Advertisement
Quick Links
Advertisement
Related Manuals for Gecco DROPMASTER Mini E
Summary of Contents for Gecco DROPMASTER Mini E
- Page 1 PERATION ANUAL...
-
Page 2: Table Of Contents
Dropmaster (Patented) By GECCO, Inc. RR 2, Box 2476G Factoryville, PA 18419 Phone: 1-866-GECCO-00 Fax: 1-570-945-9542 Operation Manual Table of Contents Introduction page 2 Safety Instructions page 3 III. Operations Procedures page 4 & 5 Water Calculations Sheet page 6... -
Page 3: Introduction
Connect the hose, activate the power source and the Dropmaster is ready to GECCO. The Dropmaster Mini E is rugged, portable and constructed to be transported in a service truck or van. The unit (2’ x 2’-6”) is built on a handcart and designed to fit through a hospital, nursing home, motel or office standard door opening. -
Page 4: Safety Instructions
Safety Instructions Read all instructions before operation. Retain instructions for your permanent records. Disconnect power source before servicing or cleaning unit. Do not permit unauthorized persons to use the unit at any time. Do not put alcohol or other combustible materials in the vacuum tank. Never operate compressor at pressures or speeds in excess of those recommended by manufacturer. - Page 5 III. Dropmaster Operating Procedures Dropmaster is to be used only by a qualified fire protection technician. The Dropmaster is designed to be used on one sprinkler system at a time. Utilize normal shut down procedures for ‘Alarms’; i.e. customer/owner must notify service monitoring alarms and insurance company.
- Page 6 Make sure Dropmaster is operating before breaching sprinkler system. When approaching sprinkler head a slight vibration from the siphon effect will be noticed at the base of sprinkler head. If you do not notice this vibration make sure Dropmaster is running.
-
Page 7: Water Calculations Sheet
Water Calculations Please Note Utilize this worksheet to perform calculations at project site to determine residual water that will be captured by Dropmaster tank before placing Dropmaster in service. 1 Gallon of water = 8.344 lbs. Pressure Vacuum 1 psi = 2.036 inches H.G. -
Page 8: Troubleshooting
Trouble Shooting Dropmaster Not Siphoning 1. Check for power. 2. Check that valves are in proper position. 3. Check filter. 4. Check strainer on the intake side of the tank 5. Check reservoir tank – if full, drain tank. Dropmaster Stalls 1. -
Page 9: Maintenance
Maintenance Daily: • Check for any unusual noise, failure to compress, overheating, vibration and correct before damage of a serious nature can develop. • Check and add oil to vacuum pump reservoir, if necessary • Flush and clean storage tank after daily use. •... - Page 10 VII. Model Information Model Mini E 120 Volt 3/4 Horse Power Electric Standard Equipment: Mounted on a portable handcart 20’ of 1” flexible hose suction 20’ of 1” flexible hose discharge 20’ electrical cord GFI 15 Gallon holding tank 120 Volt Automatic Draining System 15 AMP Anti-flood device Options: 1”...
-
Page 12: Warranty
GECCO or its designee at GECCO’s then current repair charges. In this case, upon the request of the Original Purchaser, GECCO will submit an estimate of the repair cost to the purchaser prior to making the repairs. - Page 13 For a warranty claim please call GECCO for further instructions. Any part which is determined to be defective in material or workmanship and returned to GECCO as instruction will be, as the exclusive remedy, repaired and replaced at GECCO’s option.
-
Page 14: Registration - Updates
Registration – Updates Please complete the following warranty and registration information and mail to: GECCO, Inc. RR 2, Box 2476G Factoryville, PA 18419 GECCO will periodically update all registered owners about the Dropmaster unit. Name of Business: Contact Name: _____ Street Address:...
Need help?
Do you have a question about the DROPMASTER Mini E and is the answer not in the manual?
Questions and answers