Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for ROPA euro-BunkerMaus 4
Summary of Contents for ROPA euro-BunkerMaus 4
- Page 1 Short Instructions Loading and Driving euro-BunkerMaus 4 Edition 1 02/2024...
- Page 2 ROPA GmbH. Any type of reproduction, distribution or storage on data medium in any form and of any type not authorised by ROPA GmbH forms a violation of current domestic and international copyright law and will be judi- cially prosecuted.
- Page 3 Contents Contents 3 / 38...
- Page 4 Contents 4 / 38...
-
Page 5: Table Of Contents
Contents Loading................7 Transport draft for low-loader transport.............9 Lashing eyes for transport by low-loader/ship.........10 Driving................13 Steps to drive a Maus................15 Battery emergency shutdown..............16 Ladder driver's cabin................16 Steering column..................17 Battery disconnect relay................17 Switches of the roof console..............18 Operating components on the floor of the driver‘s cabin......20 Start diesel engine...................21 Shut down diesel engine................. - Page 6 Loading 6 / 38...
-
Page 7: Loading
Loading Loading 7 / 38... - Page 8 Loading 8 / 38...
-
Page 9: Transport Draft For Low-Loader Transport
Loading Transport draft for low-loader transport Transport draft for low-loader transport All data in mm. 9 / 38... -
Page 10: Lashing Eyes For Transport By Low-Loader/Ship
Loading Lashing eyes for transport by low-loader/ship Lashing eyes for transport by low-loader/ship The front axle is equipped with eyes, located on the right and left side, for clamping it down in ground direction. The rear axle support is also equipped with eyes, located on the right and left side, for clamping it down in direction of the ground. - Page 11 Loading Lashing eyes for transport by low-loader/ship Lashing point behind the front axle, left side Lashing point at the rear axle support 11 / 38...
- Page 12 Driving 12 / 38...
-
Page 13: Driving
Driving Driving 13 / 38... - Page 14 Driving 14 / 38...
-
Page 15: Steps To Drive A Maus
Driving Steps to drive a Maus Steps to drive a Maus – Switch on the Power supply at the emergency switch. (See Page – Adjust the steering column (See Page – Turn on battery main switch. (See Page – Turn on the rotating beacons. Fold out and adjust the mirror. Turn on driving light. (See Page –... -
Page 16: Battery Emergency Shutdown
Driving Ladder driver's cabin Battery emergency shutdown Power supply at the emergency switch turned on ("Battery emergency shut- down") ATTENTION Danger of machine damage. If this switch is tilted upward while the ignition is on, it can lead to data loss. It may also seriously damage the exhaust gas after-treatment system (SCR system). -
Page 17: Steering Column
Driving Battery disconnect relay Steering column DANGER Hazard of deadly injuries if the steering column is moved while driving. In this case, the machine can go out of control and cause the severest damages. – Therefore, NEVER move the steering column while driving! Clamping screw (1) incline adjustment Loosen the clamping screw (1) and pull or push steering column into the desired posi- tion. -
Page 18: Switches Of The Roof Console
Driving Switches of the roof console Switches of the roof console Microphone for outside speaker system Loud-speaker radio Internal lamps on driver's cabin ceiling LED Radio with Bluetooth (see separate operating manual) Rotating switch to fold in/out the left rearview mirror Rotating switch to fold in/out the right rearview mirror Switch for rotating beacons Outlet 24V/8A maximum... - Page 19 Driving Switches of the roof console (23) Switch window wiper/washer rear window (24) Switch for LED internal lamps on driver's cabin ceiling (25) Switch ladder light (26) Battery main switch (See Page (27) Timer for park heating (optional). The timer for park heating even functions when the main battery switch is switched off.
-
Page 20: Operating Components On The Floor Of The Driver's Cabin
Driving Operating components on the floor of the driver‘s cabin Operating components on the floor of the driver‘s cabin Opener for cleaning flap Foot-switch look forward Foot switch driving direction Brake pedal Drive pedal 20 / 38... -
Page 21: Start Diesel Engine
Driving Start diesel engine Start diesel engine If the drive pedal is not in resting position during starting, then for safety reasons, trac- tion drive is blocked. The block remains until the drive pedal is completely released and pressed again. ATTENTION Risk of machine damage. -
Page 22: Shut Down Diesel Engine
Driving Operating mode change Shut down diesel engine Let the engine run for a short time idling before shutting it down. If the engine is shut down at high speed, then the turbo charger runs on after the oil pressure has already fallen. - Page 23 Driving Operating mode change ATTENTION Hazard of heavy damage to the gearbox. Please observe the above hints in any case! Damage to the gearbox caused because the above hints were not or only imprecisely complied with are excluded from any guarantee or warranty! The keys for switching between the operating modes may ONLY be used if the machine is standing completely still (0.0 km/h).
-
Page 24: Driving
Driving Driving 2.11 Driving The electronic control relieves the driver and protects the environment thanks to the automotive driving. Automotive driving means that the driving speed is preselected by the pressure on the gas pedal. The electronics control the hydrostatic drive and the diesel engine so that the preselected speed is always driven at the lowest possible engine rotational speed, independent on the fact whether you are driving uphill or downhill. - Page 25 Driving Driving Hydrostatic drives are deemed very safe. The following measure additionally increases this safety, if there should be any operating faults of the drive. If, when releasing the driving pedal, the machine should neither reduce driving speed nor stand still, then a safety circuit is activated by engaging the parking brake (1). This safety circuit bypasses the standard control behaviour of the hydraulic system and opens a safety valve that quickly shuts off the traction drive.
- Page 26 Driving Driving If it is not possible to move the vehicle, then the cause for this is shown on the colour terminal: Please release parking brake. Please release brake pedal. Compressed air brake reservoir pressure is too low! Error of the drive pedal sensors! Release pressure parking brake too low! Call customer service Supply pressure in hydrostatic drive is very low...
-
Page 27: Selection Of The Driving Direction (Forward+/Backward) In Operating Mode "Rabbit
Driving Selection of the driving direction (forward+/backward) in operating mode "Rabbit" 2.12 Selection of the driving direction (forward+/backward) in operating mode "Rabbit" Foot switch driving direction (3): NOT PRESSED driving direction „forward“ PRESSED Driving direction „backward“ Foot switch driving direction Drive pedal ADVICE The following is only for operating mode "Rabbit II": the driving pedal (5) must be... -
Page 28: Right Joystick With Multi-Functional Handle
Driving Right joystick with multi-functional handle 2.13 Right joystick with multi-functional handle The joystick enables easy control of a multitude of functions of the machine with a single hand without distracting the attention of the operator. For better orientation, a transparent sticker is located on the side window of the driver's cabin containing the following schematic overview of all functions of the joystick with multifunctional handle. - Page 29 Driving Right joystick with multi-functional handle Joystick movements Press joystick for- = Cruise control ON. ONLY in the operating ward mode "Rabbit". Pull joystick back- = cruise control OFF. ONLY in the operating ward mode "Rabbit". Pull joystick to the = Rear axle steers to the left.
-
Page 30: Steering In The Operating Mode "Rabbit
Driving Steering in the operating mode "Rabbit" 2.14 Steering in the operating mode "Rabbit" In the operating mode "Rabbit", the rear wheels may be steered by moving the joystick back and forth, if the main steering switch (44) is unlocked. When driving on public roads and paths, the main steering switch must generally be locked. -
Page 31: Manual Rear Axle Steering
Driving Steering in the operating mode "Rabbit" 2.14.1 Manual rear axle steering In the operating mode „Rabbit“, the rear axle may be steered independently from the front axle by moving the right joystick left/right. Additionally, the main steering switch unlocked. When driving in the operating mode "Rabbit"... -
Page 32: Put Rear Axle In Central Position
Driving Steering in the operating mode "Rabbit" The steering display shows: If the all-wheel steer was not activated, then the cause of it is shown on the colour terminal: – Unlock main steering switch (44) – Drive faster, the minimum speed (0.5 km/h) shouldn’t be reached. –... -
Page 33: Quick Description: Steering In The "Rabbit" Operating Mode
Driving Steering in the operating mode "Rabbit" If the rear axle is not locked in central position, then during driving in the operating mode "Rabbit II", the following warning icon is displayed on the colour terminal. 2.14.4 Quick description: steering in the "Rabbit" operating mode Start engine. - Page 34 Index 34 / 38...
-
Page 35: Index
Index Index 35 / 38... - Page 36 Index 36 / 38...
- Page 37 Index Steering column............ 17 Switching gears............ 22 Battery disconnect relay........17 Battery emergency shutdown....... 16 Transport draft............9 Driving..............24 Window wipers............. 18 Foot switch............20 Fuse box............... 18 Hand potentiometer..........28 Interior lights............18 Joystick with multi-functional handle (right)..28 Ladder driver's cabin..........
- Page 38 Index 38 / 38...
Need help?
Do you have a question about the euro-BunkerMaus 4 and is the answer not in the manual?
Questions and answers