Advertisement
Quick Links
(US & Canadian units are convertible and are assembled for Natural Gas)
(European units are not convertible and assembled for the appropriate gas)
Please complete this information and retain this manual for the life of the equipment. For Warranty
Service and/or Parts, this information is required.
Model Number
FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors and liquids
in the vicinity of this or any other appliance.
WARNING: Improper installation, operation, service or maintenance can cause property
damage, injury or death. Read and understand these instructions thoroughly before
positioning, installing, maintaining or servicing this equipment.
DALLAS:
1307 N. Watters Rd #180 • Allen, TX • 75013
Local: (972) 908-6100
Toll Free: (800) 733-2203
Parts/Service Fax: (214) 565-0976
INSTALLATION
OPERATING
INSTRUCTIONS
Gas Griddles
MODELS: TSGGT-18i, -24i, -36i, -48i
MODELS: TSGGM-18i, -24i, -36i, 48i
IMPORTANT FOR FUTURE REFERENCE
TRI-STAR MANUFACTURING
www.tri-starmfg.com
AND
&
Serial Number
CHEYENNE:
1938 Wyott Dr • Cheyenne, WY • 82007
Local: (307) 634-5801
Toll Free: (800) 752-0863
Parts/Service Fax: (214) 565-0976
1
Date Purchased
P/N 882213, REV 9/13
Advertisement
Summary of Contents for Tri-Star TSGGT-18i
- Page 1 INSTALLATION OPERATING INSTRUCTIONS Gas Griddles MODELS: TSGGT-18i, -24i, -36i, -48i & MODELS: TSGGM-18i, -24i, -36i, 48i (US & Canadian units are convertible and are assembled for Natural Gas) (European units are not convertible and assembled for the appropriate gas) IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment.
-
Page 2: Table Of Contents
Tri-Star. Congratulations on your purchase of Tri-Star commercial cooking or refrigeration equipment. Tri-Star takes pride in the design and quality of our products. When used as intended and with proper care and maintenance, you will experience years of reliable operation from this equipment. -
Page 3: Safety Precautions
If you have questions concerning the installation, operation, maintenance or service of this product, write or call Technical Service Department at Tri-Star, 1307 N. Watters Rd#180, Allen TX, 75013 (800) 733-2203. SAFETY PRECAUTIONS Before installing and operating this equipment be sure everyone involved in its operation is fully trained and is aware of all precautions. -
Page 4: Installation Instructions
100,000/29.3 6/10(15/25) Griddle Surface Dimensions WIDTH DEPTH MODEL IN. (MM) IN. (MM) TSGGT-18i and TSGGM-18i 17 13/16” / (452) 19 ½” / (496) TSGGT-24i and TSGGM-24i 23 13/16” / (605) 19 ½” / (496) TSGGT-36i and TSGGM-36i 35 13/16” / (910) 19 ½”... - Page 5 Caution: DO NOT use an open flame to check for leaks. Check all gas piping for leaks with a soap and water solution before operating unit. THESE UNITS ARE SUITABLE FOR INSTALLATION ON NON-COMBUSTIBLE SURFACES ONLY. Noncombustible clearances: 0" sides (0 mm) 0"...
-
Page 6: Operation Instructions
5. Turn the burner knobs to "HI". If the burner does not ignite, promptly open the pilot valve more. If the pilot flame appears larger than necessary, turn it down and reset burner ignition. The pilot flame should be as small as possible but large enough to guarantee reliable ignition of the burners when the knobs are turned to "HI". -
Page 7: Service/Repair
NOTE: THIS APPLIANCE MUST ONLY BE SERVICED BY AN AUTHORIZED AGENT. NOTE: Parts protected by the manufacturer or his agent are not to be adjusted by the installer unless the installer is an authorized service agent. If you have any questions or problems contact your nearest Tri-Star Service Representative. -
Page 8: Conversion
CONVERSION Instructions are for conversion from Natural Gas to Propane (L.P.) on all TSGGT & TSGGM models. The conversion should be done before connecting the unit to the gas supply. 1. Remove the knobs and front panel. TSGGM TSGGT Models Models Screw 2. - Page 9 TSGGT CALIBRATION PROBE LOCATION CALIBRATION PROCEDURE FOR TSGGT GRIDDLES Locate the reading positions Make sure the griddle surface is clean. Grease or food particles on the griddle will result in inaccurate thermostat calibration. Mark the locations where the temperature probe will be placed for testing. See the sketch provided. Starting from the left side of the griddle, measure 8”...
- Page 10 If the temperature differential is large than 75ºF, there is probably a problem with your system. It may not be the thermostat. First make sure you thermostat probe is flat against the griddle plate and is making good contact. Dirt under the probe will cause inaccurate readings. Next make sure the thermostat bulb is held tightly in its holder.
-
Page 11: Troubleshooting
TROUBLESHOOTING GUIDE PROBLEM POSSIBLE CAUSE Thermostat is bad. Heat does not come on when Pilot burner not lit. thermostat is turned on. Gas valve is bad. Obstructed pilot orifice. Pilot burner will not light. Pilot gas turned off at automatic pilot. Automatic pilot valve is bad. - Page 12 PARTS LISTS & EXPLODED VIEWS TSGGM GRIDDLES (EXPLODED VIEW)
- Page 13 TSGGM – PARTS LIST Item Description Quan Item Description Quan 218215-20 Weldment, Griddle 2425400 Pan, Grease 18" Short Draw Varies TSGGM-18 218216-20 Weldment, Griddle 2425500 Pan, Grease 24" Short Draw Varies TSGGM-24 218217-20 Weldment, Griddle 8861000 Label, Spec TSGGM-36 218218-20 Weldment, Griddle 218215-12 Panel, Back...
- Page 14 TSGGT GRIDDLES (EXPLODED VIEW)
- Page 15 TSGGT – PARTS LIST Item Description Quan Item Description Quan 218219-60 Weldment, Griddle, TSGGT -18 2300100 Bags, Poly 36x27x44 218220-60 Weldment, Griddle, TSGGT -24 1018064 Insulation, Thermostat Bulb 218221-60 Weldment, Griddle, TSGGT -36 8509300 Washer, Flat, SAE, 5/16 218222-60 Weldment, Griddle, TSGGT -48 8436200 Nut, Hex 5/16-18 S/S 2092614...
-
Page 16: Warranty
TRI-STAR shall not be liable whether in contract or in tort or under any other legal theory, for loss of revenue or profit, or for any substitute use or performance, or for incidental, indirect, special or consequential damages, or for any other loss or cost of similar type.
Need help?
Do you have a question about the TSGGT-18i and is the answer not in the manual?
Questions and answers