1 SAFETY GUIDELINES / TECHNICAL DATA ........................1.1 General safety guidelines ............................1.2 Built-in safety features (depending on model) ......................1.3 Technical data LIFTKAR HD models ..........................1.4 Technical data of quick-change battery unit ....................... 2 CONTROL FEATURES ................................. 2.1 UNI model ...................................
You have chosen a unit using the very latest stairclimber technology for negotiating different types of steps and stairs safely and efficiently. Development of the LIFTKAR HD focussed especially on user safety and user friendliness. Key features: Two UP / DOWN switches - one on the left and one on the right of the handle unit - for perfect user comfort.
The sliding arm must be protection system. A: Sliding Arm - B: Dolly-System A: Sliding Arm - B: Dolly-System Each time before starting up the stairclimber, make sure that the protection system is properly folded away (retracted, figure Liftkar HD I 4...
Page 5
Folding away Support system retracted IMPORTANT Do not use the protection system in the extended position while operating the stairclimber on stairs. Liftkar HD I 5...
1.3 TECHNICAL DATA LIFTKAR HD MODELS Model Fold Dolly Load capacity 360 kg 330 kg 220 kg Maximum climbing speed with full load (steps/min) 9-10 9-10 14-15 Maximum step height 210 mm 210 mm 210 mm Model Weight (incl. battery pack)
2 CONTROL FEATURES 2.1 UNI MODEL 1: UP/DOWN switches - 2: Handles - 3: Control unit - 4: Quick-change battery pack - 5: Climbing mechanism - 6: Main wheels Liftkar HD I 7...
In addition, an integrated beeper provides an acoustic signal to indicate that the battery charge is low. The beep frequency increases the lower the battery level. Liftkar HD I 11...
A: UP/DOWN switch B: DOWN - C: UP 2.7 MAIN SWITCH The main switch is located on the quick-change battery pack. The power supply to the unit can be switched off safely using the main switch (figure Liftkar HD I 12...
P or leaving the unit to switch off automatically because switch P could easily be actuated inadvertently, causing the machine to switch on. Always switch off the main switch on the battery pack before stowing the unit away. Liftkar HD I 13...
Gently press battery pack forwards swiftly. The battery pack clicks into place. Set switch on battery pack to ON and your LIFTKAR is ready for operation. C: Latches 3.2 REMOVING BATTERY PACK Lift the battery pack sharply upwards. It then disengages automatically. Liftkar HD I 14...
IMPORTANT As soon as the main wheels have landed on the step, always push the Liftkar to the edge of the next step. The brake wheels stop the Liftkar reliably on the edge of the step. Liftkar HD I 15...
The brakes are released mechanically as soon as the main wheels contact the next step. The brake system remains active and engages automatically when the main wheels approach the edge of the next step. Liftkar HD I 16...
(distance between point main wheels contact step and edge of step, i.e. approx. 7 – 8 cm). Now you can start the next lifting cycle and the LIFTKAR will land safely on the next step. Liftkar HD I 17...
The old lead batteries are fully recyclable and are not to be disposed of. The ideal temperature for charging is between 20 and 25° C. Temperatures that are too cold or too hot will affect the battery's capacity. Liftkar HD I 18...
Please note the following: Protect against damp Only charge in a well ventilated room Do not pull the plug out of the socket by its cord Do not operate charger with damaged cord or plug - replace immediately! Liftkar HD I 19...
Please ask your dealer. 8 DISPOSAL Liftkar HD stairclimbers are durable products. At the end of their useful life the stairclimber components and charger should be disposed of properly. Make sure the materials are separated carefully for disposal in line with the material codes relating to each component.
9.2 LIABILITY SANO Transportgeraete GmbH is not responsible for the safety of the LIFTKAR HD if: the LIFTKAR HD is used for a purpose for which it is not intended. repairs, installation or other work have been carried out by unauthorised persons.
10 CE DECLARATION OF CONFORMITY / PATENT REGISTERED 10.1 CE DECLARATION OF CONFORMITY SANO Transportgeraete GmbH declares that the LIFTKAR HD stairclimber fully complies with the relevant health and safety specifications laid down in the EU directive for machines 2006/42/EG, appendix IIA. Any changes made to the product without our prior consent render this declaration void.