Table of Contents
Advertisement
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Auto-Trail EXPEDITION
Summary of Contents for Auto-Trail EXPEDITION
- Page 1 CAMPERVAN EXPEDITION OWNER'S MANUAL...
-
Page 2: Table Of Contents
CONTENTS INTRODUCTION ........ENTERTAINMENT SYSTEM ....WINDOWS AND BLINDS ....WINTER CARE ........PREPARING FOR THE ROAD ..KITCHEN APPLIANCES ..... ELEVATING POP-TOP ROOF ... CAMPSITE ETIQUETTE ...... ON THE ROAD ........WHALE HEATING ......... VENTILATION ........ANNUAL CHECKLIST ......EXTERNAL FEATURES ....... -
Page 3: Introduction
For total peace of mind, all Auto-Trail vehicles registered in the UK are supplied with a comprehensive warranty. Please ensure that your dealer has explained all aspects of the warranty terms and conditions, as well as necessary servicing requirements. -
Page 4: Preparing For The Road
• Close and secure all lockers and All models manufactured by Auto-Trail are of a well-balanced design. The most common causes of poor stability Please remember that your campervan is much larger cupboard doors. -
Page 5: External Features
Tighten all nuts equally to the required torque setting. a gas regulator. This regulator provides a working gas pressure of 30mbar (1.5kg of gas per hour). All appliances installed by Auto-Trail are designed to work within this pressure range. Please ensure that EXTERNAL FEATURES any additional appliances not fitted by Auto-Trail are capable of working within this pressure. - Page 6 Please ensure that the gas system is only modified type and is installed by an approved engineer. and maintained by competent persons. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk...
-
Page 7: Electrical Services
CONNECTING VEHICLE TO MAINS SUPPLY Your Auto-Trail vehicle is supplied with an orange mains hook-up cable that will connect your campervan to a suitable power supply, via the mains hook-up point on the vehicle. - Page 8 Select Button: Use this button to select options / items or to change settings. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk...
-
Page 9: Entertainment System
The Expedition range does not feature an entertainment system as standard. However, the below instructions apply to Expedition models which have been upgraded to include a Media Pack. If you have the Media Pack, your vehicle is fitted with a dashboard mounted infotainment system that incorporates a satellite navigation system and reversing camera. -
Page 10: Kitchen Appliances
Ensure the room has sufficient ventilation when the appliance is in use. During prolonged use, additional ventilation may be needed by opening a window. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... - Page 11 5. Control panel 5a. On/off switch These instructions apply to the Expedition 68 model These instructions apply to the Expedition 66, 67 and 5b. Confirmation button only. Please see the Thetford N4080 instructions for 67 Flex models only. Please see the Thetford T2090 5c.
-
Page 12: Whale Heating
16A | 3kw | 230v AC used for more than three days, or if there is a risk of frost. is minus 15°C. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... -
Page 13: Water Services
Please note: Only a food or drug quality hose the vehicle is in the closed position. should be used to fill your freshwater tank. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... -
Page 14: Thetford Toilet (66 And 67)
Thetford cassette toilet (C223) EMPTYING THE WASTE TANK These instructions apply to the Expedition 66 and Expedition 67 models only. Please see the Thetford C402 instructions on page 27 for the Expedition 68. Your toilet has a 1-level indication for the waste holding tank. When the slide turns from green to red, the waste-holding tank is full. -
Page 15: Thetford Toilet (68)
THETFORD TOILET (68) Thetford cassette toilet (C402) USING THE TOILET These instructions apply to the Expedition 68 model only. Please see the Thetford C223 instructions on page 25 for the Expedition 66 and 67. • Run water into the bowl by pressing the flush briefly... -
Page 16: Windows And Blinds
Please note: Do not leave pleated night blinds in the closed position if the vehicle is being left in storage for any extended period of time. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... -
Page 17: Elevating Pop-Top Roof
ELEVATING POP-TOP ROOF The below instructions are relevant only for the Expedition 67 and Expedition 68 models which have a pop-top roof upgrade. Some compact models may be fitted with an elevating pop-top roof that must be raised with the front ventilation slot unzipped when the vehicle is used for habitation purposes. -
Page 18: Ventilation
When inside the vehicle, the entrance doors can be locked or unlocked via the switch on the Fiat dashboard. Pressing button A will lock all entrance doors and the LED will illuminate. Press it again to unlock all entrance doors. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... -
Page 19: Fire Safety
If any of these will indicate that the battery is settings are found to be completely flat. incorrect or if the batteries have become low, the TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... -
Page 20: General Care
A good quality car wax may be applied which will make washing even easier in the future. Abrasive cleaning agents must never be used to clean the exterior of Auto-Trail vehicles. When all the excess dirt has been removed, wash with a solution of warm water and a small amount of washing up liquid, windows can then be dried off with a window leather. -
Page 21: Winter Care
Ideally, you should rotate your be flushed through using sterilising wheels every couple of weeks try to eliminate flat spots developing. solution prior to the first use. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... -
Page 22: Campsite Etiquette
TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... -
Page 23: Annual Checklist
Make up the beds according to the manufacturer' s Check the security of fixings. Check instructions and check for rigidity and safety. the seals have not deteriorated. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk... - Page 24 Avoid confusion by making sure proper markings are used. Blue for fresh water and red for waste water. Check that the filler positions are correctly designated 'petrol', 'diesel' and 'water' as appropriate. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk...
-
Page 25: Warranty
WARRANTY TECHNICAL For total peace of mind, your Auto-Trail vehicle is covered by a comprehensive warranty on the base vehicle, the habitation compartment and the body integrity. INFORMATION For full terms and conditions, please visit the Auto-Trail website. FIAT WARRANTY The Fiat Ducato base of your Auto-Trail campervan has a two-year warranty. - Page 26 Jack up the vehicle until the wheel to be changed is just off the ground. • Remove the wheel nuts and wheel. • Fit the spare wheel and reverse the above procedure. • Tighten all nuts equally to the required torque setting. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk...
- Page 27 WIRING SCHEMATIC If the above measures do not remedy the malfunction, or if fault codes are displayed that you cannot find in this guide, please contact Truma Service. TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk...
- Page 28 The following table shows the rating and circuit allocation for the three MCBs. FUSE RATING FUSE COLOUR DESCRIPTION 10 amps White 230V sockets/cooker Extra 230V sockets/heating system/combination 16 amps White (sockets), Yellow (heater) water heater 10 amps Black (fridge) Fridge/12V charger TOGETHER WE’RE GOING PLACES For more information visit www.auto-trail.co.uk...
- Page 29 Tel: 01472 571 000 | Email: sales@auto-trail.co.uk | Web: www.auto-trail.co.uk Registered Office: Trigano House, Genesis Way, Europarc, Grimsby, North-East Lincolnshire, DN37 9TU Registered in England: 3533638 | VAT Registration: 706423457...
Need help?
Do you have a question about the EXPEDITION and is the answer not in the manual?
Questions and answers
charging battery
The leisure battery in the Auto-Trail Expedition can be charged in two ways:
1. Vehicle Alternator: The battery is charged by the vehicle's alternator when the engine is running.
2. On-board Battery Charger: When the vehicle is connected to a suitable mains supply via the hook-up cable, the on-board battery charger charges the battery. To do this:
- Locate the charger power switch on the Power Supply Unit (PSU) and switch it to "OFF" before connecting the mains supply.
- Connect the supplied orange hook-up cable to the vehicle's mains hook-up point and a suitable mains power source.
- Switch the charger power switch back to "ON" after connecting to the mains supply.
Connecting to the mains supply also activates the 230V socket and mains appliances.
This answer is automatically generated