All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips 3141 785 31575 Version 1.5...
Page 2
1.0 TECHNICAL SPECIFICATION General Playback disc type: DVD, Picture-CD, SVCD, Video CD, MP3- CD, CD-R/CD-RW, WMA-CD, DVD-R, DVD- Dimensions (W x H x D): 255 x 170 x 31 mm RW, DVD+R, DVD+RW Weight: 0.97kg Power supply: 100 – 240V (AC adaptor) DC 12V (Battery) Video Playback Format: DVD / VCD / JPEG /...
Page 3
A) PANEL firmware upgrade Unzip the WDR830.ROM Drag-n-drop to USB drive Power on PET830 with AC/DC adaptor Insert USB drive to the USB port of the main set The set will detect the updated firmware Press “OK” to confirm and proceed...
Page 4
1.0 TECHNICAL SPECIFICATION Symptom: Pop up screen "FSM AGING FAIL INFO" after replacing the mainboard Cure: After replacing the mainboard or LCD, power on the set with below error message: It could be resolved by the following procedure: Press "SETUP" key on the remote control Press "RETURN"...
Page 5
2.0 SAFTETY INSTRUCTIONS WAARSCHUWING WARNING Alle IC’s en vele andere halfgeleiders zijn All ICs and many other semi-conductors are gevoelig voor electrostatische ontladingen susceptible to electrostatic discharges (ESD). (ESD). Careless handling during repair can reduce life Onzorgvuldig behandelen tijdens reparatie kan drastically.
Page 6
2.1 ESD PROTECTION When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser may be received. PREPARATION OF SERVICING Pickup Head consists of a laser diode that is very susceptible to external static electrocity. Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement, its life might be shortened.
Page 7
SAFTY NOTICE SAFTY PRECAUTIONS LEAKAGE CURRENT CHECK Plug the AC line cord directly into a 120V AC outlet (do Measure the AC voltage across the 1500 resistor. not use an isolation transformer for this check). Use an The test must be conducted with the AC switch on and AC voltmeter, having 5000 per volt or more sensitivity.
4.0 MECHANICAL INSTRUCTION Disassembly Procedure on PET830 Spare Parts Remove five screws on (5pcs) back cabinet to separate top cabinet and back cabinet. Generally open the front cabinet. Disassemble FPC from turn board on top cabinet. Disassemble connecter of speaker from main board.
Page 11
4.0 MECHANICAL INSTRUCTION After 3 and 4 procedures, we will get top cabinet assembly and back cabinet assembly. Remove three conductive (3pcs) fabrics. Disassemble FPC of TFT- LCD from turn board.
Page 12
4.0 MECHANICAL INSTRUCTION (6pcs) Remove six screws on turn board and jogging board. Disassemble connecter of TFT-LCD from turn board. Remove two screws on (2pcs) eject board. Remove all PCB boards (6pcs) on top cabinet. Remove six screws on speaker, and then remove speaker.
Page 13
4.0 MECHANICAL INSTRUCTION (6pcs) Remove six screws and sponges on TFT-LCD. (6pcs) Remove TFT-LCD and disassembly of top cabinet is ok. (4pcs) Remove four screws on driver and FFC of driver from main board. Remove top keypad board from back cabinet, and disassemble FFC from main board.
Page 14
4.0 MECHANICAL INSTRUCTION (4pcs) Remove four screws on main board. Remove six screws on (6pcs) plate metal EMI. Remove two screws on (2pcs) PCB of battery. Use tool to remove battery from back cabinet.
Page 15
4.0 MECHANICAL INSTRUCTION Finally, we will get the back cabinet.
5.0 TROUBLESHOOTING SYMPTOM: BATTERY NO POWER BATTERY CAN'T Power ON Start Check charging Check adaptor Check Battery capacity ? SET OK? function OK? power-ON OK? Check the Power-ON No Defect , return button and cable OK? set to Customer Replace Button or Replace Main Board Cable...
Page 17
5.0 TROUBLESHOOTING SYMPTOM: NO IMAGE / NO SOUND SYMPTOM: NO IMAGE OUTPUT ( THE PANEL SHOW BLUE PICTURE ) Start Check DVD Drive work ? Replace DVD Drive Check the external AV NOTE: AV Cable TYPE from outside to note Cable TYPE Exchange AV cable Inside L-Audio, R-Audio, Video, Ground...
Page 18
5.0 TROUBLESHOOTING SYMPTOM: THE DVD DRIVE DOES NOT WORK SYMPTOM: THE DVD DRIVE DOESN 'T WORK Start Check DVD-Loader Cable Reinsertion connection OK? Check the DVD-Loader Replace DVD- Loader Replace main board...
Page 19
5.0 TROUBLESHOOTING SYMPTOM: ADAPTOR CANNOT POWER ON Adaptor can not Power ON Start Check Adaptor OK? Change adaptor SET OK? Check the Power-ON Return set to Replace Main Board button and cable OK? Customer Replace Button or Cable...
Page 20
5.0 TROUBLESHOOTING SYMPTOM: REMOTE CONTROL CANNOT WORK SYMPTOM: THE REMOTE CONTROL CAN NOT WORK Start Check CABLE form bottom board to top board Cable Reinsertion connection OK? Check TOP-board OK? Replace IR receiver Replace top board Replace main board Return to custormer...
Page 21
SYMPTOM: THE USB DOESN 'T WORK Start Check USB INSERTION USB Reinsertion Add external adaptor on USB Check the external USB PET830 USB current limit Is 500mA Over spec power consumption ? Change another USB Replace main board SYMPTOM: NO SOUND FROM HEADPHONE...
Page 22
5.0 TROUBLESHOOTING SYMPTOM: LED DISPLAY FAILURE SYMPTOM: LED Display Fail Start Check CABLE form Main board to top board Cable Reinsertion connection OK? Check TOP-board OK? Replace LED Replace top board Replace main board Return to custormer...
Page 23
5.0 TROUBLESHOOTING SYMPTOM: KEY & BOTTON FAILURE SYMPTOM: Key & Botton Fail Start Check CABLE form board to Cable Reinsertion board connection OK? Check KEY board OK ? Replace KEY board Replace main board Return to custormer...
Page 28
7.0 ELECTRICAL DIAGRAM 24C04 4KBits EEPROM NIM CON TDR086L CON SPEAKER Motor Driver AUDIO-HP1 HP1 OUT BH5510KV 74HC08D CAMCLK AUDIO-HP2 Audio AMP HP2 OUT TPA6011A4 Processor Audio DAC LCD BOARD CON 128Mbits-6 CS4334(OPTIONAL) ES8380?? SDRAM AUDIO-VOLUME VIDEO APC4558 AUDIO A/V IN L/R-LINE OUT 16Mbits A/V OUT...
Page 54
7.0 ELECTRICAL DIAGRAM System Configuration CHIP FUNCTION ES8380FCA Single chip processor that handles all system control, DVD decoding and servo control. 128MBit SDRAM Data storage and frame buffer using 1 pc of 4Mx16 SDRAM 16Mbit EPROM/FLASH Program storage using 16Mbit Flash 24C04 SERIAL EE System setup configuration storage LCSx#...
Page 55
7.0 ELECTRICAL DIAGRAM Power CON DC-DC +1.8V +3.3V +5V NIM Module System Board CON Title Block Diagram Size Document Number DVBT Date: Monday, January 08, 2007 Sheet...
Page 56
7.0 ELECTRICAL DIAGRAM +3.3V 1A/600OHM/0603 VT(TP) IF-OUT(TP) 74HC08DT 0.1U/25V/0603 VS ANT VS1(+5.0V) VS2(+1.8V) 0/J/0603 VS3(+3.3V) N.C. RESET MDVBT-90038ASTY ERROR OUT 10. FRAME SYNC 11. VALID 12. MDCLOCK VT(TP) 13. MD0-0 14. MD0-1 IF-OUT(TP) 15. MD0-2 PWR_TUNER VS ANT +5V_ANT PWR_TUNER 16.
Page 64
12NC Description Remark 996510001019 MAIN PCBA PET830 FOR S/N: AY2xxxxxxxxx 100R 996510006307 MAIN PCBA PET830 FOR NEW LCD FOR S/N: AY3xxxxxxxxx or above 996510001795 MAIN PCBA PET835 FOR S/N: AY2xxxxxxxxx 100R 996510006308 MAIN PCBA PET835 FOR NEW LCD FOR S/N: AY3xxxxxxxxx or above...
Version 1.1 (3141 785 31571) • Update service manual content to include PET835 Version 1.2 (3141 785 31572) • Update service manual content to include PET830/98 Version 1.3 (3141 785 31573) • Update service manual content to include PET830/93 Version 1.4 (3141 785 31574) •...