Gravely Pro-Trim 22 Owner's/Operator's Manual
  1. Manuals
  2. Brands
  3. Gravely Manuals
  4. Trimmer
  5. Pro-Trim 22
  6. Owner's/operator's manual

Gravely Pro-Trim 22 Owner's/Operator's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
Pro-Trim
Owner/Operator Manual
Manuel Du Propriétaire/Utilisateur
E10
™
22
The use of any gasoline exceeding 10% ethanol (E10) or
10% MTBE will void the product warranty.
L'utilisation d'une essence contenant plus de 10% d'éthanol
(E10) ou de 10% de MTBE annulent la garantie.
ENGLISH
FRANÇAIS
Model
946153 – Pro-Trim 22
04242000A 10/12
Printed in USA

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Pro-Trim 22 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Gravely Pro-Trim 22

Summary of Contents for Gravely Pro-Trim 22

  • Page 1 Pro-Trim Owner/Operator Manual Manuel Du Propriétaire/Utilisateur Model 946153 – Pro-Trim 22 The use of any gasoline exceeding 10% ethanol (E10) or 10% MTBE will void the product warranty. L’utilisation d’une essence contenant plus de 10% d’éthanol (E10) ou de 10% de MTBE annulent la garantie.

  • Page 2: Table Of Contents

    English may be obtained from your completely read your manuals. The contents Dealer. Visit your dealer or will provide you with an understanding of www.gravely.com for a list of safety instructions and controls during normal languages available for your operation and maintenance.

  • Page 3: Safety

    Dealer for assistance. To locate your PRODUCT REGISTRATION nearest Gravely Dealer, go to www.gravely.com on the internet. The Gravely dealer must register the product at the time of purchase. Registering the WARNING: Improper assembly product will help the company process...
  • Page 4 SAFETY DECALS AND LOCATIONS IMMINENTLY DANGER: HAZARDOUS SITUATION! If ALWAYS replace missing or damaged Safety not avoided, WILL RESULT Decals. Refer to (Figure 2) below for Safety in death or serious injury. Decal locations. WARNING: POTENTIALLY HAZARDOUS SITUATION! If not avoided, COULD RESULT in death or serious injury.
  • Page 5 Keep work area clear of all persons, children dangerous projectile. Use only flexible, non- and pets. metallic line recommended by Gravely. Keep children out of the work area and under ALWAYS keep trimmer head in contact with the the watchful care of a responsible adult.
  • Page 6 A spark arrestor, if used, must Check all hardware at regular intervals, be maintained in effective working order by the especially trimmer head attachment bolts. operator. See your Gravely Dealer or engine Keep all hardware properly tightened. manufacturer’s service center. Before tipping unit, remove fuel.

  • Page 7: Assembly

    ASSEMBLY Handlebar Assembly WARNING: AVOID INJURY. 1. Loosen handlebar wing knobs. Do not Read and understand the entire remove them. Safety section before 2. Unfold handlebar to operating position. proceeding. NOTE: Adjust handlebar to a height comfortable for the operator. Be sure cable is TOOLS REQUIRED clear of pinch points.

  • Page 8: Controls And Features

    CONTROLS AND FEATURES Figure 3 1. Trimmer Head 9. Oil Dipstick and Cap 2. Trimmer Line 10.Fuel Tank and Cap 3. Upper Handlebar 11. Debris Screen 4. Lower Handlebar 12.Air Cleaner 5. Control Bail 13.Primer Bulb 6. Throttle Control Lever 14.Swivel Head Lock 7.

  • Page 9: Operation

    OPERATION CONTROLS AND FEATURES FILLING FUEL TANK See Controls and Features (Figure 3) on page 8. WARNING: AVOID INJURY. Read and understand entire Safety section before WARNING: AVOID INJURY. proceeding. Read and understand the entire Safety section before proceeding. Add fuel to Fuel Tank as needed. See your Engine Manual for correct type and grade of Trimmer Head / Trimmer Lines fuel.
  • Page 10 • Use of any gasoline other than those Stopping the Engine approved above will void the engine 1. Release control bail so that trimmer head warranty. If the pumps are not marked stops rotation. Wait until rotating parts for the content of alcohol or ethers, stop completely before leaving operator’s check ethanol and MTBE levels with position.

  • Page 11: Maintenance

    MAINTENANCE WARNING: AVOID INJURY. Read and understand the entire Wood Block Safety section before proceeding. Maintenance Schedule Service Performed Intervals (Hours) Each Check Fasteners • Figure 4 Check Trimmer Lines • Check Control Bail • CHECK FASTENERS Operation Make sure all hardware is tightened properly. Check Engine Oil •...

  • Page 12: Service And Adjustments

    5. Make sure the ends of the line extend than 4” (10.2 cm) from cutter disk. For best through the cutter disk at the same length. results, use only genuine Gravely replacement Uneven trimmer lines cause the trimmer trimmer line.
  • Page 13 HANDLEBAR HEIGHT 1. Raise the cutter head off the ground. 2. Loosen and remove capscrew, lock ADJUSTMENT washer and washer. (Figure 6) 3. Remove height guide and bottom spacer. 1. Loosen and remove both wing knobs from 4. Remove cutter disk and any of the handlebar.
  • Page 14 SWIVEL HEAD ADJUSTMENT DRIVE BELT REPLACEMENT (Figure 8) (Figure 9 & 9) 1. Stop the engine and wait for all moving parts to stop. Disconnect the spark plug wire and place it securely away from the spark plug. 2. Loosen the wing knob on the bracket at the rear of the unit.
  • Page 15 To remove the old belt: 1. Stop the engine and wait for all moving parts to stop. Disconnect the spark plug wire and place it securely away from the spark plug. 2. Place unit in service position (see Maintenance section). CAUTION: Before tipping unit, remove enough fuel so no spillage will occur.

  • Page 16: Troubleshooting

    TROUBLESHOOTING PROBLEM PROBABLE CAUSE CORRECTION Engine will 1. Spark plug wire disconnected. 1. Connect spark plug wire. not start or 2. Engine not primed 2. Prime engine. runs poorly 3. Fuel tank empty. 3. Add fuel to the fuel tank. 4.

  • Page 17: Storage

    Replacement Line of ignition. Length – in. (cm) 18 (46) Diameter – in. (cm) 5/32 (0.40) SERVICE PARTS Be sure to always use genuine Gravely parts to keep your String Trimmer running like new. Part no. Description 07236900 Drive Belt...

  • Page 18: Warranty

    Consumer Mowing Equipment Limited Warranty Ariens Company (Ariens) warrants to the original purchaser that Ariens, Gravely and Countax brand lawn and garden consumer products purchased on or after 1/1/2012 will be free from defects in material and workmanship for the time period noted in the chart below. Equipment put to personal use around a single household or residence is considered “Consumer Use”;...
  • Page 19 Exclusions – Items Not Covered by This Warranty • Parts that are not genuine Ariens, Gravely or Countax service parts are not covered by this warranty and may void the warranty. • Damages resulting from the installation or use of any part, accessory, or attachment which is not approved by the Ariens Company for use with product(s) identified herein are not covered by this warranty.
  • Page 20 OWNER'S WARRANTY RESPONSIBILITIES: is in fact defective, provided that such diagnostic work As the small off-road equipment owner, you are is performed at an authorized Ariens, Gravely, or Parker responsible for the performance of the required service representative. maintenance listed in your Owner's Manual. Ariens (7.) Throughout the evaporative emission control system's...
  • Page 22 GRAVELY 655 West Ryan Street Brillion, WI 54110 920-756-4688 Fax 920-756-2407 www.gravely.com WARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.

This manual is also suitable for:

946153

Table of Contents

Save PDF