Summary of Contents for SUPERPURE Ultra Filter UC-05UF
- Page 1 5-Stage Ultra Filter ____________________________________________ Installation and Maintenance Manual...
- Page 2 Introduction _____________________ We would like to thank you for choosing a SUPERPURE water filter system. This is our best-selling 5-stage filtration system. Your system has been manufactured to strict quality standards to ensure you receive the best product possible. This filtration system is your first step to cleaner, healthier and better tasting water.
- Page 3 Package Contents _____________________ 1x Ultra Filter Housing Unit including Pre-filters 1x Ultra Filter Membrane 1x Filtered Water Tap with Fittings 1x Housing Wrench 1x White Food Grade Tubing 1x EZ-Feed Fitting with Ball Valve 1x Pressure Reducing Valve 1x Mini-Roll PTFE Thread Tape 1x Spare Elbow Fitting 1x User Manual Technical Specifications...
- Page 4 Before You Start _____________________ • Read through all instructions before beginning installation and using this system. Follow all steps exactly or risk damaging system/incorrect operation. • This system contains filters that need to be replaced at certain intervals. While replacement intervals will vary according to use, it is recommended to replace the pre-filters every 6-months and UF membrane every 24-months.
- Page 5 Caution _____________________ • Do not disassemble, open, or modify this unit. Tampering with the unit may cause failure or damage and will void warranty. • Do not place objects on top of the unit as this may cause damage to the unit and may cause leaking.
- Page 6 Tools Required _____________________ Drill Water Knife Pump Pliers...
-
Page 7: Installation Steps
Installation Steps Scan the QR codes with a smartphone to follow along step-by-step on companion video _____________________ Step 1 Remove the system from the box and check that the system is undamaged and all parts are included. Step 2 Check filters one-by-one to ensure filters are properly installed and o-rings are correctly seated and housings tightened. - Page 8 Step 4 Drill a 10mm hole for your filtered water tap in your countertop or sink. Install faucet and trim ring and screw on bottom nut firmly. Step 5 Connect your compression fitting parts to the pipe and screw pipe to filter tap. Step 6 Connect EZ-Feed connector and ball valve between existing water outlet and flex pipe.
- Page 9 Pre-Filter Flushing _____________________ Prepare system for operation by flushing pre-filters: Step 1 Disconnect pipe from membrane inlet. Step 2 Open water main and inlet valve and allow water to run through the 3 pre-filters. Discard output water into container or drain. Step 3 Continue flushing until output water is visibly clean.
- Page 10 The following are guidelines for scheduled filter changes, keep in mind that the frequency of filter changes may vary. If in doubt contact your local dealer or SUPERPURE technical support. • Change Pre-Filters and Inline Carbon Filter every 6 months •...
- Page 11 Trouble Shooting _____________________ Problem No water is coming out of the tap Cause There is either a valve closed or there is still air in the system Solution(s) (1) Ensure the input valve and main water lines are open (2) Ensure that no pipes are pinched (3) Ensure that there is sufficient inlet pressure (minimum 1 bar) (4) Wait a short while to ensure that any air is flushed out of the system Problem...
- Page 12 Technical Support _____________________ For any technical support queries please contact Definitive Brands Group for assistance: Email: support@definitivebrandsgroup.co.za Tel: +27 21 851 0133 Manufactured for: Definitive Brands Group Units 1-2, 5 Firgrove Way Firgrove Industrial Estate Macassar Western Cape South Africa Spare parts &...
Need help?
Do you have a question about the Ultra Filter UC-05UF and is the answer not in the manual?
Questions and answers