Advertisement
Quick Links
Gas Range with Convection Oven
Service, Installation and Care Manual
Please read this manual completely before attempting to install or operate this equipment.
Notify carrier of damage! Inspect all components immediately.
ABOUT YOUR
IMPORTANT INFORMATION
PLEASE READ BEFORE USE!
Save These Instructions!
Parts & Service Manuals Available at:
www.servware.com
800•768•5953
FOR QUESTIONS, CONTACT THE
SERVICE DEPARTMENT AT:
service@servware.com or
800•768•5953
SGR-6B-C
UNIT ENCLOSED.
Advertisement
Subscribe to Our Youtube Channel
Related Manuals for SERV-WARE SGR-6B-C
Summary of Contents for SERV-WARE SGR-6B-C
- Page 1 Gas Range with Convection Oven Service, Installation and Care Manual Please read this manual completely before attempting to install or operate this equipment. Notify carrier of damage! Inspect all components immediately. SGR-6B-C IMPORTANT INFORMATION ABOUT YOUR UNIT ENCLOSED. PLEASE READ BEFORE USE! Save These Instructions! Parts &...
- Page 2 Service, Installation & Care Manual COMMERCIAL RANGE SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the Safety Alert Symbol. This symbol alerts you to potential hazards that can kill or injure you and others.
- Page 3 Service, Installation & Care Manual COMMERCIAL RANGE SAFETY • Do not touch any hot surfaces. • Do not use this unit for any other than intended use. • Do not use outdoors. • Always use on a firm, dry and level surface. •...
-
Page 4: Table Of Contents
GAS CONVERSION ..................7 CLEANING ...................... 7 TROUBLESHOOTING CHART ............... 8 SPECIFICATION LIST ..................9 © Copyright 2022 Serv-Ware Products Incorporated. All rights reserved. Reproduction without written permission is prohibited. BEFORE INSTALLATION • Installation of this device should be performed by professional technicians. -
Page 5: Before Installation
Service, Installation & Care Manual BEFORE INSTALLATION Clearance and positioning: • This equipment must be installed adjacent to non-combustible surfaces only with a minimum spacing of 6" from all sides. This equipment must be a distance of 6" from other equipment. The equipment must have the 4"... -
Page 6: Installation
Service, Installation & Care Manual INSTALLATION 7. A pressure regulator must be installed with this unit. Ensure that the regulator type is in agreement with the rating plate gas supply. Regulator must be upright after installation. If regulator is not level during operation, performance problems may result. -
Page 7: Operation
Service, Installation & Care Manual OPERATION CONVECTION OVEN: WIRING DIAGRAM: HL1 ...... Power indicator S4 ......Gas ignition switch HL2 ...... Motor indicator IC1 ....... Digital thermostat HL3 ...... Ignition indicator IC2 ....... Ignition module S1 ......Power on/off switch YV ...... -
Page 8: Gas Conversion
Service, Installation & Care Manual GAS CONVERSION Conversion from Natural Gas to Liquid Propane (LP) or vice versa may only be performed by the factory or its authorized service agent. CLEANING NOTE: It is important to check the machine daily. Checking the machine regularly can avoid serious accidents. -
Page 9: Troubleshooting Chart
Service, Installation & Care Manual TROUBLESHOOTING CHART PROBLEM CAUSES SOLUTIONS Adjust the relieve valve to The gas pressure is too low increase pressure The nozzle is clogged Unclog the nozzle The pilot flame can’t Connection of the thermocouple Tighten the thermocouple be ignited is loose The thermocouple is defective... -
Page 10: Specification List
Service, Installation & Care Manual SPECIFICATION LIST ELECTRIC GRIDDLE/ MODEL STYLE OPEN BURNER OVEN RATING BROILER 6 burners with 24" SGR-6B-C 120VAC, 60HZ 30,000BTU/pc*6 31,000BTU/pc*2 20,000BTU/pc*2 griddle + oven 800•768•5953 www.servware.com... - Page 11 Serv-Ware Products and upon proper installation and start-up as well as for a period of one (1) year from the original installation date or a maximum of eighteen (18) months after the shipment date from Serv-Ware Products.
- Page 12 Service, Installation & Care Manual NOTES 800•768•5953 www.servware.com...
- Page 13 Service, Installation & Care Manual NOTES 800•768•5953 www.servware.com...
- Page 14 Products LLC. 222 Hwy 58 South Kinston, NC 28504 Parts & Service Manuals Available at: www.servware.com 800•768•5953...
Need help?
Do you have a question about the SGR-6B-C and is the answer not in the manual?
Questions and answers
How do I change the thermocouple
To change the thermocouple on a SERV-WARE SGR-6B-C:
1. Turn off all gas valves before starting.
2. Locate the thermocouple near the pilot flame.
3. Disconnect the thermocouple connection from the gas control valve.
4. Remove the old thermocouple from its mounting.
5. Install the new thermocouple in the same position.
6. Tighten the thermocouple connection to the gas control valve.
7. Turn the gas back on and test the pilot flame for proper operation.
This answer is automatically generated