Table of Contents
Advertisement
Quick Links
VS400RL-VS400SP - VS700RL-VS700SP
Please read the following instructions carefully before operating the machine and refer to them
as needed. If you do not understand a part of the user manual, please contact your MAJAR
reseller or:
USER AND SERVICE INSTRUCTION
SPARE PART LIST
– Translation of the original instructions –
SAND SPREADER
1 Route de Montréal - CS30074
11890 CARCASSONNE Cedex 9
Phone 0033 / 4 68 25 38 16
MANUAL
MAJAR
FRANCE
04/2017
Advertisement
Table of Contents
Summary of Contents for MAJAR VS400RL
- Page 1 VS400RL-VS400SP - VS700RL-VS700SP 04/2017 Please read the following instructions carefully before operating the machine and refer to them as needed. If you do not understand a part of the user manual, please contact your MAJAR reseller or: MAJAR 1 Route de Montréal - CS30074...
-
Page 2: Table Of Contents
SERIAL N°: ....In line with the goals of continuous improvement MAJAR reserves the right to change the machines without changing the sold machines. The illustrations and characteristics of this manual may vary slightly on your due to production changes. -
Page 3: Technical Data
Ø 20.5 mm INSPECTION CHECKLIST The assembly, installation and commissioning of the machine is the MAJAR reseller’s responsibility. Please read carefully the use and care manual and the safety regulations. Make sure that the indicated points of the checklist had been verified before delivery and on delivery and amended if necessary before delivering the machine to the owner. -
Page 4: Safety Regulations
REGLES DE SECURITE * Never allow anybody to go under the Sand spreader when lifted WARNING * Never go or work under the Sand spreader or its accessories unless it is blocked and in a locked position with enough security *While maneuvering on slope always work up and down, never Some illustrations may show the machine without protective across the slope... -
Page 5: Safety Stickers
SAFETY STICKERS Replace immediately if worn or damaged Move away from the machine Attention! Danger of crushing hands and feet Read carefully the instructions Identification and before using the machine conformity plate... -
Page 6: Installation And Commissioning
INSTALLATION AND COMMISSIONING The installation and commissioning of the tool are the responsibility of the MAJAR reseller. The machine must be delivered fully mounted, lubricated and adjusted to the normal operating conditions. COUPLING OF THE MACHINE WARNING Keep your hands away from the linkage... -
Page 7: Use
Check the tightening of the bolts at the tightening torque at the end of the manual. The safety is a challenge that concerns the most while designing and manufacturing this tool. However, the efforts of the constructor may be shattered due to user carelessness. The accident prevention depends on prudence and training of staff in charge of using and maintenance of the machine. - Page 8 Loading of the sand spreader Disengage the roller and close the protection flap. Loading with bucket: When you charge the sand spreader from above, empty shacking to avoid deterioration of the roller and the bearings. The sand level must not exceed the highest front part of the housing. Loading by tilting the case: Tilt progressively the case actuating the double acting remote so that the effet afin que le rabot touche le sol.
-
Page 9: Maintenance By User
MAINTENANCE BY USER DANGER Before performing service or maintenance, stop the motor, apply the handbrake and remove the key before all settings, adjustments, maintenance or disassembly. Never let anyone else to the driver’s cabin DAILY MAINTENANCE BEFORE STARTING WORK VALVE •... -
Page 10: Declaration Of Conformity
DECLARATION OF CONFORMITY The letters CE on the identification plate of this machine certify that it is conforming to EC machine directive 2006/42/CE. The Director, Jean-Luc Checa... -
Page 11: Guarantee
FRANCE SPARE PART LIST According to Article L.111-3 of the Consumer Code and of the Decree implementing the Code N°2014-1482 of 9th of December 2014, the availability duration of indispensable spare parts for use of MAJAR material is 7 years... - Page 14 Route de Montréal 11850 CARCASSONNE TELEPHONE 04 68 25 38 16...