POWERWINCH H500 Operating Instructions Manual

J
Pqrenninch'
Please read a,'d save th€se itst'ucdons.
Read <arelulty
bero're attempting
to assembte, instatt. opente
or maintain
the prcduct
described.
Protect y'ourtelf
and others hy observing
a salety intor',,'ation.
Faiture to compty with
inttructions .outd .esutt in peBonat injury andtor
propefty
damagcrc! Retain instnt<tions for futur€ .et€rEhce.
Electric Powercd Hoist
v
Description
Electric Hoist Model H500 has a double
line capacity of 500 lbs., Model H800
has a double line capaci! of 800 lbs.
and Model H880 has a double line
capacity of 880 lbs. Light duty hoists
are used for lifting and lowering loads
v e r t i c a l l y i n l i g h t i n d u n r i a l o r D o - l t -
Yourself applications. These hoists are
not intended for heavy industrial or
production applications requiring
continuous operation. The hoists lift
{reely suspended (unguided) loads on
an intermittent basis.
AWARNING
Do not use this
equipment to lift,
suPPort, or othefwise transpoft peopte
and animalt. or to suspend loads over
people.
Unpacking
When unpacking, inspect carefully for
any damage that may have occurred
during transit. Check for loose, missing
or damaged parts. Make sure any loose
fittings, bolts, etc., are tightened
before putting unit into service.
General Safety Information
Read instruction manual care{ully
before installing and operating the
norst.
All persons operating or maintaining
these hoists should be familiar with the
information presented here and are
urged to read American National
Standard (ANsl) B30.16 Safety Standard
for Overhead Hoists.
AWARIi NG
Do not
-use
hoist in
an exPtostve
atmosphere.
Before starting hoist, operator
should be familiar with operating
controls, procedures and warnings.
Do not remove or obscure the
warning decals on the hoist.
Do not use hoist to pull loads
horizontally, vertical lift only.
Not for outdoor use or use in wet
areas.
Units must be plugged into a 1 15
volt. 60 Hz,3-wire grounded outlet.
2 .
1 .
5 .
Specifications
Max. Rated Load
(Single Line/Double Line)
(Single Line/Double Line)
Max. Lift
H P
Power supply
Amp draw (no load)
Duty cycle
Control cord length
Power cord length
Limit switches
Headroom
Height
width
Length
Weight
H500
250/500 lbs.
36/18 fpm
40 ft.
'tB
115V,
1 phase, 60 HZ
6 min/hr
6 ft.
Upper paddle
9 "
7 7/8"
5
'v4"
13"
23 lbs,
HA00
400800 lbs.
36/18 fpm
40 ft.
1t2
115V,
1 phase, 60 HZ
5
10 min/hr
6 ft.
12'
Upper paddle
10-rE"
9 "
5-1n"
16"
28 lbs.
H880
400880 lbs.
36/'18 fpm
40 ft.
1n
115V,
1 phase. 60 HZ
5
10 min/hr
6 f t .
12"
Upper paddle
10- v8"
5-1t2"
28 lbs.
P8030701AV 1/96