Advertisement
Quick Links
INSTALLATION & OPERATING
INSTRUCTIONS
BMW MINI (2001-2006)
Quick Fit & Quick Fit Pro
Harnessbelts
Safety
through
Technology
Patents granted in
Patente wurden erteilt in
DE
3 735 077
GB
2 211 070
I
1 207 344
USA
4 854 608
Installation Operating Instructions
Questions about Installation
Package Contents
Installation
Operating
Care and Maintenance
Accessories and Spare Parts
GEPRÜFT
UND
ÜBERWACHT
TESTED
AND
INSPECTED
Edition 03/2007
2–12
3
4
5-6
7-10
10-11
11-12
Advertisement
Summary of Contents for SCHROTH MINI Quick Fit Rallye 4 Black Left
- Page 1 INSTALLATION & OPERATING INSTRUCTIONS BMW MINI (2001-2006) Quick Fit & Quick Fit Pro Harnessbelts Edition 03/2007 Safety through Technology Patents granted in Patente wurden erteilt in 3 735 077 2 211 070 1 207 344 4 854 608 2–12 Installation Operating Instructions Questions about Installation Package Contents Installation...
- Page 2 Toll Free (888) 536-8550 Phone (978) 532-1145 these warnings will create serious danger that can (978) 532-2016 lead to serious personal injury or death. Congratulations! With the purchase of this SCHROTH asm harnessbelt, you have chosen sophisticated restraint system, which represents a further advance in harness restraint technology.
- Page 3 4. Do you have a left belt for the driver’s side and/or a right belt for the passenger’s side? (See illustrations on page 5.) This SCHROTH asm harnessbelt is only suitable for adults on front outboard seating positions. SCHROTH asm harnessbelts are not intended or suited for use by children under 12 years of age, or persons who weigh less than 88 lbs (40 kg) or those who are less than 4'11"...
-
Page 4: Package Contents
SCHROTH Racing sticker point factory provided front seat belts. To use the factory installed seat belts after a SCHROTH MINI Rallye 4 belt has All MINI Rallye 4 belts re-use factory mounting been installed you must first release (un-clip) all four points of bolts for the outside lap belt mounting points the SCHROTH belt and remove it. - Page 5 Never drill or tap or make a new attachment point in the body or performance. chassis in order to mount a SCHROTH Quick Fit harness at that Weak tail strap anchor points will not withstand the forces in an location. Such attachment points are inadequate, may be accident and increase the risk of personal injury.
- Page 6 Bend and mount the SCHROTH tail strap connector as shown in the picture above left. Be sure to replace the MINI bolt with the SCHROTH bolt, washer, and spacer as pictured above. Replace the rear seat bottom cushion being sure that it is “snapped”...
- Page 7 Never strap more than one person in place, with each Inside Rear Tail Strap Mount Points harness system. Clip the SCHROTH Tail Strap end with the MINI male latch into Never wear the harness system at the same time as the the factory female receptacle as pictured above left.
- Page 8 6.2 Shorten the belt Pull the end of the strap in direction of the arrow (see illustration beside). SCHROTH offers accessory adjusting grips which can make close buckle tighten lap belt W R O N G the adjustment even more convenient (see page 18,...
- Page 9 Stowing the belts when not in use point s is attached directly to the chassis. If you use the stock 3-point belt instead of the SCHROTH harnessbelt, be sure to properly stow the SCHROTH harness Adjust the length of the inboard shoulder belt until both belt so that it is not exposed to seat tracks, liquids, sun light, or belts exert equal pressure against the upper torso.
-
Page 10: Care And Maintenance
Modified belts or such belts that have been resewn are not strong enough and are dangerous in an accident. Never modify, disassemble or repair the belts yourself. For parts that can be replaced, use only original SCHROTH Spare Parts. Only original SCHROTH Accessories may be used with the harness belt system. - Page 11 Adjusting grips for length adjuster, 4 pcs./package 00092 Spare Parts If any part of your harness needs replacement, please contact your nearest dealer. USE ONLY GENUINE SCHROTH We do not recommend to disassemble the length adjuster PARTS. during installation process. Even to run the harness belt...
- Page 12 SCHROTH Safety Products GmbH, Germany. Copyright of this part or in hole, on paper, on film or electronically is allowed only after written permission by SCHROTH Safety Products GmbH, Germany. © 2003, SCHROTH Safety Products GmbH, Arnsberg, Germany. Printed in Germany...