Summary of Contents for Castex FP-1600
- Page 1 FP-1600 Water Transfer Machine Operator and Parts Manual Model No.: 609539 CASTEX 12875 RANSOM STREET HOLLAND MI 49424 U.S.A. 609638 FAX: 1–800–678–4240 Rev. 00 (01-00) CUSTOMER SERVICE: 1–800-964–9644 Home Find... Go To..
-
Page 2: Table Of Contents
E1999 Tennant Company Printed in U.S.A. This machine will provide excellent service. However, Castex is a registered United States trademark of Tennant Company. the best results will be obtained at minimum costs if: Specifications and parts are subject to change without notice. -
Page 3: Safety Precautions
– Do not pull machine by plug or cords. – Do not pull cords around sharp edges or GROUNDING PIN corners. – Do not unplug by pulling on cords. – Do not stretch cords. FP-1600 (11–99) Home Find... Go To.. -
Page 4: Machine Components
Report damages at once to carrier. Machine is use of additional extension cords. Only use fully assembled and ready for use. manufacturer’s extension cord equipped with machine which has proper capacity and is grounded. FP-1600 (12–99) Home Find... Go To.. -
Page 5: Machine Maintenance
(Figure 4). completely drained and dry. RECOMMENDED STOCK ITEMS Refer to Parts List section for recommended stock items. Stock Items are clearly identified with a bullet preceding the parts description. See example below: FIG. 4 FP-1600 (11–99) Home Find... Go To.. -
Page 6: Troubleshooting
SEALED WATER LIFT 3048 mm (120 in) POWER CORD LENGTH 15 m (50 ft) TOTAL POWER CONSUMPTION 120V, 17 A, 2040 W (Use Separate Circuits) DECIBEL RATING AT OPERATOR’S EAR, INDOORS ON CARPET 80dB(A) FP-1600 (12–99) Home Find... Go To.. -
Page 7: Electrical Diagram
ELECTRICAL DIAGRAM VAC. DISCHARGE MOTOR PUMP 12AMP CIRCUIT FLOAT BREAKER SWITCH GROUND TO PLATE VACUUM SWITCH POWER POWER CORDS CORDS FP-1600 (11–99) Home Find... Go To.. -
Page 8: Parts List
PARTS LIST RECOVERY TANK GROUP FP-1600 (11–99) Home Find... Go To.. - Page 9 SLEEVE, DRAIN HOSE DASM., DRAINHOSE STOPPER 140000 WASHER, 1/4 FLT 701061 130181 CORD, GRIP 140955 PLUG, DRAIN HOSE W/RIBS 609639 DECAL, FP-1600 140056 WASHER, 3/8IDX1.50OD 140223 SCREW, 5/16–18X3/4 230882 STRAP, DRAIN STOPPER 231034 PLATE, CASTER MOUNT 230831 KNOB, DRAIN HOSE 103065 CASTER, SWIVEL 4”...
-
Page 10: Vacuum Motor / Machine Base Group
PARTS LIST VACUUM MOTOR / MACHINE BASE GROUP FP-1600 (11–99) Home Find... Go To.. - Page 11 SCREW, 10–24X3/4 140003 DWHEEL, 10”X1.75 GRAY 140519 NUT, 10–24 KEP 103068 DBREAKER CIRCUIT 12A 230522 PLATE, MOTOR MOUNT 130670 140340 SCREW, #10–24X5/8 140022 WASHER, 3/8 INT 140501 NUT, 1/4–20 NYLK D RECOMMENDED STOCK ITEMS FP-1600 (11–99) Home Find... Go To..
-
Page 12: Discharge Pump Group
PARTS LIST DISCHARGE PUMP GROUP FP-1600 (11–99) Home Find... Go To.. - Page 13 PLATE, PUMP BLACK DHOSE, 1.62 ID 6” DGASKET, TANK CONNECTOR 608488 100029 DCLAMP, HOSE 140308 140027 WASHER, 5/16 FLT DVALVE, CHECK 210007 140015 WASHER, 5/16 SPLTLCK 230183 FITTING, 1–1/2 140223 SCREW, 5/16–18X3/4 D RECOMMENDED STOCK ITEMS FP-1600 (11–99) Home Find... Go To..
-
Page 14: Handle Group
DBRACKET, DRAIN HOSE 230696.BK 130267 CORD, 16/3X30” YELLOW 140825 SCREW, #6X1/2 140504 NUT, CONDUIT LOCK 1/2” DCORD, 16/3X50’ EXT SJT YELLOW 602596 DECAL, WARNING WET/DRY VAC 130250 DCORD, 16/3X28” YELLOW 130201 D RECOMMENDED STOCK ITEMS FP-1600 (12–99) Home Find... Go To.. -
Page 15: Floor Tool, Hoses And Squeegee Group
DHOSE, VAC 1.5X25 160466 240056.BK CHANNEL, 15” SQUEEGEE DHOSE, VAC 1.5X15’ 160465 240059 WIPING BLADE, 15” SQUEEGEE 200170 SQUEEGEE ASSEMBLY 140887 SCREW, 10–24X3/8 240200 KNOB, SQUEEGEE ASSEMBLY INCLUDED IN ASSEMBLY D RECOMMENDED STOCK ITEMS FP-1600 (02–00) Home Find... Go To..
Need help?
Do you have a question about the FP-1600 and is the answer not in the manual?
Questions and answers