Viking Designer DECU105 Install Manual
Built-in electric cooktop
Hide thumbs
Also See for Designer DECU105:
- Install manual (16 pages) ,
- User manual (8 pages) ,
- Use and care manual (6 pages)
Table of Contents
Advertisement
INSTALLATION
INSTRUCTIONS
BUILT-IN ELECTRIC COOKTOP
IMPORTANT: PLEASE READ AND FOLLOW
•Before beginning, please read these instructions completely and carefully.
•Do not remove permanently affixed labels, warnings, or plates from the product. This may void the warranty.
•Please observe all local and national codes and ordinances.
•Please ensure that this product is properly grounded.
•The installer should leave these instructions with the consumer who should retain for local inspector's use and for
future reference.
•Installation must conform with local codes or, in the absence of codes, the National Electrical Code, ANSI/NFPA 70-
latest edition.
IN CANADA: Electrical installation must be in accordance with the current CSA C22.1 Canadian Electrical Codes Part 1
and/or local codes.
GENERAL INFORMATION
1. WARNING: The use of cabinets for storage above the appliance may result in potential burn hazard. Combustible
items may ignite, metallic items may become hot and cause burns. If a cabinet storage is to provided the risk can
be reduced by installing a range hood that projects horizontally a minimum of 5 in. beyond the bottom of the
cabinets.
2. WARNING: This appliance shall not be used for space heating. This information is based on safety considerations.
3. All openings in the wall behind the appliance in the floor under the appliance shall be sealed.
4. Keep appliance area clear and free from combustible materials, gasoline, and other flammable vapors.
5. Disconnect the electric supply to the appliance before cleaning or servicing.
6. When removing the cooktop for service and/or cleaning, disconnect AC power supply.
7. Electrical Requirement:
Listed on Specifications/Wiring Diagram Sheet - Minimum Recommended Electric Circuit.
WARNING!
ELECTRICAL GROUNDING
INSTRUCTIONS
This cooktop must be electrically grounded in
accordance with local codes or, in the absence of
codes, with the National Electrical Code,
ANSI/NFPA 70-latest edition.
1
VIKING RANGE CORPORATION
111 Front Street
Greenwood, Mississippi 38930 USA
(662) 455-1200
Advertisement
Table of Contents
Related Manuals for Viking Designer DECU105
Summary of Contents for Viking Designer DECU105
-
Page 1: General Information
If a cabinet storage is to provided the risk can be reduced by installing a range hood that projects horizontally a minimum of 5 in. beyond the bottom of the cabinets. - Page 2 SPECIFICATIONS - VECU ELECTRIC COOKTOP Description Cutout Width Cutout Height Cutout Depth Overall Width Overall Height from Bottom Overall Depth from Rear Electrical Requirements Maximum Amp Usage Surface Element Rating Approximate Shipping Weight 52 lb. (23.4 kg) SPECIFICATIONS - DECU ELECTRIC COOKTOP Description Cutout Width Minimum 28 5/8”...
-
Page 3: Electrical Requirements
ELECTRICAL REQUIREMENTS Check your local codes regarding this unit. This cooktop is supplied with a 3-wire, A.C. 208/120 volt or 120/240 volt, 60 HZ electrical system. A white (neutral) is not needed for this unit. See next section for grounding instructions. It should be fused separately. - Page 4 PROXIMITY TO SIDE CABINET INSTALLATION 1. The cooktop may be installed directly to existing base cabinets. 2. The cooktop CANNOT be installed directly adjacent to sidewalls, tall cabinets, tall appliances, or other side vertical surfaces above 36” (91.4 cm) high. There must be a minimum of 6” (15.2 cm) side clearance from the cooktop to such combustible surfaces above the 36”...
-
Page 5: Wall Installation
The bottom of the hood should be 30” (76.2 cm) min. to 36” (91.4 cm) max. above the countertop. This would typically result in the bottom of the hood being 66” (167.6 cm) to 72” (182.9 cm) above the floor. Refer to the rangehood installation instructions for further information. - Page 6 30” W. VECU TOP 30” W. VECU BURNER BOX 19” (48.3 cm) 30” W. VECU CUTOUT w/VIPR101 DOWNDRAFT 30 3/4” (78.1 cm) Indentification Label Location 5 3/4” (14.6 cm) 28 11/16” (72.9 cm) 7/8” 27” (68.6 cm) (2.2 cm) 28 3/4” (73.0 cm) 21”...
- Page 7 36” W. VECU TOP 36” W. VECU BURNER BOX 19” (48.3 cm) 36” W. VECU CUTOUT w/VIPR161 DOWNDRAFT 36 3/4” (93.3 cm) Indentification Label Location 34 5/8” (87.9 cm) 7/8” (2.2 cm) 34 3/4” (88.3 cm) 21” (53.3 cm) 6” (15.2 cm) 33”...
- Page 8 INSTALLATION OF HOLD DOWN BRACKET VECU Models Front Brackets After installating cooktop with two of the sheet metal screws (Item 1), locate the sheet metal screw hole in the rear of the burner box. Screw hold down brackets (Item 2) using the third sheet metal screw (Item 3) to the burner box.
-
Page 9: Wiring Diagram
30” W. VECU ELECTRIC COOKTOP WARNING- THIS UNIT MUST BE GROUNDED. SEE INSTALLATION INSTRUCTIONS FOR PROPER GROUNDING PROCEDURES NOTE: TRAILERS OR STRIPES WILL BE THE SECOND COLOR IN A COLOR COMBINATION WIRING DIAGRAM... - Page 10 WIRING DIAGRAM 36” W. VECU ELECTRIC COOKTOP WARNING- THIS UNIT MUST BE GROUNDED. SEE INSTALLATION INSTRUCTIONS FOR PROPER GROUNDING PROCEDURES NOTE: TRAILERS OR STRIPES WILL BE THE SECOND COLOR IN A COLOR COMBINATION...
- Page 11 DIMENSIONS DECU HEIGHT 3 1/2” (8.9 cm) 30” W. DECU TOP 30” W. DECU BURNER BOX 30 3/4” (78.1 cm) Indentification Label Location 19 11/16” (50.0 cm) 28 1/2” (72.4 cm) 4 1/2” (11.4 cm) 3 1/16” (7.7 cm) 21” (53.3 cm) Hold down bracket...
- Page 12 36” W. DECU TOP 36” W. DECU BURNER BOX 36 3/4” (93.3 cm) 19 11/16” (50.0 cm) 34 5/8” (87.9 cm) 21” (53.3 cm) Indentification Label Location 1 3/16” (3.0 cm) Hold down bracket (one on each side) 1 3/16” (3.0 cm)
- Page 13 45” W. DECU TOP 45” W. DECU BURNER BOX 19 11/16” (50.0 cm) 45” (114.3 cm) Indentification Label Location 1 3/16” (3.0 cm) 42 3/4” (108.6 cm) 21” (53.3 cm) Hold down bracket (one on each side) 1 3/16” (3.0 cm)
- Page 14 Two (2) hold brackets will be provided with your unit. After cooktop has been installed into the countertop, locate the bracket in the slots as needed (Figure 1). Place a bracket in the slots and lower until the bracket catches. (Figure 2).
- Page 15 WARNING- THIS UNIT MUST BE GROUNDED. SEE INSTALLATION INSTRUCTIONS FOR PROPER GROUNDING PROCEDURES NOTE: TRAILERS OR STRIPES WILL BE THE SECOND COLOR IN A COLOR COMBINATION 36” W. DECU ELECTRIC COOKTOP WARNING- THIS UNIT MUST BE GROUNDED. SEE INSTALLATION INSTRUCTIONS FOR PROPER GROUNDING PROCEDURES NOTE: TRAILERS OR STRIPES WILL BE THE SECOND COLOR IN A COLOR COMBINATION...
-
Page 16: Performance Checklist
All other servicing should be referred to a qualified technician. 111 Front Street • Greenwood, Mississippi 38930 USA • (662) 455-1200 F20034K VIKING RANGE CORPORATION Specifications subject to change without notice (PS042607J)