Table of Contents
Advertisement
Advertisement
Table of Contents
Troubleshooting
Subscribe to Our Youtube Channel
Related Manuals for Washtech CD120
Summary of Contents for Washtech CD120
- Page 1 CD120 RACK CONVEYOR OPERATOR MANUAL...
- Page 2 Document subject to change without prior notice. Information supplied in this manual is copyright. No part of this work may be reproduced or copied in any form or by any means, electronic or mechanical without the express permission of Washtech. 4/26/2022 Washtech CD120L Operator Manual...
-
Page 3: Table Of Contents
4. Safety Instructions Installation Diagram 6. Installation Instructions Installation Checklist 9. Installation Troubleshooting 10. Operator Use Guide 11. Operator Care – Wash Zone 12. Operator Care – Curtains 13. Operator Troubleshooting 14. Schematic Diagram 15. Accessories 4/26/2022 Washtech CD120L Operator Manual... -
Page 4: Warning
Installation and servicing must be carried out by a suitably qualified person in compliance with all local codes and standards including AS/NZS 3500.1. 4/26/2022 Washtech CD120L Operator Manual... -
Page 5: Installation Diagram
Installation Diagram CD120L Installation • Part #: CD120L • Date: 22-04-2022 • Version: 4/26/2022 Washtech CD120L Operator Manual... -
Page 6: Installation Instructions
NOTE: Levels above or below the stated requirements can be expected to increase component wear and reduce the expected useful life of the dishwasher. If in doubt, it is best to consult a water specialist and have the incoming water professionally tested and treated if necessary. 4/26/2022 Washtech CD120L Operator Manual... - Page 7 We recommend consulting your local authority to ensure your site remains compliant. Installation Checklist • Complete attached Installation Checklist to ensure machine is installed and running correctly, and operator is familiar with operating procedures. 4/26/2022 Washtech CD120L Operator Manual...
-
Page 8: Installation Checklist
USE LONG CYCLE WHERE POSSIBLE DRAINING THE MACHINE DRAIN THE MACHINE DAILY SHUT-DOWN AND DAILY CLEANING CHECK WASH ELEMENTS HAVE COOLED BEFORE CLEANING WEEKLY MAINTENANCE FULL MACHINE CLEAN INCLUDING WASH/RINSE ARMS PLANNED SERVICNG IMPORTANCE OF HAVING MACHINE SERVICED REGULARLY 4/26/2022 Washtech CD120L Operator Manual... -
Page 9: Installation Troubleshooting
Machine stops and refills during the commissioning stage • Fit the curtains according to the Operator Care – curtain diagram (page 14). • Ensure the Scrap Trays are fitted in the Wash and Rinse Zones. 4/26/2022 Washtech CD120L Operator Manual... -
Page 10: Operator Use Guide
Scrape and/or rinse trays, plates & glasses in cool water. Chemical Use a good quality non foaming commercial detergent and drying agent – do not use domestic detergents which will cause the machine to foam. 4/26/2022 Washtech CD120L Operator Manual... -
Page 11: Operator Care - Wash Zone
Operator Care – Wash Zone CD120 Wash Zone • Part #: CD120 Wash Zone • Date: 22/04/2022 • Version: Daily Cleaning • Remove Scrap Trays (10) and clean with a brush and water to clear grid. • Remove Wash Pump Inlet Filter (12) and clean with a brush and water to clear grid. -
Page 12: Operator Care - Curtains
Curtains must be placed in their correct positions to work properly. They must also be the • correct way around. • Broken curtains need to be replaced promptly. Weekly Cleaning • Remove curtains from hooks. • Place each curtain into a dishrack and wash through the machine. 4/26/2022 Washtech CD120L Operator Manual... -
Page 13: Operator Troubleshooting
** For issues that are likely due to poor water quality (scale building up, filters being required on other kitchen equipment etc.), we recommend you consult a local water specialist prior to calling in a dishwasher technician. IF PROBLEMS PERSIST CONTACT MOFFAT SERVICE ON 1300 264 217 4/26/2022 Washtech CD120L Operator Manual... -
Page 14: Schematic Diagram
Schematic Diagram CD120 Schematic Diagram • Part #: 260100 • Date: 18-01-2022 • Version: 4/26/2022 Washtech CD120L Operator Manual... -
Page 15: Accessories
Accessories CD100 Accessories • Part #: CD100 ACW • Date: 18-02-2020 • Version: 4/26/2022 Washtech CD120L Operator Manual... - Page 16 ISO9001 quality management system, covering design, manufacture and final inspection, ensuring consistent high quality at all times. In line with policy to continually develop and improve its products, Washtech Ltd reserves the right to change specifications and design without prior notice.
Need help?
Do you have a question about the CD120 and is the answer not in the manual?
Questions and answers