Warranty service is available by returning the Craftsman Power Mower to the nearest Sears Service Centre/Department in Canada. This warranty applies only while this prod- uct is used in Canada.
Page 3
• Do not pull mower backwards unless • Do not trim excessively steep slopes. absolutely nec es sary. Always look down • Do not mow on wet grass. Reduced and behind before and while moving footing could cause slipping. backwards. •...
V. GENERAL SERVICE • Never attempt to make wheel height • Never run machine inside a closed area. adjustments while the engine is running. • Never make adjustments or repairs with • Grass catcher components are sub ject the engine (motor) running. Dis con nect the to wear, dam age, and de te ri o ra tion, spark plug wire, and keep the wire away from the plug to prevent ac ci den tal starting.
ASSEMBLY / PRE-OPERATION Read these instructions and this manual in Operator MOWING its entirety before you attempt to assemble presence POSITION or operate your new lawn mower. control bar IMPORTANT: This lawn mower is shipped LIFT WITHOUT OIL OR GASOLINE in the engine.
OPERATION KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND ALL SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your lawn mower or in literature supplied with the product.
Page 7
TO CONVERT MOWER The operation of any lawn mower can result in foreign Your lawn mower was shipped ready to be objects thrown into the used as a mulcher. To convert to bagging: eyes, which can result in • Lift rear door of the lawn mower and severe eye damage.
Page 8
BEFORE STARTING ENGINE CAUTION: Wipe off any spilled oil or fuel. Do not store, spill or use gasoline ADD OIL near an open fl ame. Your lawnmower is shipped without oil in CAUTION: Alcohol blended fuels the engine. For type and grade of oil to (called gasohol or using ethanol or metha- use, see “EN GINE”...
Page 9
MOWING TIPS MULCHING MOWING TIPS CAUTION: Do not use de-thatcher IMPORTANT: For best performance, blade attachments on your mower. Such keep mower housing free of built-up attachments are hazardous, will damage grass and trash. See “CLEANING” in the your mower and could void your warranty. Maintenance section of this manual.
MAINTENANCE BEFORE AFTER EVERY EVERY EVERY BEFORE EACH EACH 25 HOURS STORAGE HOURS OR SEASON HOURS Check for Loose Fasteners Clean / Inspect Grass Catcher * Check Tires Check Drive Wheels *** Clean Lawn Mower **** Clean under Drive Cover *** Check Drive Belt / Pulleys *** Check / Sharpen / Replace Blade Lubrication...
Page 11
LAWN MOWER Blade adapter Crankshaft keyway Always observe safety rules when per- form ing any main te nance. Lockwasher TIRES Blade • Keep tires free of gasoline, oil, or insect control chemi cals which can harm rubber. • Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage.
Page 12
NOTE: Although multi-viscosity oils AIR FILTER (5W30, 10W30 etc.) improve starting in Your engine will not run properly and may cold weather, these multi-viscosity oils will be damaged by using a dirty air fi lter. result in increased oil consumption when Replace the air fi...
• Clean engine often to keep trash from • We do not recommend using a garden accumulating. A clogged engine runs hose to clean lawn mower unless the hotter and shortens engine life. electrical system, muffl er, air fi lter and •...
STORAGE Immediately prepare your lawn mower for Operator MOWING storage at the end of the season or if the presence POSITION unit will not be used for 30 days or more. control bar LAWN MOWER When lawn mower is to be stored for a period of time, clean it thor oughly, remove FOLD all dirt, grease, leaves, etc.
Page 15
ENGINE OIL • Replace your gasoline can if your can starts to rust. Rust and/or dirt in your Drain oil (with engine warm) and replace gasoline will cause problems. with clean engine oil. (See “ENGINE” in • If possible, store your unit indoors and the Maintenance section of this manual).
TROUBLESHOOTING - See appropriate section in manual unless directed to a Sears Parts & Repair Centre. PROBLEM CAUSE CORRECTION Does not start 1. Dirty air fi lter. 1. Clean/replace air fi lter. 2. Out of fuel. 2. Fill fuel tank. 3.
Page 17
TROUBLESHOOTING - See appropriate section in manual unless directed to a Sears Parts & Repair Centre. PROBLEM CAUSE CORRECTION Loss of power 1. Rear of mower housing or 1. Raise cutting height. blade dragging in grass. 2. Cutting too much grass. 2.