Summary of Contents for Nortek CLEANPAK CPFFU-EC-ZA
- Page 1 ILTER CLEANPAK M CPFFU-EC-ZA ODEL NSTALLATION & O PERATION ANUAL © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 1 of 15 | 503.639.0113 | www.nortekair.com...
- Page 2 L'unité doit être installée à au moins 8 pieds du sol. LE CÂBLAGE EXTÉRIEUR DOIT ÊTRE CONFORME AUX EXIGENCES APPLICABLES AUX CIRCUITS DE CLASSE 1. © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 2 of 15 | 503.639.0113 | www.nortekair.com...
-
Page 3: Warranty
Supply and hookup of all power wiring, communication cabling, gateways, PLC, and screen setups, if applicable, are not in CLEANPAK’s scope. © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 3 of 15 | 503.639.0113 | www.nortekair.com... - Page 4 FFU does not fall or catch on anything. Because the fan unit is not permanently attached to the filter, they could separate. © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 4 of 15 | 503.639.0113 | www.nortekair.com...
- Page 5 The input power wiring into the junction box can be as follows (or follow specific site wiring requirements): black = hot © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 5 of 15 | 503.639.0113 | www.nortekair.com...
- Page 6 Refer to the Direct Networking to BMS section in the back of this manual. © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 6 of 15 | 503.639.0113 | www.nortekair.com...
- Page 7 To BMS or FFUs, Handheld max 62 Terminal Figure 5. Networking FFUs using Cat5 cables. © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 7 of 15 | 503.639.0113 | www.nortekair.com...
- Page 8 ( ) to return to the previous menu. Figure 7. Handheld Terminal Buttons © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 8 of 15 | 503.639.0113 | www.nortekair.com...
- Page 9 Press (i) to return to the Speed display to confirm the motor RPM. ▲ ▼ Figure 9. Speed adjustment via Set Intern 1 © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 9 of 15 | 503.639.0113 | www.nortekair.com...
- Page 10 FFUs on the line. Figure 10. Connecting Handheld Terminal to FFU daisy chain for auto-addressing. © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 10 of 15 | 503.639.0113 | www.nortekair.com...
- Page 11 OPTIONAL DEDICATED CONTROL SYSTEM MODULE (BY OTHERS) NAS P/N: 290-00-123 © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 11 of 15 | 503.639.0113 | www.nortekair.com...
- Page 12 The following is a suggested networking methodology and register shortlist for hookup to the BMS. NAS P/N: 290-00-124 © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 12 of 15 | 503.639.0113 | www.nortekair.com...
- Page 13 NOTE: Reason codes are only available for motor firmware versions 13.31 and higher. Check Input Register 1 (address i0, read-only) for firmware version number. © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 13 of 15 | 503.639.0113 | www.nortekair.com...
- Page 14 (holding) 40001 PIN input (controller reset) R/W (volatile) Write decimal 2143 to activate parameter changes © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 14 of 15 | 503.639.0113 | www.nortekair.com...
- Page 15 □ OR manually address each FFU through the Service port, with BUS1 and BUS2 disconnected. © Nortek Air Solutions CLEANPAK | 19855 SW 124th Ave, Tualatin, OR 97062 Last Rev: 12/13/2023 | Page 15 of 15 | 503.639.0113 | www.nortekair.com...
Need help?
Do you have a question about the CLEANPAK CPFFU-EC-ZA and is the answer not in the manual?
Questions and answers