Stern 50177 Manual

7K
50177
3. Pressure Sensitive Safety Device
The unit automatically cuts off the gas supply when the built-in pressure sensor
device detects the inner pressure of the gas cartridge to be above normal. This
usually occurs when the internal pressure is in the 57-85psi range.
When this occurs, first, follow the directions for "Removing the Gas Cartridge".
If possible, replace Gas Cartridge with a new cartridge. Otherwise, allow 20
minutes for the Gas Cartridge to cool and depressurize.
4. Checking and Cleaning
Precautions for checking and cleaning.
a) Remove the Gas cartridge before checking or cleaning.
b) Never disassemble safety devices on stove. Do not modify the appliance.
Body - Wipe body with clean cloth. If further cleaning is necessary, use only dish soap
or other mild cleansing agent. Dry with clean cloth. Do not rinse stove under water.
Pan Support and Drip Prip - Wash with dish soap when necessary.
Burner -Clean the burner top and holes with a wire brush.
Note: After use, remove the cartridge and fit the cartridge with its red protective cap.
Also, clean any food and especially fat residues from the appliance.
Store the appliance and the cartridge separately in a cool, dry and well ventilated place.
5. Troubleshooting
Problem
Continues Burning After Shutting Off Faulty or Damaged Flame Control Knob
Lack of Fuel
Stopped Working While in Use
Safety Stop Mechanism Activated
Improper Cartridge Alignment
Gas Smell Coming from Stove
Faulty or Damaged Flame Control Knob
Lack of Fuel
Slow Burning or Unstable
Improper Cartridge Alignment
Flame
Dirty Burner
Spark Point Dirty
Improper Spark Point Setting
Improper Cartridge Alignment
No Ignition
Dirty Burner
Safety Stop Mechanism Activated
Faulty or Damaged Flame Control Knob
Portable tableside cooking
For use by commercial restaurants indoors.
Not for household use.
Model: 50177 Gas type: Butane
Max. rating: 7000 BTU ANSI Z81.11/CSA 1.8-2016
Manufactured for distributed by: Sterno Products, Corona, CA. 92881 • MADE IN KOREA
Note: In the event of any problems, please contact Sterno Products customer service at (951) 682-9600.
Possible Cause Solution
Contact Customer Service
Replace Cartridge
See Section 3 "Pressure Sensitive Safety
Device"
Remove Gas Cartridge and Reinstall
Properly
Contact Customer Service
Replace Cartridge
Remove Gas Cartridge and Reinstall
properly
Clean the Burner
Clean Spark Point
Set Spark Point to 1/16 " (2 mm) Away
from Burner.
Remove Gas Cartridge and Reinstall
Properly
Clean the Burner
See Section 3 "Pressure Sensitive Safety
Device"
Contact Customer Service
INDOOR
Burner Shield
Pan Support (Grate)/
Grille de support de plat
Cartridge Priming Lever/
Levier d'amorçage de la cartouche
FOR YOUR SAFETY
IF YOU SMELL GAS:
1.Do not attempt to light
appliance.
2.Extinguish any open flame.
3.Disconnect from fuel supply.
This appliance can produce carbon monoxide
!
which has no odor.
Using it in an enclosed space can kill you.
DANGER
Never use this appliance in an enclosed space
such as a camper, tent, car or home.
IMPORTANT: Read these instructions for use carefully so as to familiarize yourself with the
appliance before connecting it to its gas container. Keep these instructions for future reference.
This appliance shall only be used with the Butane Gas Cartridge 227g approved to UL.
It may be hazardous to attempt to fit other types of gas containers.
Finger hole to open lid/
Burner/
Accès d'ouverture du compartiment
Brûleur
Control Knob/
Bouton de réglage de la flamme
FOR YOUR SAFETY
Do not store or use gasoline
or other liquids with flammable
vapors in the vicinity of this or
any other appliance.
CARBON MONOXIDE HAZARD