Table of Contents
Advertisement
Quick Links
WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing
•
Do not store or use gasoline or other flammable vapors and liquids in vicinity of this or any other appliance.
•
An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
•
Do not try to light appliance.
•
Extinguish any open flame.
•
Shut off gas to appliance.
Service must be performed by a qualified service agency.
READ INSTRUCTIONS CAREFULLY: Read and follow all instructions. Place instructions in a safe place for future
reference. Do not allow anyone who has not read these instructions to assemble, light, adjust or operate the heater.
This is an unvented gas-fired portable heater. It uses air (oxygen) from the area in which it is used. Adequate
combustion and ventilation air must be provided.
United States Stove Company
227 Industrial Park Road, South Pittsburg, TN
PH: (800) 750-2723
www.usstove.com
MODEL: HF15TT / HF30TT
CYLINDER NOT INCLUDED
property damage, personal injury or loss of life.
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to www.P65warnings.ca.gov
GAS-FIRED
INFRA-RED TANK
TOP HEATER
®
854017B-2406M
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for US Stove Company HeatFast HF15TT
Summary of Contents for US Stove Company HeatFast HF15TT
- Page 1 GAS-FIRED INFRA-RED TANK TOP HEATER ® MODEL: HF15TT / HF30TT CYLINDER NOT INCLUDED WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. • Do not store or use gasoline or other flammable vapors and liquids in vicinity of this or any other appliance.
-
Page 2: General Safety Information
GENERAL SAFETY INFORMATION WARNING: YOUR SAFETY IS IMPORTANT TO YOU AND TO OTHERS, SO PLEASE READ THESE INSTRUCTIONS BEFORE YOU OPERATE THIS HEATER. GENERAL HAZARD WARNING: FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS HEATER, CAN RESULT IN DEATH, SERIOUS BODILY INJURY AND PROPERTY LOSS OR DAMAGE FROM HAZARDS OF FIRE, EXPLOSION, BURN, ASPHYXIATION, CARBON MONOXIDE POISONING, AND/OR ELECTRICAL SHOCK. - Page 3 GENERAL SAFETY INFORMATION USA 8-Hr Time weighted average (OSHA 29 CFR 1926.55 App Canada STEL (15 minutes Reg 833/1 hour WSBC) WorkSafe BC OHS Guidelines Part 5.1 and Ontario Workplaces Reg 833 50 ppm 100 ppm 15,000 pm (WSCB) 5000 pm 30,000 ppm (Reg 833) 1.0 ppm (WorkSafeBC) 5.0 ppm (Reg 833)
-
Page 4: Assembly And Hook-Up Information
ASSEMBLY AND HOOK-UP INFORMATION • Propane cylinders (tanks) are not included with these heaters. • Remove the heater from the carton. • Use only vapor withdrawal LP gas cylinders constructed for use with propane only (HD-5) and marked in accordance with the specifications for LP gas cylinders of the U.S. - Page 5 ASSEMBLY AND HOOK-UP INFORMATION 3. Align the bolt holes in the tank collar bracket with the bolt holes located in the center plate of the manifold. Using the previously removed screws, secure the center plate manifold to the collar bracket. NOTE: The heater MUST be facing away from the tank once it has been attached to the collar bracket.
- Page 6 ASSEMBLY AND HOOK-UP INFORMATION SINGLE BURNER MODEL 1. Be sure the heater is facing away from tank. Insert the regulator connector into the tank valve outlet fitting and turn left (counter clock-wise) until fully tightened. Do not overtighten. 2. Loosen the wingnut located on the venturi tube. Place the heater support around venturi and rest the bottom of the heater support on the propane cylinder.
-
Page 7: Odor Fade Warning
IMPORTANT INFORMATION ODOR FADE WARNING WARNING ASPHYXIATION HAZARD • DO NOT USE THIS HEATER FOR HEATING HUMAN LIVING QUARTERS. • DO NOT USE IN UNVENTILATED AREAS. • THE FLOW OF COMBUSTION AND VENTILATION AIR MUST NOT BE OBSTRUCTED. • PROPER VENTILATION AIR MUST BE PROVIDED TO SUPPORT THE COMBUSTION AIR REQUIREMENTS OF THE HEATER BEING USED. -
Page 8: General Information
IMPORTANT INFORMATION • Always be sensitive to the slightest gas odor. If you continue to detect any gas odor, no matter how small, treat it as a serious leak. Immediately go into action as discussed previously. ATTENTION - CRITICAL POINTS TO REMEMBER •... -
Page 9: Minimum Clearance From Combustible Materials
IMPORTANT INFORMATION E. LEAK DETECTION: Before each use of the heater check all fittings and connections with a soap solution to be sure there are no leaks. NEVER USE ANY FLAME FOR LEAK TEST. CONNECTING HEATER TO PROPANE CYLINDER: Always connect the heater to the bulk cylinder in the outdoors or in a well ventilated area. -
Page 10: Operation
OPERATION LIGHTING INSTRUCTIONS Before attempting to light the heater, check all fittings and connections with a soap solution. NEVER USE A MATCH TO CHECK FOR LEAKS. Should a gas leak occur, do not attempt to repair or use heater. Return the heater to your dealer or the address given on back page. -
Page 11: Shutdown And Storage Instructions
OPERATION SHUTDOWN AND STORAGE INSTRUCTIONS A. The bulk propane tank “ON-OFF” valve should ALWAYS be completely turned “OFF” when the heater is not in use. B. When shutting off the heater, turn the regulator knob on the heater to “OFF” (clockwise). C. - Page 12 HF15TT PARTS LIST Part # Description 81383 Control Valve Assembly 894002 Burner Head Assy 894003 Front Guard Assy 894004 Rear Guard Assy 80918 Tip Switch 80919 Thermocouple/Tip Switch Wire Assy. 831041 Wing Bolt w Fiber Washer 894005 Support Leg IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING ORIGINAL MANUFACTURERS PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM THE APPLIANCE MANUFACTURER.
- Page 13 HF30TT PARTS LIST Part # Description 81384 Control Valve Assembly 894002 Burner Head Assy 894003 Front Guard Assy 894004 Rear Guard Assy 80918 Tip Switch 80919 Thermocouple/Tip Switch Wire Assy. 831041 Wing Bolt w Fiber Washer 894006 Tank Collar Bracket IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING ORIGINAL MANUFACTURERS PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM...
-
Page 14: Service Record
SERVICE RECORD It is recommended that this unit is serviced regularly and that the appropriate Service Interval Record is completed. Service Provider: Before completing the appropriate Service Record below, please ensure you have carried out the service as described in the manufacturer’s instructions. -
Page 15: Limited Warranty
® LIMITED WARRANTY 854057 United States Stove Company warrants this product, to of purchase from an authorized retailer or distributor. the original retail purchaser only, to be free from defects This Limited Warranty does not cover any operational in material and workmanship for a period of one (1) year failures or difficulties due to normal use and wear and from the date of the initial purchase as evidenced on an tear, accident, abuse, misuse, alteration, misapplication,... - Page 16 NOTES WARNING: Never leave the heater unattended while operating. Disconnect the heater from its power source when not in use. -16-...
- Page 17 NOTES WARNING: Never leave the heater unattended while operating. Disconnect the heater from its power source when not in use. -17-...
Need help?
Do you have a question about the HeatFast HF15TT and is the answer not in the manual?
Questions and answers