A L D O N O T U S E T H I S P R O D U C T A S A P R I M A R Y H E A T S O U R C E A L W A Y S U S E B I O E T H A N O L O F 8 5 % T O 9 6 , 6 % A L C O H O L D O N O T P O U R O V E R D O N O T F I L L W H I L E...

  • Page 3: Table Of Contents

    I N S T A L L A T I O N M A N U A L TABLE OF CONTENTS DECLARATION OF PERFORMANCE � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 4 IMPORTANT INFORMATION �...
  • Page 4 I N S T A L L A T I O N M A N U A L MAINTENANCE INSTRUCTION � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 17 9�1 MAINTENANCE �...

  • Page 5: Declaration Of Performance

    Remote control Local spaceheater on bioethanol Model: Owner Ovation Bio Keep this manual for future reference The fireplace may only be installed by a qualified installer/dealer, This declaration loses its validity when changes to the device are made following these installation instructions. We advise you to read these without the written permission by Element4.

  • Page 6: Other Information

    I N S T A L L A T I O N M A N U A L | Chapter 1, 2, 3 2�3 OTHER INFORMATION front of the fireplace: a fire screen or, to protect young toddlers, a “hearth gate”.
  • Page 7 I N S T A L L A T I O N M A N U A L | Chapter 1, 2, 3 WARNING NEVER OBSTRUCT the flow of ventilation air. Keep the front of the Children and adults should be alerted to the hazards of high surface appliance CLEAR of all obstacles and materials for servicing and temperature and should stay away to avoid burns or clothing ignition.

  • Page 8: Remote Control And Ignition

    Chapter 4 I N S T A L L A T I O N M A N U A L | REMOTE CONTROL AND IGNITION 4�1 REMOTE CONTROL 4�2 FILLING THE TANK Figure 4.1 The device is operated by remote control ( ) The remote control requires 4 type AAA batteries.

  • Page 9: Turning The Fire Place Off

    Chapter 4 I N S T A L L A T I O N M A N U A L | 4�4 TURNING THE FIRE PLACE OFF The tank hose can be emptied by pressing the -FILL- button several times while holding the hose upright to prevent spillage. Make To turn off the fire, touch the ON button to activate the remote control sure the hose is completely free of fuel before disconnecting it.

  • Page 10: Installation Preparation And Instruction

    I N S T A L L A T I O N M A N U A L | Chapter 5 INSTALLATION PREPARATION AND INSTRUCTION The device has been developed, tested and approved to conform with applicable standards for the usage, performance and safety of the product.

  • Page 11: Top Side Or Back Side Connection

    I N S T A L L A T I O N M A N U A L | Chapter 5 5�2 TOP SIDE OR BACK SIDE CONNECTION This device has the option to be connected on the top side or the back side.

  • Page 12: 5�3 Safety Screen

    I N S T A L L A T I O N M A N U A L | Chapter 5 5�3 SAFETY SCREEN 5�3�1 SAFETY SCREEN MOUNTING INSTRUCTIONS To reduce the risk of accidents caused by contact with the stove's hot surfaces, a safety screen is installed over the hottest area, the glass To install the safety screen, start by using the top brackets to hang it over panel.

  • Page 13: Fire Safe Installation

    I N S T A L L A T I O N M A N U A L | Chapter 6 FIRE SAFE INSTALLATION To install a fireplace as safely as possible, several installation preparations need to be made. This overview can be used to assure the fire safety of a conversion of a fireplace.
  • Page 14 I N S T A L L A T I O N M A N U A L | Chapter 6 a’ Figure 6.2 | Distances to combustible materials (front) Figure 6.1 | Backside connection a - a’ Figure 6.3 | Figure 6.4 | Floor plate Floor plate...

  • Page 15: Attention Points Flue Gas Extraction

    I N S T A L L A T I O N M A N U A L | Chapter 7 ATTENTION POINTS FLUE GAS EXTRACTION To guarantee the fire safety regarding you flue gas configuration a casing is necessary. For this case non-combustible materials should be used. Make sure to ventilate a shaft and never to insulate it, to make sure the hot air is able to get away.

  • Page 16: 7�2 Bends

    I N S T A L L A T I O N M A N U A L | Chapter 7 7�2 BENDS 7�2�1 CALCULATE FLUE LENGTH Not all parts can be adjusted! To fit the drainage system correctly, you Be aware of the bends in your flue.

  • Page 17: Safety

    I N S T A L L A T I O N M A N U A L | Chapter 8 SAFETY The Element4 bioethanol fireplace has several safety systems to ensure that it can be used in the safest way. Nevertheless, a few things must be taken into account: •...

  • Page 18: Maintenance Instruction

    I N S T A L L A T I O N M A N U A L | Chapter 9 MAINTENANCE INSTRUCTION This part of the manual focuses on maintenance. To ensure the optimal flame picture of your device, an annual maintenance by a competent company or installer is prescribed.
  • Page 19 I N S T A L L A T I O N M A N U A L | Chapter 9 Figure 9.2 | Opening the top door...

  • Page 20: Burner Maintenance

    I N S T A L L A T I O N M A N U A L | Chapter 10 BURNER MAINTENANCE APPENDIX A APPENDIX A has an overview for burner malfunctions. The burner can be reached via the maintenance access. The starter and thermocouple can be reached through the combustion chamber.

  • Page 21: Decorative (Ceramic) Parts

    I N S T A L L A T I O N M A N U A L | Chapter 11 DECORATIVE (CERAMIC) PARTS This appliance is equipped with a ceramic fire bed with heat-resistant Position the decoration logs as shown on the following steps. ceramic fibers, or artificial glassy silicate fibres.
  • Page 22 I N S T A L L A T I O N M A N U A L | Chapter 11 Figure 11.3 | Step 2 Lay log 3 and 4 as shown in the image above Figure 11.4 | Step 3 Place logs 1 and 2 with the scorched part on top of logs 3 and 4 as shown above.
  • Page 23 I N S T A L L A T I O N M A N U A L | Chapter 11 Fill the burner grate with some chips. Figure 11.5 | Step 4...

  • Page 24: Operating The Fireplace

    I N S T A L L A T I O N M A N U A L | Chapter 12 OPERATING THE FIREPLACE 12�1 BEFORE THE FIRST FIRE 12�3�2 SMELL CHECK When the fireplace is first heated, an odour may be given off by the hot Make certain that all construction materials have been removed metal.

  • Page 25: Atroubleshooter

    I N S T A L L A T I O N M A N U A L | Appendix A TROUBLESHOOTER A�A FIRST AID FOR MALFUNCTION Below you will find an overview of the possible cause and solution in the event of a failure.

  • Page 26: A�Bnecessary Tools

    I N S T A L L A T I O N M A N U A L | Appendix A A�B NECESSARY TOOLS To help out the installers, mechanics and others who need to do work Please note on our fireplaces e.g. during maintenance, a list is compiled of tools If a problem is found, that cannot be solved on site, always contact your Element4 expects are being carried during said services.

  • Page 27: Berror Codes

    I N S T A L L A T I O N M A N U A L | Appendix B ERROR CODES B�A MESSAGES SHOWN ON REMOTE CONTROL The installed software will give an error/stop code if the bioethanol fire has stopped or not started for any reason.
  • Page 28 I N S T A L L A T I O N M A N U A L | Appendix B Erro code Description Possible causes Possible solutions Time out, waiting • The fuel did not reach the high sensor in •...

  • Page 29: Cterminal Location

    I N S T A L L A T I O N M A N U A L | Appendix C TERMINAL LOCATION C�B TERMINAL LOCATION WITH HORIZONTAL EXHAUST (C31) C�A TERMINAL LOCATION WITH VERTICAL EXHAUST (C11) Distance Exhaust 1,2 of 3 Position terminal dist.

  • Page 30: Dcalculation Tables Fluegas Restriction

    I N S T A L L A T I O N M A N U A L | Appendix D CALCULATION TABLES FLUEGAS RESTRICTION Attention: For information on how to calculate bends see CHAPTER 7 CHAPTER 7 In the calcualtion table below you can see when your flue is suitable for this fire or not.

  • Page 31: D�Cadditional Information Rear Flue Connection

    I N S T A L L A T I O N M A N U A L | Appendix D D�C ADDITIONAL INFORMATION REAR FLUE CONNECTION D�D CALCULATION TABLES FLUEGAS RESTRICTION When using the rear flue connection the rules for the flue gas extraction In the calcualtion table you can see an overview of the possible flue change comapred to using the standard top connection.

  • Page 32: Etechnical Data

    I N S T A L L A T I O N M A N U A L | Appendix E TECHNICAL DATA The values below depend on the type of Bioethanol used and the way in which the fire is built in. Note: Always use Bio-Ethanol with 85% to 96.6% alcohol.

  • Page 33: Fdimensional Drawings

    I N S T A L L A T I O N M A N U A L | Appendix F DIMENSIONAL DRAWINGS On this page you will find the dimensional drawings of the Ovation with some of the important dimensions that you have to take into account when installing and installing your fireplace.

  • Page 34: Gelement4 Warranty

    PRODUCT INSTALLATION RECORD Installer: Please complete this form. Customer: Please retain this information. Model ❒ Ovation Bio Purchased from Installed by Date of installation Fireplace serial number Total horizontal section (venting) Total vertical section (venting)
  • Page 35 I N S T A L L A T I O N M A N U A L | Notes 3 4 3 4...
  • Page 36 Design & Assembly by: E L E M E N T 4 B . V. Info@element4.nl www.element4fires.com 1 1 / 1 2 / 2 4 RELEASE DATE |...

Table of Contents