Subscribe to Our Youtube Channel
Summary of Contents for Grunbeck GENO-UV-75
- Page 1 Operation Manual GENO-UV-75 Disinfection Device Edition December 2020 Order no. 100117150000_en_054...
-
Page 2: Table Of Contents
Disinfection device GENO-UV-75 Table of contents A General ................ 1 Preface 2 How to use this operation manual 3 General safety information 4 Shipping and storage 5 Disposal B Basic information ............1 Laws, regulations, standards 2 Disinfecting effect of UV light 3 Room irradiation C Product description ............ - Page 3 Disinfection device GENO-UV-75 All rights reserved. Copyright by Grünbeck Wasseraufbereitung GmbH Printed in Germany Effective with the date of edition indicated on the cover sheet. -We reserve the right to modifications, especially with regard to technical progress- Reprints, translations into foreign languages, electronic storage or copying of this operation manual –...
- Page 4 Disinfection device GENO-UV-75 EU Declaration of Conformity This is to certify that the devices designated below comply with the safety and health require- ments of the applicable European Directive in terms of its design, construction and execution. If the systems are modified in a way not approved by us, this certificate is void.
-
Page 5: A General
Disinfection device GENO-UV-75 General 1 | Preface Thank you for opting for a Grünbeck product. Backed by dec- ades of experience in the area of water treatment, we provide customised solutions for all kind of processes. Drinking water is classified as food and requires particular care. -
Page 6: General Safety Information
Disinfection device GENO-UV-75 3 | General safety information 3.1 Symbols and Important information in this operation manual is characterised notes by symbols. Please pay particular attention to this information to ensure the hazard-free, safe and efficient handling of the sys- tem. -
Page 7: Shipping And Storage
Disinfection device GENO-UV-75 3.4 Protection from water damage Warning! In order to properly protect the installation site from water damage: a) a sufficient floor drain system must be available or b) a water stop device (see chapter C Accessories) must be in- stalled. -
Page 8: Disposal
Disinfection device GENO-UV-75 5 | Disposal Comply with the applicable national regulations. 5.1 Packaging Dispose of the packaging in an environmentally sound manner. 5.2 Product If this symbol (crossed out waste bin) is on the product, Euro- pean Directive 2012/19/EU applies to this product. This means that this product or the electrical and electronic components are not allowed to be disposed of in the household waste. -
Page 9: B Basic Information
The con- centrations of the disinfectants dosed as well as the resulting by- products are also indicated therein. Note: The disinfection system GENO-GENO-UV-75 is designed for the disinfection of pool water and must not be operated in the drinking water sector. -
Page 10: Room Irradiation
The irradiation duration results from the flow rate and the volume of the GENO-UV-75 disinfection unit. Order no. 100117150000_en_054 Author: mal-mrie G:\BA-100117150000_EN_054_GENO-UV-75.DOCX... -
Page 11: C Product Description
Possible deviations in case of special versions are commu- nicated separately, if applicable. Warning! If the GENO-UV-75 disinfection unit fails or is switched off, the pool water and the subsequent piping system can be- come contaminated with bacterial growth. - Page 12 Disinfection device GENO-UV-75 Table C-1: Technical specifications GENO-UV-75 disinfection unit Connection data Nominal connection diameter DN / R DN 50 / R 2“ Min. drain connection DN 50 Floor drain DN 100 Power supply V/Hz 230/50-60 Connected load Max. power input 0.35...
-
Page 13: Intended Use
Disinfection device GENO-UV-75 Fig. C-2: Dimensional drawing of GENO-UV-75 with optional wall bracket 3 | Intended use The GENO-UV-75 UV disinfection unit is designed for the disin- fection of pool water and must not be operated for drinking wa- ter. -
Page 14: Application Limits
4,500 operating hours have not yet been reached. • Operation manual • Sealing paste for mounting protective quartz pipe 5.2 Accessories Connection set for the GENO-UV-75 disinfection Order no. unit, consisting of: 335 850 • 2 Stainless steel pipes, each 0.50 m in length, DN 50;... - Page 15 Disinfection device GENO-UV-75 5.4 Wearing parts Order no. Wearing parts are listed below. 523 218 • UV lamp 75 W 520 153 • Sealing ring for lamp Note: Although this is a wearing part, we grant a limited war- ...
-
Page 16: D Installation
The installation instructions described below are also illustrated in fig. D-1. Mandatory regulations The installation of a GENO-UV-75 disinfection unit is a major in- tervention in the sanitary installation, and may only be carried out by an approved installation company or by individuals ex- pressly authorised by Grünbeck. -
Page 17: Preliminary Work
Disinfection device GENO-UV-75 2 | Preliminary work 1. Unpack all components. 2. Check for completeness and proper condition. 3. Set up the device at the predetermined location. Note: The safest and easiest way to mount the unit is to use the ... - Page 18 Disinfection device GENO-UV-75 3.2 Electrical connection The GENO-UV-75 disinfection unit is electrically pre-assembled. The electrical connections are featured in terminal diagram D-2. The work described here may only be performed by trained elec- tricians or electronics experts. Danger! Danger due to electrical energy! Do not connect the mains plug to the socket before you have finished this work.
-
Page 19: Terminal Connection Diagram
Disinfection device GENO-UV-75 4 | Terminal connection diagram Fig. D-2: GENO-UV 75 disinfection unit terminal connection diagram Order no. 100117150000_en_054 Author: mal-mrie G:\BA-100117150000_EN_054_GENO-UV-75.DOCX... -
Page 20: E Start-Up
Disinfection device GENO-UV-75 Start-up The work described here should resp. may only be carried out by Grünbeck's technical service/authorised service company or by specialised trained personnel. 1 | Mounting the protective quartz pipe Caution! When mounting the protective quartz pipe, ensure that it (pos. - Page 21 Disinfection device GENO-UV-75 1. Unscrew the screw-in part with spacer (pos. 7) from the brass screw connection (pos. 4). Loosen the cable gland of the screw-in part. 2. Unscrew the screw connection (pos. 4) and remove the stainless steel binder ring (pos. 3).
-
Page 22: Mounting The Uv Lamp
UV lamp with the naked eye. The UV lamp function can only be checked when wearing suitable protective goggles (see accessories Section C-5.2). 2.1 GENO-UV-75 disinfection unit 1. Insert the UV lamp (pos. 6) into the protective quartz pipe (pos. -
Page 23: F Operation
(pos. 2) lights up. The operating hours meter (pos. 1) starts counting. 1.2 Stop The GENO-UV-75 disinfection unit is switched off by the mains voltage and the lamp (pos. 2) goes out. Note: The GENO-UV-75 disinfection unit should not be switched ... -
Page 24: G Faults
Table G-1 provides an overview of the possible faults when operating the GENO-UV-75 disinfection unit, their causes and fault rectification. The GENO-UV-75 disinfection units monitor the function of the lamp. Faults are analysed using a fault signal contact. ... -
Page 25: Mechanical Destruction Of The Lamp
3 | Mechanical destruction of the lamp If the lamp has been mechanically irreparably damaged, the GENO-UV-75 disinfection unit must be disconnected from the water supply and then drained. Afterwards, the lamp protective pipe is removed from the unit and the fragments of the lamp are removed from the protective pipe. -
Page 26: Mechanical Destruction Of The Lamp And The Protective Quartz Pipe
4 | Mechanical destruction of the lamp and the protective quartz pipe If mechanical destruction of the lamp and the cladding tube has occurred at the same time, the GENO-UV-75 disinfection unit must be disconnected from the mains and dismantled. Remove the fragments of the cladding tube and the lamp through the quartz pipe mounting opening. -
Page 27: H Maintenance And Care
UV unit, is attached to this operation manual as an appendix. Note: Ensure the proper operation of your GENO-UV-75 disin- fection unit by means of regular inspection and maintenance. We recommend inspecting the units every 2 months and main- taining the unit every 12 months. - Page 28 60 min. Then drain the GENO-UV-75 disinfection unit and neutralise the chemical if necessary • Flush the GENO-UV-75 disinfection unit several times (3 - 4 x contents of the unit) with clear water through the outlet valve to remove chemical residues.
-
Page 29: Notes On The Operation Log
Disinfection device GENO-UV-75 3 | Notes on the operation log The operation log is located in the pocket at the end of this folder. When starting up the device, make sure to record all data on the cover sheet of the operation log and fill in the first column of the checklist. -
Page 30: Operation Log
GENO-UV-75 5 | Operation log Customer Name: ................Address: ............................................... GENO-UV-75 disinfection unit Serial number ............Year of construction: ..........Installed by ............Installed on ............Connection data: Drain connection DIN EN 1717 Floor drain available (Please check appropriate box) - Page 31 Disinfection device GENO-UV-75 Maintenance work on the GENO-UV-75 disinfection system Checklist Please enter measured values. Confirm checks with Yes/No or OK or enter repair work performed. Maintenance performed (date) Operating hours System checked for tightness UV lamp changed UV lamp plug checked...
- Page 32 Disinfection device GENO-UV-75 Maintenance work on the GENO-UV-75 disinfection system Checklist Please enter measured values. Confirm checks with Yes/No or OK or enter repair work performed. Maintenance performed (date) Operating hours System checked for tightness UV lamp changed UV lamp plug checked...
- Page 33 Disinfection device GENO-UV-75 Maintenance work on the GENO-UV-75 disinfection system Checklist Please enter measured values. Confirm checks with Yes/No or OK or enter repair work performed. Maintenance performed (date) Operating hours System checked for tightness UV lamp changed UV lamp plug checked...
- Page 34 Disinfection device GENO-UV-75 Maintenance work on the GENO-UV-75 disinfection system Checklist Please enter measured values. Confirm checks with Yes/No or OK or enter repair work performed. Maintenance performed (date) Operating hours System checked for tightness UV lamp changed UV lamp plug checked...
- Page 35 Disinfection device GENO-UV-75 Maintenance work on the GENO-UV-75 disinfection system Checklist Please enter measured values. Confirm checks with Yes/No or OK or enter repair work performed. Maintenance performed (date) Operating hours System checked for tightness UV lamp changed UV lamp plug checked...
- Page 36 Disinfection device GENO-UV-75 Maintenance work on the GENO-UV-75 disinfection system Checklist Please enter measured values. Confirm checks with Yes/No or OK or enter repair work performed. Maintenance performed (date) Operating hours System checked for tightness UV lamp changed UV lamp plug checked...
Need help?
Do you have a question about the GENO-UV-75 and is the answer not in the manual?
Questions and answers