Summary of Contents for Alfa Laval SB Carlsberg Flask
- Page 1 Instruction Manual Alfa Laval SB Carlsberg Flask ESE02966-EN3 2022-11 Original manual...
-
Page 3: Table Of Contents
Table of contents The information herein is correct at the time of issue but may be subject to change without prior notice 1. Declarations of Conformity ..............2. Safety ..................2.1. Important information ................2.2. Warning signs ..................2.3. Safety precautions ................3. -
Page 4: Declarations Of Conformity
EU Declaration Declaration Declaration of of of Conformity Conformity Conformity The Designated Company Alfa Laval Kolding A/S, Albuen 31, DK-6000 Kolding, Denmark, +45 79 32 22 00 Company name, address and phone number Hereby declare that Valve Designation SB Carlsberg Flask... - Page 5 UK Declaration Declaration Declaration of of of Conformity Conformity Conformity The Designated Company Alfa Laval Kolding A/S, Albuen 31, DK-6000 Kolding, Denmark, +45 79 32 22 00 Company name, address and phone number Hereby declare that Valve Designation SB Carlsberg Flask...
-
Page 6: Safety
2 Safety Unsafe practices and other important information are emphasised in this manual. Warnings are emphasised by means of special symbols. 2.1 Important information Always r r r ead ead the the manual manual befor before e e using using the the valve! valve! Always... -
Page 7: Safety Precautions
2 Safety All warnings in the manual are summarised on this page. Pay special attention to the instructions below to avoid serious personal injury and damage to the valve. 2.3 Safety precautions Installation: Installation: Installation: Always Always read the technical data thoroughly (see chapter 6 Technical Data) Always Never Never dismantle the Carlsberg Flask when under pressure. -
Page 8: Installation
The items refer to the Parts List and Service Kits section. 3.1 Unpacking/delivery Step 1 1 1 Step Step CAUTION CAUTION CAUTION Alfa Laval cannot be held responsible for incorrect unpacking. Carlsberg Flask 1 PC Bursting disc 1 PC Assembly key 1 PC Quick opening key... -
Page 9: Valve Assembly
3 Installation 3.3 Valve assembly Step 1 1 1 Step Step Fill the flter house with hydrophobic cotton. Step 2 2 2 Step Step Connect the filter house to the threaded connection. Make sure connection is tight. Step Step Step 3 3 3 Connect bursting disc and protection cap to clamp connection. -
Page 10: Recycling Information
- At the end of use, the equipment should be recycled according to relevant local regulations. As well as the equipment itself, any hazardous residues from the process liquid must be considered and dealt with in a proper manner. When in doubt, or in the absence of local regulations, please contact your local Alfa Laval sales company. -
Page 11: Operation
4 Operation 4.1 Operation The Carlsberg Flask is equipped with a bursting disc for safety purposes. Never operate Carlsberg Flask without bursting disc. Never Never Alfa Laval cannot be held responsible for incorrect operation. Operation range range Operation Operation range... -
Page 12: Sterilisation
4 Operation 4.2 Sterilisation The flask is filled with wort to the net capacity corresponding to approximately 80% of the total volume. Sterilisation takes place in an autoclave, on a gas burner or an electric hotplate. After sterilisation, the flask is placed in a refrigerator or a cold room in order to cool down the wort to the desired working temperature. -
Page 13: Recommended Cleaning
4 Operation 4.6 Recommended cleaning Always Always Always handle lye and acid with great care. Caustic Caustic hazar Caustic hazard! d! d! hazar Always use Always use Always Always Always Always rubber gloves! protective goggles! After use, the Carlsberg Flask should be taken apart and cleaned manually with normal detergents. -
Page 14: Maintenance
5 Maintenance 5.1 General maintenance Step 1 1 1 Step Step Always read the technical data thoroughly. Always Always See chapter 6 Technical Data Step 2 2 2 Step Step Never service the Carlsberg Flask when it is hot. Never Never Burning ning hazar... -
Page 15: Technical Data
6 Technical Data 6.1 Technical data V V V alve alve alve data data data Recommended Recommended Recommended W W W eight eight Net volume volume volume T T T otal otal volume otal volume volume Allowable Allowable Allowable pr pr pressur essure e e PS essur eight... -
Page 16: Parts List And Service Kits
7 Parts List and Service Kits... - Page 17 7 Parts List and Service Kits Parts list list Parts Parts list Pos. Denomination Filter nut large �♦ Filter top large �♦ Seal, EPDM �♦� Filter holder �♦ Filter house �♦ ♦� Seal, EPDM Membrane Q, 20 pcs O-ring, NBR �...
- Page 18 © Alfa Laval Corporate AB This document and its contents is owned by Alfa Laval Corporate AB and protected by laws governing intellectual property and thereto related rights. It is the responsibility of the user of this document to comply with all applicable intellectual property laws. Without limiting any rights related to this document, no part of this document may be copied, reproduced or transmitted in any form or by any means (electronic, mechanical, photocopying, recording, or otherwise), or for any purpose, without the expressed permission of Alfa Laval Corporate AB.
Need help?
Do you have a question about the SB Carlsberg Flask and is the answer not in the manual?
Questions and answers