Table of Contents
Advertisement
Quick Links
O W N E R ' S & PA R T S M A N U A L
O W N E R ' S & PA R T S M A N U A L
RIDE-ON VIBRATORY COMPACTOR - 2 1/4 TON
SERIAL NUMBERS 305-NB24-0001 & UP
WARNING! READ THIS MANUAL AND
SAFETY MANUAL BEFORE OPERATING OR SERVICING YOUR MODEL B305.
VIBRATORY
GASOLINE & DIESEL ENGINES
A E M
AEM ROLLER COMPACTOR
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for NEW BEUTHLING B305
Summary of Contents for NEW BEUTHLING B305
- Page 1 O W N E R ’ S & PA R T S M A N U A L VIBRATORY RIDE-ON VIBRATORY COMPACTOR - 2 1/4 TON GASOLINE & DIESEL ENGINES SERIAL NUMBERS 305-NB24-0001 & UP A E M WARNING! READ THIS MANUAL AND AEM ROLLER COMPACTOR SAFETY MANUAL BEFORE OPERATING OR SERVICING YOUR MODEL B305.
-
Page 2: Table Of Contents
MACHINE IDENTIFICATION INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . BACK COVER NOTE: FOR ALL INQUIRES PLEASE INDICATE: NEW BEUTHLING MODEL _________________________________ NEW BEUTHLING SERIAL NUMBER ________________________ ENGINE MAKE & MODEL __________________________________ ENGINE SPEC NUMBER __________________________________ MODEL & SERIAL NUMBER PLATE IS LOCATED ON FRONT MAIN FRAME... -
Page 3: Operation
DRUM PARKING FORWARD & SPRAY BRAKE REVERSE LEVER HYD. FLUID (DASH PANEL) CHOKE, THROTTLE, GAUGES, ROCKER FUEL WATER SWITCHES FUEL 65.00” FRONT DRUM BALLAST FILL 11.00” CURB PLUGS FRONT CLEARANCE TIE DOWNS REAR TIE DOWNS WALL 65.50” CLEARANCE .75 97.00” 44.00”... -
Page 4: Starting Diesel Engine
STARTING DIESEL ENGINE STARTING DIESEL ENGINE If so equipped with ROPS, IMMEDIATELY, after being seated, place the seat belt across the lap and SECURELY insert the metal end into the belt buckle. TIGHTEN the belt, AGAINST the body, by pulling on the loose end of the belt. IMPORTANT: Move the engine speed throttle control to the LOW (down) engine idle speed •... -
Page 5: Emergency Shutdown Procedure
COLD WEATHER COLD WEATHER IMPORTANT: • Do not allow the starter motor to run continuously STARTING DIESEL STARTING DIESEL for more than 20 seconds. • Be sure to warm up the engine not only in winter, but If the ambient temperature is below -5°C(23°F) and the also in warmer seasons. -
Page 6: Dynamic Braking
Fill the water tank with clean water. The B305 is equipped with a 15 quart oil reservoir - when changing or Located by the seat is the spray valve. Open valve, by moving the adding fluid, use AW ISO 32 HYD Fluid or equivalent. -
Page 7: Lubrication Chart
(-) battery cables from a battery, BEFORE ANY repair procedures are done to the electrical wiring or components . DO NOT weld on machine unless battery Is disconnected and removed . LUBRICATION CHART MODEL B305 Ref No. Lubrication Point Types of Lubricant Lub. -
Page 8: Filter Chart
FILTER CHART FILTER CHART Honda GX 690 Kubota D1005 Gasoline Engine Diesel Engine Oil Filter 200-0400 Oil Filter 200-0156 Fuel Filter 200-0402 Fuel Filter 205-0250 Air Filter Element 200-0401 Air Filter Element 205-0252 Hyd . Oil Filter 130-0002 Hyd . Oil Filter 130-0002... -
Page 9: Decals, Operation & Maintenance
DECALS, OPERATION & MAINTENANCE AMERY, WISCONSIN... - Page 10 DECALS, OPERATION & MAINTENANCE...
- Page 11 Optional...
-
Page 12: Front End Assembly
FRONT END ASSEMBLY Item No. Part No. Description ..............Qty. - Page 13 B305 REAR DRUM ASSEMBLY II Item No. Part No. Description ..............
-
Page 14: Drum Spray System
DRUM SPRAY SYSTEM SPRAY NOZZLE ASSEMBLY Item No . Part No . Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Qty . - Page 15 ELECTRICAL SCHEMATIC - W/ HONDA GX690 BRAKE SOLENOID BLACK GREEN GREEN WHITE/BLUE STRIPE WHITE GREY GREEN WHITE WHITE/BLACK STRIPE IGN. SWITCH BLUE PURPLE GREEN VIBE SOLENOID WHITE HONDA V-TWIN GX-690 BROWN GREY GREY GREEN BLACK PINK OPTIONAL...
- Page 16 ELECTRICAL SYSTEM - W/ HONDA GX690 Item No . Part No . Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Qty .
- Page 17 ELECTRICAL SCHEMATIC - KUBOTA D1005 DIESEL...
-
Page 18: Electrical System
New Beuthling Wiring Harness (Diesel Engine Only) D1005 ....... 1... - Page 19 KUBOTA D1005 DIESEL ENGINE COMPONENTS...
- Page 20 KUBOTA D1005 DIESEL ENGINE & RELATED COMPONENTS B305 *NOTE: Must have unit and engine S/N when ordering these engine parts Item No . Part No . Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
- Page 22 HYDRAULIC SYSTEM B305 Item No . Part No . Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
-
Page 24: Miscellaneous Components
Decal Kit, Complete Set B305 ........ - Page 25 Decal Kit, Complete Set B305 ........
-
Page 26: Electrical System W/Kubota Diesel Engine
B305 SPECIFICATIONS WEIGHTS BRAKES Shipping Weight ......3100 lbs. Service ..Hydrostatic drive provides dynamic braking Operating Weight (Full Ballast + Operator) . -
Page 27: Notes
NOTES... - Page 28 COMPACTOR IDENTIFICATION INFORMATION COMPACTOR SERIAL NUMBER: ________________________________________________________________________________________________ ENGINE, MAKE, MODEL & SERIAL NUMBER: ___________________________________________________________________________________ PURCHASE DATE: ______________________________________________________________________________________________________________ DEALER: ________________________________________________________________________________________________________________________ PHONE #: _______________________________________________________________________________________________________________________ COMPACTOR SERVICE INFORMATION New Beuthling 465 Griffin Blvd. M3-24-305 Amery, WI 54001 715-263-2300...
Need help?
Do you have a question about the B305 and is the answer not in the manual?
Questions and answers