Advertisement
24" Wide, 7' Long Conveyor Dryer
OWNER'S MANUAL
OWNER'S MANUAL
Installation, Operation and Care of VS-2407
Installation, Operation and Care of VS-2407
For Customer Service, Call 1-800-835-0606
CONTENTS
Receiving & Installation ....................................................................................2
Operation ..........................................................................................................3
Settings.............................................................................................................4
Adjustments ......................................................................................................5
Maintenance .....................................................................................................6
Maintenance .....................................................................................................7
Warranty ...........................................................................................................8
BEFORE warranty repair you MUST get Prior Authorization:
VS - 2407
or Visit www.hixcorp.com
VS-2407
10556 RV A_031418
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Summary of Contents for Hix VS-2407
- Page 1 VS - 2407 24” Wide, 7’ Long Conveyor Dryer OWNER’S MANUAL OWNER’S MANUAL Installation, Operation and Care of VS-2407 Installation, Operation and Care of VS-2407 VS-2407 For Customer Service, Call 1-800-835-0606 or Visit www.hixcorp.com CONTENTS Receiving & Installation ..................2 Operation ......................3 Settings......................4...
- Page 2 RECEIVING & INSTALLATION SHIPPING OR RETURNS NOTE: Save all of your shipping/packing materials. DO NOT RISK COSTLY SHIPPING DAMAGE! RAISE OVEN HEATER TO THE HIGHEST POSITION BEFORE SHIPPING. THIS SECURES THE HEATER TO THE DRYER FRAME. SHIP ONLY IN ORIGINAL CRATE. UNCRATING INSTRUCTIONS Remove top of crate Remove the four 9/16”...
- Page 3 OPERATION OPERATING INSTRUCTIONS Turn “Main Power” Switch on. Turn the belt speed control up and observe the belt moving. Now would be a good time to “chart” your actual oven retention times for any given speed control setting. Place a coin on the belt to use as a reference when checking time through the oven.
- Page 4 SETTINGS TEMPERATURE ADJUSTMENT Press on the temperature display with your fi nger – display will start fl ashing. Press on the “UP” or “DOWN” arrow to change the value. Once the new value is displaying, it will automatically lock in that new setting. STORING TEMPERATURE PRESETS Temperature presets can be “stored”...
- Page 5 ADJUSTMENTS OVEN DOOR HEIGHT ADJUSTMENT The oven doors can easily be raised or lowered and then locked in place with the two black star knobs as shown below. Height is adjustable from 1” to 6” off of the conveyor belt. OVEN HEATER HEIGHT ADJUSTMENT The oven heater height can also be adjusted from 5”...
- Page 6 MAINTENANCE BELT TRACKING ADJUSTMENT After the conveyor belt has been installed some adjustment may be necessary to ensure the belt is tracking properly. Make sure the oven is level (from side to side). Use a carpenters level. Slightly loosen the four nuts on the input side of the dryer as shown in the diagram.
- Page 7 MAINTENANCE If the belt is moving to the left, tighten (1/2 turn-clockwise) the adjustment screw on that side. If tracking to the right, tighten the right side adjustment screw. Allow the belt to make at least 3 full revolutions before making further adjustments.
- Page 8 Thermatrol and doughXpress products are covered under separate warranty. In the event of a defect, HIX, at its option, will repair, replace or substitute the defective item at no cost during this period subject to the limitations of insurance and shipping costs stated below.
Need help?
Do you have a question about the VS-2407 and is the answer not in the manual?
Questions and answers