Gas deck oven with digital controls & steam boiler and stone (16 pages)
Summary of Contents for Trufrost GDO 1D-2T Black Italia
Page 1
USER MANUAL Gas Deck Oven with Digital Control GDO 1D-2T Black Italia GDO 2D-4T Black Italia GDO 3D-6T Black Italia...
Page 2
User Manual (Please read this manual carefully before using the product) Black Italia Series Gas Deck Ovens & Pizza Ovens Thank you for purchasing our products Please pay attention to the instructions before using this product Please read this manual properly and keep it safely for future reference ...
Page 3
User Manual II Structural Schematic Diagram 2.1 Structural Schematic Diagram (the product and the pictures are for reference only) Schematic Diagram of Single-layer Structure: Chimney Control panel Rubber leg Damper handle Door Door handle Peep-in window Schematic Diagram of Two-layer Structure: Chimney Control panel Door handle...
Page 4
User Manual Schematic Diagram of Three-layer Structure: Chimney Control panel Door Door handle Caster Observation window Damper handle 2.2 Structural performance characteristics: The gas oven comes in one, two or three deck options. It adopts liquefied petroleum gas as the heating source. Blast combustion mixes the gas and air in the correct proportion and forces them into the combustion tube in the furnace for full combustion and uniform heating.
Page 5
0.18 0~400℃ Liquefied petroleum GPO-36 – 2D Black 1060×675×11 220V 0.36 0~400℃ Liquefie d Italia petroleum GDO 1D-2T Black Italia 1330×840×650 220V Liquefied 0.28 0~400℃ petroleum GDO 2D-4T Black Italia 1330×840×1355 220V Liquefied 0.58 0~400℃ petroleum GDO 3D-6T Black Italia 1330×840×1670...
Page 6
User Manual IV Precautions 4.1 Transportation and storage During transportation, the machine shall be handled with care, and it shall not be inverted to prevent damage to the product shell and the inside. The packaged machine must not be stored in open air and it needs to be in a warehouse with good ventilation and no corrosive gas.
Page 7
User Manual voltage stabilizer 11. Before installation, please check if the voltage is normal, the safe Earth connection and there is no loose wiring. 12. Flammable and explosive articles must not be stored near the equipment. 13. The equipment shall not be stored and used in the open air, nor used in wet places. 14.
Page 8
User Manual liquefied gas cylinders, relief valves and rubber hoses must be used, and the outside of the rubber hose must be protected with iron hoses to prevent gas leakage caused by rat biting or bumping. The liquefied gas cylinders must be placed in a safe zone and min.
Page 9
User Manual 15. Do not place heavy objects on the oven. 16. Do not touch the machine directly with your hands during, before and after use. It will cause burns. 17. Do not use water jet for cleaning. Clean the stainless steel surface properly and regularly to prevent surface oxidation that will damage the equipment.
Page 10
User Manual pulse igniter will ignite. Note: Each ignition shall last about 8-10 seconds. If it takes longer, the solenoid valve will automatically close, the igniter will give an alarm and the alarm light will be on. Please turn off the ignition switch and try again. If the ignition is unsuccessful for two consecutive times, turn off the temperature control switch, open the door, ventilate for 15 minutes and then re-ignite.
User Manual 17. Avoid installing an exhaust fan above or in front of the oven door. 18. In case of uneven heating during use, it can be solved by adjusting the tray 19. After use, the machine shall be powered off for maintenance, and the baking tray shall be cleaned regularly and at least once a day.
Page 12
User Manual 1. Air intake is too large or 1. Reduce the air intake too small Sudden flameout 2. Replace the gas cylinder 2. Gas cylinder runs out of gas 3. Replace the igniter or solenoid at work 3. Igniter or solenoid valve valve damage 1.
Page 13
User Manual VIII To Users Customers are not allowed to return or replace the commercial box-type gas oven for any reason. After opening the packaging, read the product specifications carefully and follow the operation instructions, otherwise the losses caused will be borne by the customers themselves.
Page 14
User Manual Circuit Diagram of Gas Oven: The circuit diagram of single-layer gas oven is as follows:...
Page 15
User Manual Computer-controlled operation instructions: The electrical wiring diagram of the computer panel is as follows:...
6. In any of the following circumstances, the warranty will not be provided, but repair fees can be charged: Marketed globally by: TRUFROST AND BUTLER PRIVATE LIMITED 1215, 12th Floor, Tower B, Emaar Digital Greens, Golf Course Extn. Road, Sector 61, Gurugram – 122011 T.
Need help?
Do you have a question about the GDO 1D-2T Black Italia and is the answer not in the manual?
Questions and answers