AEM B100Z Owner's & Parts Manual

Ride-on static compactor - 1 1 / 2 ton gasoline & diesel engines

Advertisement

Quick Links

O W N E R ' S & PA R T S M A N U A L
O W N E R ' S & PA R T S M A N U A L
R I D E - O N S TAT I C C O M PA C T O R -
R I D E - O N S TAT I C C O M PA C T O R -
G A S O L I N E & D I E S E L E N G I N E S
G A S O L I N E & D I E S E L E N G I N E S
S E R I A L N U M B E R 1 0 0 - N B 2 3 - 0 0 0 0
S E R I A L N U M B E R 1 0 0 - N B 2 3 - 0 0 0 0
WARNING! READ THIS MANUAL AND
WARNING! READ THIS MANUAL AND
SAFETY MANUAL BEFORE OPERATING OR SERVICING YOUR MODEL B100.
SAFETY MANUAL BEFORE OPERATING OR SERVICING YOUR MODEL B100.
A E M
AEM ROLLER COMPACTOR
AEM ROLLER COMPACTOR
1 1
/ /
T O N
T O N
1 1
2 2

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the B100Z and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for AEM B100Z

  • Page 1 S E R I A L N U M B E R 1 0 0 - N B 2 3 - 0 0 0 0 A E M WARNING! READ THIS MANUAL AND WARNING! READ THIS MANUAL AND AEM ROLLER COMPACTOR AEM ROLLER COMPACTOR SAFETY MANUAL BEFORE OPERATING OR SERVICING YOUR MODEL B100. SAFETY MANUAL BEFORE OPERATING OR SERVICING YOUR MODEL B100.
  • Page 3: Table Of Contents

    TABLE OF CONTENTS OWNERS MANUAL OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6 MAINTENANCE .
  • Page 4: Operation

    FORWARD & SECONDARY/ REVERSE LEVER (DASH PANEL) PARKING CHOKE, THROTTLE, LEVER HYD. FLUID GAUGES WATER FUEL FUEL 63.75” REAR DRUM BALLAST FILL PLUG FRONT DRUM BALLAST FILL 9.50” CURB PLUGS CLEARANCE FRONT WALL REAR TIE DOWNS TIE DOWNS CLEARANCE .875 52.75”...
  • Page 5 CAUTION: Never over crank - if the engine does NOT start within ten (10) seconds of continuous cranking, turn the ignition key switch to the “OFF” position and wait at least thirty (30) seconds. This will allow the starter motor time to cool. Try starting the engine again. DO NOT increase the speed of the engine ABOVE the LOW rpm for a period of one (1) minute, to allow the hydraulic oil to reach operating temperature.
  • Page 6: Maintenance

    DRUM BALLAST This machine is designed for use with or without liquid ballast in the front and rear drums . If water ballast is used in temperatures below freezing , use 30% alcohol in water . If fuel oil is used, allow 10% for expansion . A pipe plug is located in each roller for filling and draining purposes, be sure to fill both front drums.
  • Page 7 SECONDARY/PARKING BRAKE Daily inspect and adjust (if necessary) brake lever next to operator . Further adjustment can be made at the brake band clevis (2) and brake rod end clevis (1) . Check and inspect brake rod . Lubricate the secondary/parking brake arm assembly found on the right side of the machine.
  • Page 8 MODEL 100 Ref No. Lubrication Point Types of Lubricant Lub. Fitting • Front Axel Bearings EP-2 Chassis Lub. • Front Pivot Tube EP-2 Chassis Lub. • Oscillating King Pin EP-2 Chassis Lub. ✓ Engine Crankcase See Engine Manual ✓ Engine Air Cleaner See Engine Manual •...
  • Page 9 STARTING DIESEL ENGINE 3 . Place the speed control lever at more than half IMPORTANT: • Do not use ether or any starting fluid for starting the engine, or a severe damage will occur . • When starting the engine after a long storage (of more than 3 months), first set the stop lever to the “STOP”...
  • Page 10 Note: • If no oil pressure immediately stop the engine and check; - if there is enough engine oil. - if the engine oil has dirt in it. - if the wiring is faulty. • If the engine does not catch or start at 1 0 seconds after the starter switch is set at “START”, wait for another 30 seconds and then begin the engine starting sequence again.
  • Page 11: Decals, Operation & Maintenance

    DECALS, OPERATION & MAINTENANCE AMERY, WISCONSIN...
  • Page 12 DECALS, OPERATION & MAINTENANCE...
  • Page 13 Optional...
  • Page 14: Front End Assembly

    FRONT END ASSEMBLY Item No. Part No. Description ............... . .Qty.
  • Page 15: Rear Drum Assembly

    REAR DRUM ASSEMBLY Item No. Part No. Description ............... . Qty.
  • Page 16: Covers, Rubber Scrapers & Cocoa Mats

    COVERS, RUBBER SCRAPERS & COCOA MATS Item No. Part No. Description ................Qty.
  • Page 18: Hydraulic System

    HYDRAULIC SYSTEM - HONDA GX 630 & KUBOTA DIESEL Z602 ENGINES Item No. Part No. Description ............... . . Qty.
  • Page 19: Electrical Schematic - Kubota Z-602 Diesel

    ELECTRICAL SCHEMATIC - KUBOTA Z-602 DIESEL REMOVE THESE WIRES WHEN USING MURPHY FUEL SHUT DOWN SYSTEM. GREEN WHITE WHITE WHITE & GREEN WHITE & BLACK BLACK PINK WHITE GRAY DETAIL A WHITE GREEN FUEL PINK STOP TIMER GREEN BLACK GREEN BLUE 9 20 WHITE...
  • Page 20 ELECTRICAL SYSTEM - W/ KUBOTA DIESEL Z602 Item No. Part No. Description ............... . . Qty.
  • Page 21: Electrical Schematic - Honda Gx630

    ELECTRICAL SCHEMATIC - W/ HONDA GX630 GREY GREEN WHITE/BLACK SPADE CONN. RO STARTER SOLENIDO-BLACK YELLOW BUTT CONN. BLACK/YELLOW WHITE WHITE/RED STRIPE GREEN PINK OPTIONAL...
  • Page 22 ELECTRICAL SYSTEM - W/ HONDA GX630 Item No. Part No. Description ............... . . Qty.
  • Page 23 56 55 39 40...
  • Page 24: Miscellaneous Components

    MISCELLANEOUS COMPONENTS Item No. Part No. Description ............... . . Qty.
  • Page 25 MISCELLANEOUS COMPONENTS (CONTINUED) 000-1036 Steering Tie Rod - (000-1464 Assembly) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 315-0019 Throttle Cable w/Tee Handle .
  • Page 26: Drum Spray System - B100 Diesel

    DRUM SPRAY SYSTEM - B100 DIESEL Item No. Part No. Description ................Qty.
  • Page 29 WATER SPRAY SYSTEM - GASOLINE ENGINES Item No. Part No. Description ............... . . Qty.
  • Page 30: Water Spray System

    WEIGHTS DRIVE Shipping Weight . . . . . . . . . . . . . . . . . . . . . . . . . . 1800 lbs . Drive System .
  • Page 31 COMPACTOR IDENTIFICATION INFORMATION COMPACTOR SERIAL NUMBER: ________________________________________________________________________________________________ ENGINE, MAKE, MODEL & SERIAL NUMBER: ___________________________________________________________________________________ PURCHASE DATE: ______________________________________________________________________________________________________________ DEALER: ________________________________________________________________________________________________________________________ PHONE #: _______________________________________________________________________________________________________________________ COMPACTOR SERVICE INFORMATION New Beuthling 465 Griffin Blvd. Amery, WI 54001 M07-23-100 715-263-2300...

Table of Contents