AMS CZYS216-NG Owner's Manual

Hide thumbs

Table Of Contents

Quick Links

Download this manual

IMPORTANT

SAVE THESE

INSTRUCTIONS

WARNING:

For Outdoor Use Only.

Installation and service must be

performed by a qualified installer,

service agency,or the gas supplier.

CZYS216-NG

Owner's Manual

Read the

installation, operation

and maintenance instructions

thoroughly before installing or

servicing this equipment.

Installation and service must be

performed by a qualiﬁed installer,

service agency or gas supplier.

INSTALLER : Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

DANGER

FIRE OR EXPLOSION HAZARD

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. If odor continues,leave the area

immediately.

4.After leaving the area,call your gas

supplier or fire department.

Failure to follow these instructions could

result in fire or explosion,which could

cause property damage,personal injury,

or death.

1/18

SKU: AMS-CZYS216-NG

WARNING

The instructions shall be marked with

directions to the installer to leave them

with the consumer and to the consumer

to retain them for future reference.

Improper installation, adjustment,

alteration, service or maintenance can

cause injury or

WARNING

Do not store or use gasoline,

or other flammable vapors and liquids,

in the vicinity of this or any other

appliance.

This unit not for use with propane.

Use only with Natural gas.

property damage.

Table of Contents

Need help?

Do you have a question about the CZYS216-NG and is the answer not in the manual?

Questions and answers

Summary of Contents for AMS CZYS216-NG

Page 1 SKU: AMS-CZYS216-NG CZYS216-NG Owner's Manual IMPORTANT WARNING SAVE THESE Read the installation, operation The instructions shall be marked with and maintenance instructions directions to the installer to leave them INSTRUCTIONS thoroughly before installing or with the consumer and to the consumer servicing this equipment.
Page 2: Table Of Contents
Table of Contents Important Safety Information Natural Gas Warnings Parts List Pre-use Instructions Lighting Instructions Care and Cleaning Gas Component Connection Checks Troubleshooting Warranty WARNING : If the information in this manual is not followed exactly, a fire or explosion may result causing property damage,personal injury, or loss of life.
Page 3: Important Safety Information
IMPORTANT SAFETY INFORMATION WARNING FIRE TABLE IS FOR OUTDOOR USE ONLY IF YOU SMELL GAS: Shut off gas supply to the fire table. Extinguish any open flame. Do not try lighting any appliance. Do not touch any electrical switch, do not use any phone in your building. Immediately call your gas supplier from a neighbor’s phone.
Page 4 IMPORTANT SAFETY INFORMATION (Continued) • DO NOT store or use gasoline or other ﬂammable vapors and liquids within 25 feet (7.62m) of this or any other appliance. • DO NOT store any combustible materials in the base enclosure. • DO NOT use in an explosive atmosphere. Keep gas ﬁre table area clear and free from combustible materials, gasoline and other ﬂammable vapors and liquids.
Page 5 IMPORTANT SAFETY INFORMATION (Continued) • For appliances complying with clauses 5.20.4 and 5.20.5, a diagram with dimensions showing the manufacturers recommended position of the appliance, its supply cylinder and hose routing shall be included. At a minimum. the diagram should be in a WARNING format including a warning about tipping hazard.
Page 6 NATURAL GAS DANGERS AND WARNINGS Continued Never store or use gasoline or other volatile substance in the vicinity of this ﬁre table. Natural Gas Connection Connect a manual shut-off valve to gas supply line. Apply sealing compound or pipe thread tape of the type resistant to the action of natural gas on all male pipe threads.
Page 7: Parts List
PARTS LIST Fire Table 1 Natural Gas Hose and Quick Disconnect Lava Rock 1 Battery WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts specifically approved with this appliance may result in property damage or personal injury.
Page 8 Install the AAA battery as shown in the diagram below. Battery included. Place lava rock by hand. DO NOT dump bag out in to the tray to avoid clogging the burner with dust. Position the lava rock to a level about 1” above the t op of the burner.
Page 9 Connecting your Fire Table to the Natural Gas Source A professionally installed shut-off valve between the supply piping and the socket recommended by the National Fuel Gas Code. Socket connection must be made outdoors. Connecting the Socket Coat the gas supply pipe nipple with gas resistant pipe compound or approved Teflon PTFE tape.
Page 10 Using the Quick Connect Socket Pull back the sleeve on the quick disconnect socket and insert the unattached end of the gas hose into the socket. Release the sleeve and continue pushing the hose into the socket until the sleeve snaps into the locked position. After making all connections, perform a leak test as described on page 12 of this manual.
Page 11: Pre-Use Instructions
PRE-USE INSTRUCTIONS WARNING Before using this outdoor fire table, make sure you have read, understand and are following all information provided in the Important Safety Information section of this manual. Failure to follow those instructions can cause death, serious injury or property damage.
Page 12: Lighting Instructions
LIGHTING INSTRUCTIONS Using the Igniter 1. Read and understand all operating instructions before lighting. Ensure that all protective film has been removed from stainless burn tray prior to lighting. 2. Burner control knob must be in the “OFF” position. 3. Connect natural gas source (see above pages). 4.
Page 13: Care And Cleaning
CARE AND CLEANING Inspecting This outdoor fire table must be inspected regularly to ensure that the product is safe to use and to extend product life. WARNING DO NOT INSPECT THIS OUTDOOR FIRE TABLE UNTIL THE FIRE IS COMPLETELY OUT 1.
Page 14: Gas Component Connection Checks
GAS COMPONENT CONNECTION CHECKS If the burner will not light or stay lit, please perform the following checks. Make sure the electrode wire is correctly connected. Both elect rode wires must be fully inserted in to the igniter box. Make sure that the pilot housing is unobstructed. Clear any debris on top of the pilot housing and make sure there is no debris between the igniter pin, thermocouple and the burner tube CORRECT...
Page 15 GAS COMPONENT CONNECTION CHECKS Thermocouple Igniter Pin 3. Make sure that the igniter pin and thermocouple are correctly positioned. - The igniter pin should be pointed straight to the thermocouple. - The thermocouple should be positioned 5mm away from the burner tube. Valve Thermocouple Thermocouple Wire...
Page 16: Troubleshooting
TROUBLESHOOTING Problem: Burner will not light using igniter Possible Cause 1: Electrode and burners are wet. -Wipe dry with cloth. Possible Cause 2: Igniter battery is dead or backwards. -Check that the AAA battery is inserted correctly in the igniter (see page 10) or replace the battery.
Page 17 TROUBLESHOOTING Problem: Sudden drop in gas ﬂow, or a reduced ﬂame height Possible Cause 1: Out of gas. Call your local gas company. Possible Cause 2: Excess ﬂow safety device may have been activated. Turn control knob to “OFF”, wait 30 seconds and light outdoor ﬁre table. If flames are still too low reset the excessive flow safety device by rutning off the control knob and the gas supply.
Page 18: Warranty
WARRANTY Fire pit’s manufacturer,distributor and importer warrant fire features and accessories to be free from defects in parts and workmanship under normal use and service for a period of 1 year from the date of purchase. In the event of such defects will, at its option, repair or replace the defective product.

This manual is also suitable for:

Ams-czys216-ng