Summary of Contents for Flowzone Vortex FZFAKZ
- Page 1 ® TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 VORTEX ™ 40V BATTERY POWERED MIST BLOWER 2.5-GALLON TANK CAPACITY OPERATION GUIDE Model #: FZFAKZ - 1 -...
- Page 2 THIS Mist blower IS DESIGNED TO chemicals, it is important to spray by the hose, or wand. Carry by the may cause serious injury to the OPERATE WITH ONLY FLOWZONE ® with fresh water for 3-5 minutes to handle only.
- Page 3 DO NOT RETURN Mist blower TO STORE, if you experience problems or have moving parts, breakage of parts contact FlowZone® technical questions contact our Customer Support, M-F 9am-5pm EST at and any other condition that support. (Note: Always refer to...
- Page 4 Check for FlowZone® Support. cracked deteriorated hoses, leaks, clogged nozzles Please read and follow this manual carefully to ensure and missing or damaged parts. Manuals are subject to updates.
- Page 5 265˚F (130˚C) • Recharge only with the charger protect the lithium-ion cells and batteries properly. may cause explosion. specified by FlowZone®. A charger maximize battery life. If the mist • This product contains Lithium-ion • Follow all charging instructions...
- Page 6 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 CONTENTS: ABOUT Specifications What’s Inside Parts Diagram SET UP Mist blower Assembly How to Spray Aftercare TROUBLESHOOT Common Solutions Parts & Accessories Warranty - 6 -...
- Page 7 ® suitable for delivering many kinds of chemicals and solutions. Powered by a 40V Lithium-ion battery, this mist blower results in more efficiency than a gas powered mist blower. FlowZone® VORTEX™ Specifications Heavy-duty Model Number FZFAKZ Pump Type...
- Page 8 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 WHAT’S Name Name Name INSIDE Tank Lid Mid & Front Tube Asssembly 40V Battery Charging Dock Tank Strainer Bellows Tube For part numbers and replacement 2.5-Gallon Tank U-Clip parts/accessories ComfortStraps™ Clamps please see pages 9 &...
- Page 9 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 ASSEMBLY Bring the ComfortStraps™ (4) to Take the top of the ComfortStraps™ and slide it through the loops at the top of the Lower the bottom of the Lower Housing Housing. Feed the strap under and over the strap buckle. Gently tug on the strap to tighten in (5).
- Page 10 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 ASSEMBLY Slide the rubber bumper onto the U-Clip where the threads Secure the rubber bumper by protrude from the slot below. screwing the nut in place. Repeat Continued. for the other side of the U-Clip. Place a Clamp (10) over one end of the Bellows Tube (8).
- Page 11 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 Place a Clamp on the other end of the Bellows Tube. Slide Strap the liquid delivery hose in place on the Outlet Tube. the Mid Tube (7) into this end making sure the trigger handle is facing up.
- Page 12 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 SPRAYING Mix your chemical in the Tank Fully charge the Battery (12) on the Charging Dock (13) before the (3) and place it onto the Lower first operation. You can check the charge on the Battery by using the Housing.
- Page 13 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 AFTERCARE Mist blower maintenance Cleaning the inlet filter CAUTION: Failure to properly rinse out the mist blower may cause NOTE: It is recommended you clean your inlet filter at least every other chemical residue build-up that can clog or damage internal and external time your mist blower is used.
- Page 14 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 TROUBLESHOOTING If your mist blower is not turning on or functioning as it should, visit fzspray.com/pages/troubleshoot for detailed instructions on how to properly determine the cause of the issue. To contact Technical Support, email support@wessol.com or call +1 (803)
- Page 15 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 Problem Possible Cause(s) Solution Defective charger If the LED indicator lights do not turn on or only one red LED is on after being on the charger for over 2 hours, test the charger with a multimeter.
- Page 16 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 FZAAGD XXXXX FZRAOY Comfor tStraps™ Bellows Tube Backpack straps FZZAZ FZZAZ FZZAZ FZRAOL FZRAOZ Backpack Backpack Backpack XXXXX Li-Ion TRI-ZONE™ Outlet Tube w/ straps straps straps 40V/8Ah Battery U-Clip PART NUMBER FZRAPG XXXXX 20V/5A...
- Page 17 WARRANTY WARRANTY COVERAGE WESSOL, LLC warrants to the original purchaser that the FlowZone® product will function as intended under normal use and consistent maintenance, subject to certain limitations and exclusions. At the discretion of WESSOL, LLC, we will repair or replace any parts found to be defective in material or workmanship without charge, apart from shipping and handling costs, during the covered warranty period.
- Page 18 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 EXCLUSIONS AND LIMITATIONS WESSOL, LLC only warrants products purchased from authorized distributors. Products purchased from unauthorized resellers or distributors are not subject to warranty services. The limited warranty does not cover damages, loss, or injury resulting from transportation, storage, accident, improper use, neglect, modifications, normal wear, or operation not in accordance with the instruction manual.
- Page 19 TYPHOON 3 © WESSOL, LLC 2022 OPERATION GUIDE FZVAAK-3 fzspray.com spraysquad@fzspray.com CONNECT WITH US @FZMist blower @FZSpray - 19 -...