Page 1
All manuals and user guides at all-guides.com HISTORY Model Name KDL-32/40U2520 SERVICE MANUAL Click on Page Number to display detail of changes. Date Part Number Description of Revisions Version 2007.08 9-927-575-01 Original Manual. 9-927-575-02 Part number change - section 5 (P71) and addition 2008.01...
Page 2
All manuals and user guides at all-guides.com SE-1 RM-ED007 SERVICE MANUAL SE-1 CHASSIS MODEL MODEL COMMANDER DEST COMMANDER DEST KDL-32U2520 KDL-40U2520 RM-ED007 RM-ED007 KDL-32U2520 / KDL-40U2520 RM-ED007 FLAT PANEL COLOR TV - 1 -...
DUE TO LIVE CHASSIS, THE CHASSIS OF THIS RECEIVER IS PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE DIRECTLY CONNECTED TO THE POWER LINE. THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...
All manuals and user guides at all-guides.com SE-1 RM-ED007 CONNECTORS 21 Pin Connector (SCART) Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A...
Page 7
All manuals and user guides at all-guides.com SE-1 RM-ED007 HDMI Connector Pin No Signal Assignment Pin No Signal Assignment TMDS Data2+ TMDS Clock Shield TMDS Data2 Shield TMDS Clock- TMDS Data2- TMDS Data1+ Reserved (N.C. on device) TMDS Data1 Shield TMDS Data1- TMDS Data0+ DDC/CEC Ground...
All manuals and user guides at all-guides.com SE-1 RM-ED007 SE-1 SELF DIAGNOSTIC SOFTWARE The identification of errors within the SE-1 chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.
All manuals and user guides at all-guides.com SE-1 RM-ED007 SECTION 3 CIRCUIT ADJUSTMENTS 3-1. Electrical Adjustments Service adjustments to this model can be performed using the supplied remote Commander RM-ED007. How to enter into the Service Mode Turn on the main power switch. Press the following sequence of buttons on the Remote Commander.
Page 16
All manuals and user guides at all-guides.com SE-1 RM-ED007 SOUND ERROR MENU E02: Reserved (0, 255) (0, 511) E03: DC Fail (0, 255) (-128, -1) (+0, +127) E04: PANEL DET (0, 255) E05: NVM (0, 255) (+0, +127) E06: IIC (0, 255) (-128, -1) E07: HDMI...
All manuals and user guides at all-guides.com SE-1 RM-ED007 3-2. TEST MODE 2 Test Mode 2 is available by setting the TV for operation in Service Mode [ As shown on Page 21 ] , OSD ‘TT’ appears. The functions de- scribed below are available by selecting the two numbers.
13. M (Default value) is shown when AM sound is demodulated in MSP; A is shown when AFRIC demodulator is used (TT63). 14. S is shown when a SONY tuner is selected; P is shown when a PHILIPS tuner is selected (TT55).
All manuals and user guides at all-guides.com 4-1. BLOCK DIAGRAMS (1) TU1300 TUNER BLOCK TUNER ANALOG AGC SW TU AGC 12C SCL SW 12C SDA SW SW1201 ANALOG IF BLOCK AUDIO SWITCH IC2000 FILTER 4 CHANNEL ANALOG SURFACE WAVE +5VA MULTIPLEXER/ IF ANALOG DEMULTIPLEXER...
All manuals and user guides at all-guides.com 4-1. BLOCK DIAGRAMS (4) (KDL-26/32P2520/30 ONLY) D6000 BRIDGE IC6000 PH6002 T6000 RECTIFIER SWITCHING CONTROL PHOTOCOUPLER V SENSE CN6003 PS6002 SIGNAL VCC D6011 3.15A DIODE VG(H) Q6003 SIGNAL VCC IC6002 TIMER VG(L) SIGNAL VCC SHUNT REGULATOR Q6004 TO BDTR-2 BOARD...
All manuals and user guides at all-guides.com 4-1. BLOCK DIAGRAMS (5) 4-2. CIRCUIT BOARD LOCATION 5-2. CIRCUIT BOARD LOCATION Reference Information RESISTOR : METAL FILM H1/H1P : SOLID BDTR-2 FPRD : NON FLAMMABLE CARBON G1 (KDL-32U25xx) FUSE : NON FLAMMABLE FUSIBLE G2 (KDL-40U20xx) : NON FLAMMABLE METAL OXIDE : NON FLAMMABLE CEMENT...
Page 27
All manuals and user guides at all-guides.com A1/A1P.-SE1 LINE OUT BOARD DESCRIPTION JL2110 OUT_L AUDIO OUT R2033 D2021 C2021 1/10W UDZS-TE17-12B RN-CP JL2104 D2022 ANALOG UDZS-TE17-12B R2128 JL2111 JL2105 JL2107 DIGITAL OUT_R R2032 R2129 D2023 UDZS-TE17-12B 1/10W J2021 RN-CP C2022 D2024 JL2106 UDZS-TE17-12B...
Page 28
All manuals and user guides at all-guides.com A1/A1P.-SE1 TUNER BLOCK (ANALOG / HYBRID dpl) D1100 L1100 UDZSTE-175.6B JL2138 4.7uH ANALOG_AGC_SW TU1100 XX TU1300 C1100 100p L1101 C1101 4.7uH R1300 TU AGC R1301 L1102 100nH L1103 100nH R1308 C1102 C1103 R1302 1608 1608 ANALOG IF...
All manuals and user guides at all-guides.com BDTR-2.SE1 3.3V_MAIN C5630 FB5637 C5674 FB5630 BDTR-2 R5629 C5647 C5677 1 A / 9 C5632 C5675 C5648 C5678 C5633 R5640 R5641 R5642 ABCK,ADO,ALRCK,AMCK C5649 R5643 3.3V_MAIN C5634 R5630 C5635 R5631 3.3V_MAIN C5679 R5632 R5654 C5636 R5652...
Page 33
All manuals and user guides at all-guides.com BDTR-2.SE1 NOTE SYMBOL JL5661 IS WRONG BDTR-2 +1V5D +5V_AUDIO_DAC 1 B / 9 R5666 C5657 3.3V_MAIN 3.3V_MAIN R5671 R5669 CI_PWR_EN R5663 nCI_EN C5670 nCI_OVR R5667 nSMC_INT C5671 R5664 C5672 R5668 R5665 C5679 R5673 R5674 C5673 JL5638...
Page 34
VDD1 All manuals and user guides at all-guides.com VDD1 VDD1 VDD1 VDD2 VDD2 VDD2 VDD2 VDD2 VDD2 VDD3 VDD3 VDD3 VDD3 VDD3 VDD3 VDD3 VDD3 VDD3 VDD3 C5656 FB5618 FB5619 FB5620 C5650 3.3V_MAIN R9034 C5651 R9033 C5676 C5652 C5653 BOARD VERSION RESISTORS - MOUNT ON SIDE-A WITH JL’S ON SIDE-B R5648 JL5634...
Page 35
All manuals and user guides at all-guides.com AGNDP C5667 R5626 C5668 FB5647 C5669 C5666 +1V5D IN_TSD[0-7] ALL JIG LANDS TO BE PLACED ON SIDE B BDTR-2 1D/9 MAIN MICRO CONTROLLER, PANEL DRIVING, AUDIO & VIDEO PROCESSOR BDTR-2.SE1 ~ BDTR-2 Board Schematic Diagram [ Main Microcontroller, Panel Driving, Audio & Video Processor ] Page 1D/9 ~ - 34 -...
Page 36
All manuals and user guides at all-guides.com BDTR-2.SE1 +2V5D_DDR PLACE THESE CAPACITORS CLOSE TO IC PINS. NAND FLASH 3.3V_MAIN C5693 C5695 C5698 C5699 C5700 C5701 FB5680 C5601 C5682 C5683 C5680 C5684 DQ[0-15] IC5680 BDTR-2 DDR SDRAM 2 A / 9 IC5681 DQ15 RB5680...
Page 37
All manuals and user guides at all-guides.com PLACE THESE CLOSE TO PIN 49 OF IC RDATA[0-15] STRAP PINS RDATA[0] = ENDIAN = Big Endian RDATA[2:1] = 10 = MRGMODE1-0 = Full merge & All bytes RDATA[3] = -- = RESERVED RDATA[5:4] = 11 = VRCLKSEL1-0 = 201MHz RDATA[8:6] = 101 = MCLKSEL2-0 = 187MHz RDATA[9]...
Page 40
All manuals and user guides at all-guides.com BDTR-2.SE1 3.3V_MAIN R5854 D5840 RESET SIGNAL GENERATION FB5780 C5842 C5781 R5851 IC5840 C5843 C5780 C5783 VIDEO AMPS/BUFFERS R5857 C5841 JL5855 JL5854 nMASTER_RESET C5782 R5784 R5790 C5784 R5787 C5788 3.3V_MAIN C5844 R5782 R5785 R5788 JL5795 R5852 R5853...
Page 41
All manuals and user guides at all-guides.com BDTR-2.SE1 5V_MAIN Cu Heatsink - - - - - - - - - - - 3.3V_MAIN RESET_N C5815 C5816 3.3V_MAIN Add 20mmx20mm area Q5923 Connect to TAB of Q5922 DTC114EUA-T106 DTA143EUA-T106 Regulator R5924 R3398 IC5786 3.3V_MAIN...
Page 42
All manuals and user guides at all-guides.com BDTR-2.SE1 EJTAG CONNECTION 3.3V_MAIN +3V3 SIDE_B JL5897 BDTR-2 SIDE_B SIDE_B SIDE_B SIDE_B SIDE_B SIDE_B SIDE_B FIT FOR JTAG 5 / 9 JTRST JTCK JTDO JTMS JTDI EDINT JL5896 CN5880 JL5880 JL5881 JL5882 JL5883 JL5885 JL5887 JL5895...
Page 43
All manuals and user guides at all-guides.com BDTR-2.SE1 BDTR-2 6 A / 9 +3.3IO 0 . 1 C3004 +3.3IO R3043 M24C32-WMN6T(B) C3017 IC3004 6.3V C3018 1608 0 . 1 CHIP 1608 JL3123 R3137 NVM_WP R3079 JL3124 CHIP 1608 R3080 R3001 JL3125 470p CHIP...
Page 44
All manuals and user guides at all-guides.com BDTR-2.SE1 JL3066 BDTR-2 RED_SCART1 R3271 C3098 JL3161 6 B / 9 CHIP JL3067 GREEN_SCART1 R3272 C3099 CHIP JL3068 BLUE_SCART1 C3066 JL3069 JL1060 R3273 FB_SCART1 FBLK1 CHIP C3100 R3270 JL3070 C3067 C3065 R3274 MODE1 C3089 MODE1 CHIP...
Page 45
MSB709-RT1 V IN 5 C3015 All manuals and user guides at all-guides.com CVBS_SCART1 0 . 1 JL3126 C3031 2012 RN-CP V IN 3 R3381 0 . 1 D3014 1/10W R3371 JL3127 RF_DIGITAL RN-CP 1/10W MMDL914T1 C3110 C3111 V IN 2 1/10W RN-CP R3382...
Page 46
0 . 1 DBI0 C3074 All manuals and user guides at all-guides.com LINE_OUT_L LINEOUT_L DBI1 LINE_OUT_R LINEOUT_R DBI2 JL3104 5V_STBY 3.3V_STBY DBI3 JL3164 R3257 JL3105 DBI4 AUDIO_SW1 AU_MUX_CTRL_A C3319 DBI5 CHIP JL3106 R3251 C3091 AUDIO_SW2 AU_MUX_CTRL_B 4 . 7 k DBI6 JL3107 1/10W...
Page 47
All manuals and user guides at all-guides.com UDZSTE-173.0B D6502 V IN V IN V OUT V OUT OAOJ DAOJ ON/OFF ON/OFF VOUT D6506 RSX201L-30TE25 0ADJ ON/OFF 8.5V_MAIN C6562 C6563 3216 D6521 4 . 7 C6564 C6571 ~ BDTR-2 Board Schematic Diagram [ Main Microcontroller, Panel Driving, Audio & Video Processor ] Page 7A/9 ~ - 46 -...
All manuals and user guides at all-guides.com G2.-SE1 90mm VK Q6001(1),Q6002(2),D6012(1) D6003(1) Mount Mecha A6004 234990061 Q6001,Q6002,D6012 Mount Mecha A6001 263406601 D6003 Q6001(1),Q6002(2),D6012(1) D6036(1),D6037(1) Mount Mecha A6012 214976661 Q6001,Q6002,D6012 Mount Mecha A6008 214976661 D6036,D6037 Mount Mecha 404240802 A6000 EY6036 GND_2 C6000 D6038(1),D6039(1) R6000...
Page 61
All manuals and user guides at all-guides.com G2.-SE1 1B/2 R6126 0 . 4 7 C6068 4 . 7 D6044 1/4W 100V 10ERB20-TB3 FPRD JL6013 JL6015 Q6014(1),Q6013(1) EY6066 C6073 EY6052 D6043 10ERB20-TB3 Mount Mecha A6005 234990031 Q6014,Q6013 D6035 GND_2 GND_2 D10SC6M-4012 EY6053 EY6076 EY6067...
Page 62
All manuals and user guides at all-guides.com C6019 DIPA [ X [ q ´ ET6000 2SB1122-S-TD-E VD6000 Q6008 JL6231 t @ X g ƒ “ Mount Mecha 404240802 A6003 CN6000 GND_3 C6042 C6035 0 . 1 0 . 1 R6082 R6083 1/10W 1/10W...
Page 63
MM1431ATT(CN) RN CP AMP_MUTE IC6004 UDZS-TE17-33B All manuals and user guides at all-guides.com C6089 D6048 AMP_MUTE CN6005 MM1431ATT(NEW) GND_2 GND_1 R6124 1/10W RN-CP 0.5% JL6010 POWER ON 2SB1122-S-TD-E Q6008 R6098 1/10W R6111 RN-CP AC OFF DET GND_2 JL6224 R6096 C6076 C6042 STBY5V 0 .
All manuals and user guides at all-guides.com ~ A1/A1P Board IC Voltage Table ~ ~ A1/A1P Printed Wiring Board Conductor Side B ~ ~ A1/A1P Printed Wiring Board Conductor Side A ~ Ref No Pin No Volts (V) Ref No Pin No Volts (V) Ref No...
All manuals and user guides at all-guides.com L653 2 CN6501 IC6503 Q6512 C6544 PS6500 PS6502 C6540 Q6509 3.15 A C6505 C650 7 L6502 IC6501 PS6501 CN6500 3.15 A ET650 2 5 0 2 E T 6 5 0 3 E T 6 ET6501 5 0 1 E T 6...
All manuals and user guides at all-guides.com CN6300 (1-727-577-21) C6008 1-870-685-21 L6001 A006 CN6001 JW6327 JW6321 I C 6001 JW6324 PRIMARY C6016 ET6000 C6011 C6014 C6005 EY6055 T6001 JW6329 JW6325 I C 6000 C6019 EY6054 R6045 EY6052 I C 6300 EY6050 EY6004 D6008...
All manuals and user guides at all-guides.com SECTION 5 EXPLODED VIEWS NOTE : Items with no part number and no description are not Items marked “*” are not stocked since they are seldom required for stocked because they are seldom required for routine service. routine service. Some delay should The construction parts of an assembled part are indicated be anticipated when ordering these with a collation number in the remarks column. items. 5-1. CHASSIS REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK 8-597-585-10 TUNER, FSS BTP-HC401 1-826-478-11 LOUDSPEAKER (4.2X24CM) (40 inches) *A-1247-112-A A1 BOARD, COMPLETE (SE1T)(32 inches) X-2109-674-4 BEZEL ASSY (32 inches) *A-1247-116-A A1P BOARD, COMPLETE (SE1T)(40 inches)
All manuals and user guides at all-guides.com SECTION 6 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page G2 BOARD COMPLETE Parts List : (40 inches only) ..............BDTR-2 BOARD COMPLETE Parts List : ....................76 H1/H1P BOARD COMPLETE Parts List : ....................
Page 101
All manuals and user guides at all-guides.com A1/A1P.-SE1 A1/A1P.-SE1 TUNER BLOCK (ANALOG / HYBRID dpl) AUDIO SWITCH (PC,Component,Scart2,DVI) AUDIO SCART2 D1100 L1100 UDZSTE-175.6B JL2138 4.7uH ANALOG_AGC_SW MC14052 BDR2 TU1100 XX TU1300 R2002 IC2000 C1100 8.5V 100p L2000 1/10W SC2-IN-L 10uH C2000 R2003 R2014...
Page 102
All manuals and user guides at all-guides.com BDTR-2.SE1 BDTR-2.SE1 3.3V_MAIN NOTE SYMBOL JL5661 IS WRONG C5630 FB5637 C5674 BDTR-2 +5V_AUDIO_DAC FB5630 +1V5D BDTR-2 1 B / 9 R5666 R5629 C5647 C5677 1 A / 9 C5632 C5657 3.3V_MAIN C5675 3.3V_MAIN C5648 R5671 C5678...
Page 103
All manuals and user guides at all-guides.com BDTR-2.SE1 +2V5D_DDR NAND FLASH PLACE THESE CAPACITORS CLOSE TO IC PINS. 3.3V_MAIN C5693 C5695 C5698 C5699 C5700 C5701 FB5680 C5601 C5682 C5683 C5680 C5684 DQ[0-15] IC5680 BDTR-2 DDR SDRAM 2 A / 9 IC5681 RB5680 DQ15...
Page 104
All manuals and user guides at all-guides.com BDTR-2.SE1 BDTR-2.SE1 BDTR-2 3 A / 9 BDTR-2 3 B / 9 JL5750 +3V3D_31 +5VD_CI FB5751 C5756 C5758 R5759 C5766 FB5750 C5751 C5750 C5753 C5755 nCI_WAIT VS1B MIVAL MISTRT CD2B MICLK CD1B MDI[0] MDI[1] IREQB MDI[2]...
Page 105
All manuals and user guides at all-guides.com BDTR-2.SE1 BDTR-2.SE1 BDTR-2 3 A / 9 BDTR-2 3 B / 9 JL5750 +3V3D_31 +5VD_CI FB5751 C5756 C5758 R5759 C5766 FB5750 C5751 C5750 C5753 C5755 nCI_WAIT VS1B MIVAL MISTRT CD2B MICLK CD1B MDI[0] MDI[1] IREQB MDI[2]...
Page 106
All manuals and user guides at all-guides.com BDTR-2.SE1 BDTR-2.SE1 8.5V_MAIN BDTR-2 4 A / 9 FB5782 FB5780 R5814 C5792 IC5781 C5795 8.5V_MAIN C5781 R5791 C5814 C5806 CONTROL C5807 JL5784 C5780 C5783 FB5781 C5791 AMPLIFIER GAIN = 2.0 VIDEO AMPS/BUFFERS NOISE VOUT C5794 C5796...
Page 107
All manuals and user guides at all-guides.com BDTR-2.SE1 BDTR-2.SE1 BDTR-2 BDTR-2 RED_SCART1 JL3066 6 A / 9 R3271 C3098 JL3161 6 B / 9 CHIP JL3067 GREEN_SCART1 +3.3IO 0 . 1 R3272 C3099 C3004 CHIP BLUE_SCART1 JL3068 C3066 JL3069 JL1060 R3273 FB_SCART1 +3.3IO...
Page 108
All manuals and user guides at all-guides.com BDTR-2.SE1 L6503 C6526 JL6507 10uH 1608 SIGNAL_VCC C6518 RN-CP BDTR-2 R6508 0 . 2 2 1/10W SIGNAL_VCC R6507 JL6508 1/10W R6511 7 B / 9 RN-CP TK11185CSCL-G SIGNAL_VCC IC6502 JL6509 R6512 PS6501 1608 CHIP 3.15A 0 .
Page 109
All manuals and user guides at all-guides.com BDTR-2.SE1 BDTR-2 8 A / 9 3.3V_MAIN R6576 CXD1968R (COFDM DEMODULATOR BLOCK) D6522 1.8V_MAIN R6577 R6579 3.3V_MAIN IC6504 C6580 R6578 JL6560 3V3D_XTAL_CO L5041 C5055 1.2V_MAIN R6581 C6582 3V3D_CO L5042 C5056 C6581 IC6505 C5061 C5062 3V3A_CO L5043...
Page 110
All manuals and user guides at all-guides.com BDTR-2.SE1 BDTR-2.SE1 BDTR-2 9 A / 9 RN-CP 1/10W 150k R6561 R6563 BDTR-2 VH_DDH_3.3 R6562 9 B / 9 RN-CP 1/10W RN-CP D4207 1/10W R6571 R6565 CEC_IN Q4219 RN-CP Q4214 2SK2036(TE85L) 1/10W 2SK2036(TE85L) 150k Q4215 R6566...
Page 111
All manuals and user guides at all-guides.com G1-SE1 G1-SE1 JL001 18V/24V JL002 18V/24V 18V/24V 1B/2 18V/24V C6038 1A/2 POWER SUPPLY 18V/24V JL006 JL007 EY6056 EY6037 1000 JL008 EY6058 C6039 JL009 EY6059 L6007 L6008 PS6002 EY6036 3.15A 2200 CN6002 C6030 JW6007 JW6008 EY6057 7 .
Page 112
All manuals and user guides at all-guides.com G2.-SE1 G2.-SE1 90mm VK Q6001(1),Q6002(2),D6012(1) D6003(1) 234990061 Q6001,Q6002,D6012 Mount Mecha A6004 Mount Mecha A6001 263406601 D6003 1B/2 Q6001(1),Q6002(2),D6012(1) D6036(1),D6037(1) Mount Mecha A6012 214976661 Q6001,Q6002,D6012 R6126 Mount Mecha A6008 214976661 D6036,D6037 0 . 4 7 C6068 D6044 1/4W...