Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Page 2
• Chapter 4: Added figures 4-2 Cable dressing (32" 5101 series), and added section 4.4 Assembly/Panel Removal(for 32PHD5101/30). 2. Technical Specs, Diversity, and Connections Index of this chapter: • Specifications are indicative (subject to change). 2.1 Technical Specifications 2.2 Directions for Use Technical Specifications 2.3 Connections...
Page 3
Technical Specs, Diversity, and Connections TPS16.1A LA EN 3 Connections 20190_001.eps Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 16 - DDC_SDA DDC data (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, 17 - Ground Gy= Grey, Rd= Red, Wh= White, Ye= Yellow.
Page 4
EN 4 TPS16.1A LA Technical Specs, Diversity, and Connections 17 - Ground 2.3.2 Rear Connections 18 - +5V 19 - HPD Hot Plug Detect 5 - Audio - In: Left / Right, VGA 20 - Ground Bu - Audio L/R in 0.5 V / 10 kW 3 - HDMI 1: Digital Video - In, Digital Audio with ARC -...
Page 5
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 TPS16.1A LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 7
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPS16.1A LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal(for 24Pxx45x1/30) 4.5 Set Re-assembly Cable Dressing ECN701...
Page 10
EN 10 TPS16.1A LA Mechanical Instructions CN9101 ECN701 MAIN POWER SUPPLY (1054) (1053) IR/LED BOARD (1056) LOUDSPEAKER LOUDSPEAKER (1184) (1184) ECN601 20191_100.eps Figure 4-2 Cable dressing (32" 5101 series) back to 2016-Jun-08 div. table...
Page 11
Mechanical Instructions TPS16.1A LA EN 11 Service Positions 4.3.1 Rear Cover For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop Refer to Figure 4-3 for details.
Page 12
EN 12 TPS16.1A LA Mechanical Instructions 20190_102.eps Figure 4-4 Keyboard Control unit removal 4.3.3 Small Signal Board (SSB) Refer to Figure 4-5 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB.
Page 13
When defective, replace the whole unit. 2. Lift the bracket from the set. Assembly/Panel Removal(for 32PHD5101/30) 4.3.7 IR/LED panel Instructions below apply to the 32PHD5101/30. 1. Remove the stand bracket, as described earlier. 4.4.1 Stand 2. Unplug the connector from the IR/LED panel.
Page 14
EN 14 TPS16.1A LA Mechanical Instructions 4.4.2 Rear Cover 1. Remove the fixation screws [2] and [3] that secure the rear cover. Refer to Figure 4-7 for details. 2. Gently lift the rear cover from the TV. Make sure that wires Refer to Figure 4-7 for details.
Page 15
Mechanical Instructions TPS16.1A LA EN 15 4.4.3 Speakers 2. Gently lift the speakers cover from the TV. Make sure that wires and cables are not damaged while lifting the rear cover from the set. Refer toFigure 4-8 for details. 3. Gently take the cables [2] out from the snap. 1.
Page 16
EN 16 TPS16.1A LA Mechanical Instructions 4.4.5 Small Signal Board (SSB) Refer to Figure 4-9 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB. 1.
Sub-MCU Ver V0.01 SUB-MCU Version EEPROM Ver V0.01 EEPROM Version Date Mar 16 2016 Mar 6 2016 Software release date ModelName 24PFD4501/30 32PHD5101/30 Model name Scaler MSD8120PBM Scaler model Panel Type LVM236HJJ02A452H0F LVB315WX226AHZ Display model Source HDMI Input source Auto Color...
Page 18
EN 18 TPS16.1A LA Service Modes, Error Codes, and Fault Finding Stepwise Start-up Standby Soft Mode Command Received, Switch previously in Standby Off(Mains Soft Mode (Power tact Standby Power Plug) switch) Digital Digital background background tasks started tasks completed TV Wakeup commands Received Standby...
Page 19
It is possible for the user to upgrade the main software via the USB port. This allows replacement of a software image in a stand alone set. A description on how to upgrade the main software can be found in the DFU or on the Philips website. 5.4.2 Introduction 19080_207_110324.eps...
Page 20
EN 20 TPS16.1A LA Service Modes, Error Codes, and Fault Finding 5.4.6 Content and Usage of the One-Zip Software File Below you find a content explanation of the One-Zip file, and instructions on how and when to use it. Only files that are relevant for Service are mentioned here.
Alignments TPS16.1A LA EN 21 6. Alignments Index of this chapter: 6.1 General Alignment Conditions 6.2 Reset of Repaired SSB General Alignment Conditions Perform all electrical adjustments under the following conditions: • Power supply voltage: 90 - 264 V , 50/ 60 ± 3 Hz. •...
EN 22 TPS16.1A LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPS16.1A LA is a new chassis launched in AP in 2016. 7.2 Power Supply The whole range is covered by MSD8120PBM. 7.3 DC/DC Converters The major deltas versus its predecessor support 7.4 Front-End Analogue and PAL I, DTMB reception PAL/DTMB with also multi-media, video out function.
Page 23
Circuit Descriptions TPS16.1A LA EN 23 7.1.3 SSB Cell Layout HDMI DC/DC DC/DC HDMI DC/DC HDMI DC/DC DC/DC DC/DC Tuner Headphone PC Audio Analog Input SPDIF ANALOG I/O 20190_200.eps Figure 7-1 SSB layout cells (top view) back to 2016-Jun-08 div. table...
Page 24
The following displays can be distinguished: specifications! This part is available in the regular market. • CCFL/EEFL backlight: power panel is conventional IPB Consult the Philips Service web portal for the order codes of the • LED backlight: boards. - side-view LED without scanning: PSL power panel - side-view LED with scanning: PSLS power panel Important delta’s with the TPS16.1A LA classis platform are:...
Page 25
Circuit Descriptions TPS16.1A LA EN 25 • +12V, input from the power supply for the panel Connector common(active mode) Number CN9101 CN8605 CN9101 CN8602 • +12V_AUD, input from the power supply for the AMP Description to SSB to panel to SSB to panel •...
Page 26
EN 26 TPS16.1A LA Circuit Descriptions 7.3.1 Power layout SSB U706, DDRV C260, Panel_Power L701,+5VSB C708, 5V_SW C602, +16V_AUD U102, VCC3v3 U705, VCCK 20190_203.eps Figure 7-4 Power SSB Top View back to 2016-Jun-08 div. table...
Page 27
Circuit Descriptions TPS16.1A LA EN 27 U103, +3V3_Tuner 20190_204.eps Figure 7-5 Power SSB Bottom View Front-End Analogue and PAL I, DTMB reception MxL661-AG-R 7.4.1 DVB-T/C DTV part The Front-End for DVB-T/C DTV part consist of the following IF_AGC key components: IF_AGC •...
Page 28
EN 28 TPS16.1A LA Circuit Descriptions Below find a block diagram of the front-end application for MPEG-2/H.264 decode, analog video decode and HDMI DTMB part. reception, with advanced back-end video picture improvements. It also includes next generation Motion Accurate Picture Processing High flat panel screen resolutions MxL661-AG-R and refresh rates are supported with formats including 1280 ×...
IC Data Sheets TPS16.1A LA EN 29 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 30
EN 30 TPS16.1A LA IC Data Sheets Diagram 10-3-7 Audio Amp/Headphone Output, B07, TAS5729MDDCAR (IC U601) Block diagram DVDD AVDD ANA_REG1 ANA_REG2 DIG_REG DRVDD DR_CN DR_CP DRVSS PVDD GVDD_REG TAS5729MDD Analog Supply Gate Drive Regulators Regulator Charge Pump Digital Supply Regulator PWM Power Stage Full Bridge Digital Audio Processor...
Page 31
IC Data Sheets TPS16.1A LA EN 31 Diagram 10-3-8 Demod DTMB, B08, MSB1238 (IC U103) Block diagram MSB1238 Pinning information I2CS_SCL TS_D[6] TS_D[7] Pin 1 XTAL_ OUT TS_CLK XTAL _IN SSPI_CLK AVDD_MPLL SSPI_DI GPIO SSPI_DO IFAGC RE SETZ SSPI_C SZ VDD33 19901_300.eps Figure 8-3 Internal block diagram and pin configuration...
Page 32
EN 32 TPS16.1A LA IC Data Sheets Personal Notes: 10000_012_090121 back to 2016-Jun-08 div. table...
Page 49
Circuit Diagrams and PWB Layouts TPS16.1A LA EN 49 10-3-9 System Power +5VSB System Power 5V_SW +3V3SB R706 +3V3SB +3V3SB 4K7 1/16W 5% MAIN POWER R707 R722 4K7 1/16W 5% 4K7 1/16W 5% PS_ON Q701 PS_ON R735 Back Light On / Off R742 R701 MMBT3904...
Page 51
Circuit Diagrams and PWB Layouts TPS16.1A LA EN 51 10-3-11 SSB layout bottom TP101 TP102 LAYOUT BOTTOM 715G6854 19901_514.eps back to 2016-Jun-08 div.table...
Circuit Diagrams and PWB Layouts TPS16.1A LA EN 52 10.4 J 715G5964 IR/LED Panel 10-4-1 IR & LED IR & LED LED_R LED_B Vout 15K 1/16W 5% IRM-V836M3/TR1 2.2uF 10V 2.2uF 10V CONN 033G8032 5F S B 1K5 1/16W 5% LED1 12-22/BHR6C-C31/2C NC/0R05 OHM...
Page 53
Circuit Diagrams and PWB Layouts TPS16.1A LA EN 53 10-4-2 IR/LED board layout Layout IR/LED panel (top side) LED1 Layout IR/LED panel (bottom side) 2012-10-29 IR/LED panel 715G5964 layout top/bottom 19890_529.eps back to 2016-Jun-08 div.table...
Page 55
Circuit Diagrams and PWB Layouts TPS16.1A LA EN 55 10-5-2 IR/LED board layout Layout LED Board (top side) Q301 U201 Layout LED Board (bottom side) CN201 2012-10-26 LED Board 715G7055 layout top/bottom 19791_501.eps back to 2016-Jun-08 div.table...
Circuit Diagrams and PWB Layouts TPS16.1A LA EN 56 10.6 E 715G7088 Keyboard control panel 10-6-1 CN01 CN01 KEY1 CONN CONN 0.1uF 50V 0.1uF 50V TACT SW 6P TACT SW 6P SW01 SW01 Right Center Down Left 2014-05-28 Keyboard control panel 715G7088 19791_502.eps back to...
Page 57
Circuit Diagrams and PWB Layouts TPS16.1A LA EN 57 10-6-2 Key board layout Layout Keyboard control panel (top side) SW01 Layout Keyboard control panel (bottom side) 2014-06-06 Keyboard control panel 715G7088 layout top/bottom 19791_503.eps back to 2016-Jun-08 div.table...