Page 1
Service Manual ViewSonic P95f+-1 P95f+B-1 Model No. VCDTS23956-1 19” Digital Controlled Color Monitor (P95f+/B_SM_538 - Rev. 1a – May 2002) ViewSonic 381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583...
Page 2
Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes.
PRECAUTIONS AND NOTICES................1 OPERATING INSTRUCTION..................3 SPECIFICATIONS ....................4 ADJUSTMENT ......................6 CURCIT DESCRIPTION ..................11 TROUBLE SHOOTING ...................14 IC BLOCK DAIGRAM .....................21 PCB LAYOUT......................27 SCHEMATIC DIAGRAM.....................29 EXPLODED PARTS VIEW AND PARTS LIST ............30 SPARE PARTS LIST....................31 ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
The use of substitute replacement parts which do not have the same safety characteristics as specified in the parts list may create shock, fire, X-RAY radiation or other hazards. ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 5
The picture tube used in this monitor employs integral implosion protection. Replace with tube of the same type number for continue safety. Do not lift picture tube by the neck. Handle the picture tube only after discharging the high voltage completely. ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
5. This monitor has power saving function following the VESA DPMS. Be sure to connect the signal cable to the PC. 6. If your P95f/b Series color display requires service, it must be returned with the power cord. ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
MENU Key until the OSD window changed to the Factory preset window. C. The Factory preset window contains the following functional controls. Select one of the controls. Then press the Up/Down Key to adjust it's value for the optimum picture. ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 10
ROTATION, COLOR TEMPERATURE are common mode saved in the memory. Don't needed adjust it individual at every timing Mode and save in the memory. Model select: for factory only, service engineer can't change it. ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 11
Top corner H-CONVERGENCE Bottom corner T.L.PURITY V-GAIN T.R.PURITY V-OFFSET B.L.PURITY H-MOIRE REDUCE B.R.PURITY V-MOIRE REDUCE(No use) N.S.PURITY H-FOCUS BURN IN V-FOCUS DEGAUSS ROTATION MOIRE ADJ V-LINEAR SBQ DISABLE LINEAR BALANCE MAX Hfreq ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 12
D. Adjust focus VR2 to a fine horizontal line. E. Repeat step C & D. 5. Purity Adjustment A. Be sure that the display is not being exposed to any external magnetic fields. ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 13
C. According to the actual condition of appearance,Aim at corresponding position select the T.L purity , T.R purity , B.L purity , B.R purity , and N.S purity function to correct the purity circumstance. ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
This phase detector is similar to the PLL1 detector and compares the line flyback pulse at pin 1 with the oscillator saw-tooth voltage. The PLL2 detector thus compensates for the delay in the ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 15
Q705, Q706 Brightness Control CKT Q701 Vertical Dynamic Focus Control AMP BD901 Bridge Rectifier for AC Source D909 Rectifier for Start Power Supply D907 Clip Diode for Snubber CKT D906 IC901 VCC Supply ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 16
Push Pull Driver for Q911 D856 ~ D858 DC Restoration for CRT Bias Adjustment D850 , D852,D854 Protection Diode for Q801, Q802, Q803. Q850 ~ Q852 DC Restoration for CRT Bias Adjustment ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
CHECK BRIGHTNESS CIRCUIT Q705, Q706, RELATIVE CKT. Q703, Q706, Q707 RELATIVE CKT. CHECK VOLTAGE OF THE CRT CATHODE ABOUT 60V TO 70V REFER ITEM 6-2 “ABNORMAL REFER ITEM 8-2 DISPLAY” "ABNORMAL DISPLAY" ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 18
CHECK Q801 AND RELATIVE CKT R.G.B. APPROACH STANDARD 3. ABNORMAL DDC (PLUG & PLAY) CHECK IC101 PIN 5 VOLTAGE ABOUT 5V CHECK Q102 GOOD OR FAIL CHECK SIGNAL CABLE OR H802 PIN 3, 4 DATA OUTPUT ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 19
SCREEN ABOUT 500V TO 800V ABOUT 400V TO 700V LESS THAN 500V LESS THAN 400V CHECK FBT RELATIVE CIRCUIT EXCEED 800V EXCEED 700V CHECK FBT & CRT RELATIVE CIRCUIT OR REFER ITEM 7-1 ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 20
CHECK THE COLLECTOR VOLTAGE OF Q410 ABOUT 900Vpp AT FH:31KHZ OF Q403 ABOUT 1100Vpp AT FH:31KHz CHECK Q410, D412, C424, H-DY Q408, CHECK T401, T402, Q402, Q403, R449 D408, C418, C419, H-DY ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 26
IC402 TC4538 IC601 TDA8172/TDA9302 OUTPUT SUPPLY STAGE FLYBACK VOLTAGE SUPPLY GENERATOR NVERTING INPUT OUTPUT NVERTING NPUT GROUND ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 27
ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 28
I C-BUS REGISTERS HORIZONTAL AND VERTICAL SUPPLY COINCIDENCE DETECTOR X-RAY PROTECTION FREQUENCY DETECTOR REFERENCE CONTROL H/C-SYNC INPUT PLL2,PARALLELOGRAM, PLL1 AND HORIZONTAL AND POLARITY PIN UNBALANCE AND H-OUTPUT H-POSITION OSCILLATOR CORRECTION SOFT START STAGE ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 29
ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
PART NO:41A31-094 07/17/2001 07/19/2001 12/11/2001 01/02/2002 02/18/2002 03/26/2002 1/4W NOTES: This schematic,we cannot guarantee the accuracy of this information, after the date of publication and disclaims liability for changes, errors or ommissions. ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 38
FOR Signal SW901 77A411A 2 S PUSH SWITCH T401 79A 167121 H DRIVER TRANSFORMER T402 73A 147508 H LINEARITY COIL T403 79AA9B1 1 FBT BY SAMPO T404 79A 167112 GA FOCUS COUPLING COIL ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...
Page 55
TRANSISTOR BF422/PHLIPS Q852 57A 493 10 T TRANSISTOR BF422/PHLIPS Q853 57A 419 P T TRAN 2SC945P/NEC TAPING Q854 57A 419 P T TRAN 2SC945P/NEC TAPING Q855 57A 419 P T TRAN 2SC945P/NEC TAPING ViewSonic Corporation P95f+/B-1 Confidential – Do Not Copy...