Summary of Contents for Industrial Products KeeWalk
- Page 1 | 888.243.3339 www.industrialproducts.com S A F E T Y T H E H I G H E S T L E V E L KeeWalk Step Over Instructions for Use Manual...
-
Page 2: Table Of Contents
Contents SECTION CONTENTS PAGE Introduction Validity Authorised Agent Compatibility Health & Safety Familiarisation Anticipated Life Safeguarding the Instruction For Use Manual Copyright Amendment Service Step Over System ® 1.13 Use in Accordance with Regulations 1.14 Incorrect Use 1.15 Operators Duty of Care 1.16 Atmospheric Conditions 1.17... -
Page 3: Introduction
These Instructions for Use apply to the following product: this documentation can be carried out without prior notice. Step Over System ® 1.10 Modifications to The KeeWalk® Step Over System ® Authorised Agent that comes with this product. 1.11 Definition “Authorised Person”... -
Page 4: Incorrect Use
1.17 Contaminated Surfaces DANGER TO LIFE! Do not use the KeeWalk Step Over system if oil, grease or other lubricant, or growth of algae contaminates any part of the system. Use of The KeeWalk®Step Over system in any of the above conditions is forbidden 1.15 Operator’s Duty of Care... -
Page 5: Basic Safety Instructions
For Your Safety Line 2. BASIC SAFETY INSTRUCTIONS ® Step Over system can be found here. DANGER TO LIFE! It is imperative that you follow these safety instructions to avoid endangering your life and safety. Possible Danger Prevention Measures DANGER TO LIFE! during assembly or when carrying out repairs. - Page 6 Checking the Step Over System’s Components 3. Designation and function of the components for standard systems 29-7 10-7 10-76 55-7 C50-77 326-7 325-7 45-7 74-7 199-B 63-7 62-7 69-7 77-7 105-7 440-7 KGTF1 TB3-7 TB150 TRSTEPASSY...
- Page 7 Checking the Step Over System’s Components Weighted foot assembly Front guardrail upright Step module guardrails Bridge module guardrails Toe board assembly Bridge module Stair tread assembly Back upright assembly...
- Page 8 Checking the Step Over System’s Components Exploded view of system layout and location of components and sub-assemblies:...
- Page 9 Platforms for the Major Roof Types 4. The Kee Safety Step Over modules are available to suit all major roof types Step Overs for membrane/Asphalt/PVC roofs Step over shown with 440 base feet for membrane/asphalt/ PVC roofs. Roof Type Obstacle Height (mm) Obstacle Width (mm) Foot Type Part Number...
- Page 10 Platforms for the Major Roof Types The Kee Safety Step Over modules are available to suit all major roof types Concrete floors/restricted access roofs* Roof Type Obstacle Height (mm) Obstacle Width (mm) Foot Type Part Number Concrete 1000 62-7/63-7 Concrete 1000 62-7/63-7 Concrete...
-
Page 11: Assembling The Step Over
Assembling the Step Over 5. Installation should only be carried out once the design has been verified in the Step Over Configurator and the installer has been fully trained by Kee Safety. Tool list: Ratchet Electric/battery drill Electric/battery impact driver Selection of drill bits –... - Page 12 Assembling the Step Over Inserting bridge subframe tubes into uprights at obstruction STEP 2 - Repeat Step 1 for other side of stair case next phase of the build to commence. Repeating all sub sets of step 1 to build other side of platform uprights STEP 3 Inserting bridge subframe tubes into uprights at obstruction and securing walkway STEP 2...
- Page 13 Assembling the Step Over STEP 4 - Stair Case assembly STEP 5 - Stair Case assembly Locate upper tube from staircase and brace tube in the correct orientation to meet the corresponding locate stair assembly into place. steps. they are fully inserted. the other staircase.
- Page 14 Assembling the Step Over STEP 6 - Assemble the remaining handrails and toeboard STEP 7 – Fitting toe board. shown in the illustration. tighten all grub screws to 39Nm. the other staircase. STEP 7 STEP 6...
- Page 15 Assembling the Step Over STEP 8 - Leveling and finalising of treads STEP 9 - Check and recheck all grubscrews and finalise assembly ALL grubscrews than 5% difference between any two tread heights*. on annual inspection allows the inspector to see if a grub screw has come lose and needs attention. tighten.
-
Page 16: Finished Step Over
Finished Step Over 6. Step over assembled with 440-7 feet for membrane/asphalt/PVC roofs Step over assembled with 62-7/63-7 feet for concrete roofs Step over assembled with Top Fix baseplates for metal profile roofs METAL PROFILE ROOF APPLICATION... - Page 17 Kee Walk Step Over System Recertification 7. KEE WALK STEP OVER SYSTEM RECERTIFICATION Any galvanised components showing signs of corrosion should be wire brushed thoroughly photographs and include these in the inspection report.
- Page 18 KeeWalk Step Over ® Overend Road Cradley Heath sales@industrialproducts.com | 888.243.3339 www.industrialproducts.com...