Table of Contents
Advertisement
DANGER! DO NOT tamper with the engine governed speed setting. Higher operating speeds are dangerous and increase the
▲
risk of personal injury and/or equipment damage. The generator supplies the correct rated frequencies and voltage only when
running at the correct governed speed. Incorrect frequency and/or voltage can damage some connected electrical loads.
Operating at excessively low speeds may result in shortened engine life. Over-speeding will invalidate the warranty.
DO NOT operate the generator when you are tired, or under the influence of alcohol, drugs or intoxicating medication.
8
DO NOT store generator with fuel in tank where Diesel vapours might reach an open flame or spark.
8
To avoid carbon monoxide poisoning DO NOT use Petrol/Diesel- powered equipment inside any of the following; Home, garage, tent,
8
camper van, mobile home, caravan or boat. This list is not exhaustive and if you are in any doubt contact your Sealey stockist.
Dispose of wast oil in accordance with local authority regulations'.
9
2. INTRODUCTION
Heavy-duty enclosed design features four wheels, a large handle at either end and lifting eye for portability. Suitable as a backup
electrical supply for your business and home. Ideal for running power tools and lighting units. Long running - up to 7.5 hours on a full
tank. Fitted with one 16A 110V, one 32A 110V and one 32A 230V socket. Powerful and reliable key start generator. Features low oil
warning light, overload protection and fuel gauge. Overall dimensions: 940 x 540 x 705mm. Noise Rating: 97dB @ 7m. Continuous/
Maximum Power Rating: 4600/5000W. Supplied with tool bag including plugs to fit sockets, screwdriver, two spanners, 12V cable with
plug clips and two start keys. This item is heavy. Extra assistance must be provided at the delivery point to help its safe delivery.
3. SPECIFICATION
Model No: ..........................................................DG5000
Continuous Power Rating:...................................4600W
Dimensions (W x D x H): .................940 x 540 x 705mm
Displacement (cc): ................................................... 418
Fuel Tank: ............................................................. 14.5L
Fuel: ..................................................................... Diesel
IP Rating: ................................................................IP23
Maximum Power Rating: .....................................5000W
Maximum Running Time: .................................... 7.5 Hrs
Motor Power: ......................................... 4.6kW/3000rpm
Motor Type: ............................................4 Stroke Diesel
Noise Rating: .........................................................97dB
Output: ............................................................ 110/230V
4. FEATURES
4.1.
STARTER SWITCH (SW) (fig.1)
4.1.1.
The engine starter switch controls the ignition. In the 'OFF' Position the ignition circuit is switched off
and the engine will not run.
4.1.2.
In the 'ON' position the engine is ready for starting.
4.1.3.
In the 'START' position (pushed against spring tension) the starter motor is engaged and the machine
will start.
4.2.
OIL WARNING SYSTEM
4.2.1.
When the pressure switch senses low oil pressure engine will stop automatically. Unless you refill with
oil the engine will not start again.(see 5.3.4)
4.3.
AC SWITCH (BREAKER) (fig.2)
4.3.1.
The AC Switch (Breaker) will turn 'OFF' automatically when the load exceeds the generator output.
4.3.2.
If AC switch turns 'OFF' then before resetting remove some of the load and keep below the rated output
of the machine.
4.3.3.
DO NOT Connect the generator to Mains AC sockets in your building – commonly known as 'back
feeding' it is extremely dangerous and illegal.
Low oil warning
light
© Jack Sealey Limited
Main Breaker
A/C and DC
fig.3
Original Language Version
fig.1
fig.2
DG5000 Issue:1 28/02/23
Advertisement
Table of Contents
