StreamLight 18650 USB CHARGER KIT - USB Li-ion Battery Charger Manual

OPERATING INSTRUCTIONS FOR THE STREAMLIGHT 18650 USB LI-ION BATTERY CHARGER

CHARGER

The 18650 USB Li-Ion battery charger can charge one or two batteries at the same time. The charger is equipped with dual power input ports. The overlapping design prevents both the 5V USB input and the 12VDC vehicle input to be connected at the same time. An AC/USB adapter with custom USB cable or custom USB cable only is supplied to attach to the charger. Place the small micro-USB plug of the custom USB cable (SL logo up) into the USB connector sleeve (marked with SL logo) that is located on the base of the charger. The micro-USB plug and connector on the charger base are keyed and contain a locking feature and will "snap" into place. Connect the AC/USB power supply to a wall outlet or connect the cord only model to any other standard, powered USB outlet.

CHARGING

NOTE:
Fully charge batteries before use. The batteries may be stored in the charger continuously, there is no danger of overcharge.

To charge the 18650 battery, insert it into either battery location in the charger. Place the negative end of the battery into the spring end of the charger (polarity is also marked in the battery cradle). The LED below the negative end of the battery should light to indicate charging has begun.

LED CHARGE INDICATORS

The red LED on the charger housing must light to ensure the battery is being charged.

Charge time is approximately 3.5 hours for one battery or 6.5 hours for two batteries when using Streamlight AC adapters or 12VDC input. When charging from a PC or other limited USB power source, charge time may increase due to reduced power available from the USB power source. NOTE: When charging two batteries at the same time, the left location has priority and will complete the charge process first.

Maximum charging temperature range is 20°F to 115°F with optimal temperature range between 50°F and 86°F. A safety circuit prevents charging outside the maximum range and the red charge LED will pulse rapidly. When temperature is within an acceptable range charging will resume.

CHARGER MOUNTING

The charger is designed to rest on a table top. Mounting holes have been provided for #8 self-tapping screws for optional mounting.

Before mounting a Streamlight charger in a vehicle, please read the following sections

INSTALLATION IN VEHICLES

An optional 12V DC power cord (P/N 22051) equipped with a cigarette plug is available for mounting a Streamlight charger in a vehicle. The cigarette plug can be removed and the wires can be attached directly to a power source for a more permanent installation. (A two amp fuse must be used on the positive lead.) NOTE: USB input cord must be disconnected from the charger before attempting to plug in the 12VDC power cord to the charger.

Before making electrical connections in a vehicle, keep in mind that a shorted auto battery can easily start a fire. Make all connections with insulated lugs or other connectors intended for such use. Be sure that your installation is fused.

The striped power lead is positive and the unmarked lead is negative. When connecting the charger to a fuse block, the striped, positive power lead goes to the connector that is dead when the vehicle's fuse is removed. The charger body is electrically isolated from the charge circuit and allows positive ground installations. The charger is polarity protected, and if connected in reverse polarity, simply won't operate until connected properly.

Streamlight recommends connecting the charger to an unswitched source of power to ensure the batteries are always fully charged. If the vehicle will not be driven for several days, the batteries should be removed from the charger to avoid vehicle battery drain. Charging two batteries with the 18650 USB battery charger will draw about.5 amperes for up to 6.5 hours during charging. The charger will draw less than.01 amperes when in maintenance mode once the batteries are fully charged.

USB 18650 Li-Ion BATTERY

The USB 18650 Button Top Li-Ion battery includes a micro USB port built into the battery that allows the battery to be charged without the battery cradle. Insert the micro-USB plug into the battery to charge the battery. Charge indicators on the top of the battery will light.

BATTERY CHARGE INDICATORS

• Charging - Red LED is on steady.
• Charged - Green LED is on steady.

Charge time is approximately 5.5 hours.

Streamlight's Limited Lifetime Warranty

Streamlight warrants this product to be free of defects for a lifetime of use except for batteries and bulbs, abuse and normal wear. We will repair, replace or refund the purchase price of this product should we determine it to be defective. This limited lifetime warranty also excludes rechargeable batteries, chargers, switches and electronics which have a 2 year warranty with proof of purchase. THIS IS THE ONLY WARRANTY, EXPRESSED OR IMPLIED, INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. INCIDENTAL, CONSEQUENTIAL OR SPECIAL DAMAGES ARE EXPRESSLY DISCLAIMED EXCEPT WHERE SUCH LIMITATION IS PROHIBITED BY LAW.

You may have other specific legal rights which vary by jurisdiction. Go to www.streamlight.com/support for a complete copy of the warranty, and information on product registration and the location of authorized service centers. Retain your receipt for proof of purchase.