Advertisement
Quick Links
www.theoutdoorplus.com
(909) 460-5579
Improper installation, adjustment, alteration, service or maintenance can cause
injury or property damage. Read the installation, operating and maintenance
instructions thoroughly before installing or servicing this equipment.
Do not store or use gasoline or other flammable vapors and liquids in vicinity of
this or any other appliance.
An LP-cylinder not connected for use shall not be stored in the vicinity of this or
any other appliance.
FOR OUTDOOR
If you smell gas:
Installation must conform with local codes or, in the absence of local codes, with the
National Fuel Gas Code, ANSI Z223.1 / NFPA 54, or International Fuel Gas Code.
The appliance, when installed, must be electrically grounded in accordance with local codes or, in
the absence of local codes, with the National Electric Code, ANSI/NFPA 70, if applicable.
WWW.THEOUTDOORPLUS.COM
WARNING
USE ONLY
For Use with NATURAL or LP GAS Only
NO SOLID FUELS TO BE USED WITH THIS SYSTEM
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from appliance and immediately call your
gas supplier or fire department.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
All Weather Electronic Ignition System
WARNING
WARNING
This appliance can produce carbon monoxide which
has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space such
as a camper, tent car or home.
WARNING
DANGER
1
1
(12 Volt AC)
Owner's Manual
Installation and Operation
Certified by
Lab Test Certification
Meets: ANSI Z21.97-2014
CSA 2.41-2014
CSA C22.2 No. 3-M1998 (R2014)
CARBON MONOXIDE HAZARD
P: 909-460-5579 F: 909-460-5530
Advertisement
Related Manuals for Outdoor Plus OPT-BLW60EKIT
Summary of Contents for Outdoor Plus OPT-BLW60EKIT
- Page 1 All Weather Electronic Ignition System (12 Volt AC) Owner’s Manual www.theoutdoorplus.com (909) 460-5579 Installation and Operation Certified by Lab Test Certification Meets: ANSI Z21.97-2014 CSA 2.41-2014 CSA C22.2 No. 3-M1998 (R2014) WARNING Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.
- Page 2 AVERTISSEMENT Une installation, un ajustement, une modification, une réparation ou un entretien inapproprié peuvent être la cause de blessures ou de dommages. Veuillez lire attentivement les instructions d'installation, d'utilisation et d'entretien avant d'installer ou de réparer ce matériel. AVERTISSEMENT Ne pas entreposer ni utiliser de l'essence ni d'autres vapeurs ou liquides inflammables dans le voisinage de l'appareil, ni de tout autre appareil.
-
Page 3: Table Of Contents
Table of Contents Gas and Electrical Requirements Clearance from Combustibles Installation of Ignition System Acceptable Media for Fire Features Installation of Media in Fire Features Operation Maintenance Replacement Parts Troubleshooting WWW.THEOUTDOORPLUS.COM P: 909-460-5579 F: 909-460-5530... - Page 4 Gas Requirements Fuel Type – Before making gas connections ensure appliance being installed is compatible with the available gas type. Check the label on the appliance to confirm appliance gas type requirement. Gas Pressure – Proper input gas pressures are required for optimum appliance performance. Gas Pressure Requirements Pressure Natural Gas...
- Page 5 WWW.THEOUTDOORPLUS.COM P: 909-460-5579 F: 909-460-5530...
- Page 6 Installation Note: Installation should be done by a qualified service technician that is locally licensed. 1. In the photo at right there is a bowl with both a gas riser and an electrical conduit stubbed up inside the bowl. In this photo the gas riser is centered whereas the Gas Stub electrical is off center.
- Page 7 6a. Installation of Fire Ring - Natural Gas When installing the fire ring for natural gas applications, select a pipe nipple that is long enough to raises the fire ring level with the top of the bowl. In this order, attach the orifice, coupling and nipple onto the valve (see illustration.) apply pipe dope or Teflon tape to all threaded, connections.
-
Page 8: Acceptable Media For Fire Features
Acceptable Media for Fire Features WARNING Do not use any other material as topping media in in fire feature other that those listed below Using improper media inside a fire feature could result in damage to property or injury to persons nearby due to media ‘popping’ or ‘exploding’ due to heat List of Acceptable Media for Fire Features Lava Rock (or other Igneous Rock) NO LARGER THAN 2”... -
Page 9: Operation
Operation WARNING Do NOT use this appliance if any part has been under water. Immediately call a qualified service technician to inspect the appliance and to replace any part of the control system and any gas control which has been under water. WARNING HOT –... -
Page 10: Maintenance
Maintenance WARNING Maintenance should be done by a qualified service technician. The appliance should be inspected before use and at least annually by a qualified service technician. WARNING Ensure gas and power are shut off and appliance is cool before servicing. WARNING Any guard or protective device removed for servicing must be replaced prior to operation. -
Page 11: Troubleshooting
Troubleshooting I installed the Electronic Ignition System, turned it on and nothing happened When this occurs it is usually due to an electrical wiring / power issue. Check all your electrical connections thoroughly to ensure all wires at the transformer and inside the fire feature are connected properly. If it appears all wiring is connected properly, disconnect the wires at the fire feature, attach a Multimeter to the wires to confirm a minimum of 12 volts when the fire feature is turned on. - Page 12 12 Volt Control Panel WWW.THEOUTDOORPLUS.COM P: 909-460-5579 F: 909-460-5530...
- Page 13 Accessories 2-Hour Electronic Timer - OPT-DTM The electronic timer runs ONLY on 110V. 6" of slack are provided to ease the installation process. The timer is outdoor rated but we recommend the time to be away from wet and hot conditions. Minimum operating temperature: 32°...
Need help?
Do you have a question about the OPT-BLW60EKIT and is the answer not in the manual?
Questions and answers