Do you have a question about the Innova IGZCAPS35NI-1 and is the answer not in the manual?
Questions and answers
Summary of Contents for ahlsell Innova IGZCAPS35NI-1
Page 1
Owner's Manual Original Instructions Air Conditioners DC Inverter U-match Series Cassette Type Unit Models: Indoor Unit Outdoor Unit IGZCAPS35NI-1 IGZPAC35NO-1 IGZCAPS50NI-1 IGZPAC50NO-1 IGZCAPS71NI-1 IGZPAC71NO-1 IGZCAPB85NI-1 IGZPAC85NO-1 IGZCAPB100NI-1 IGZPAC100NO-1 IGZPAC100NO3-1 IGZCAPB125NI-1 IGZPAC125NO-1 IGZPAC125NO3-1 IGZCAPB140NI-1 IGZPAC140NO-1 IGZPAC140NO3-1 IGZCAPB160NI-1 IGZPAC160NO3-1...
Page 2
To Users Thank you for selecting innova’s product. Please read this instruction manual carefully before installing and using the product, so as to master and correctly use the product. In order to guide you to correctly install and use our product and achieve expected operating effect, we hereby instruct as below: This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of...
Page 3
to the product from time to time due to the reason of sales or production, and reserve the right to revise the contents without further notice. Indoor unit must not be installed in a laundry. If the supply cord is damaged, it must be replaced by the manufacturer, its service agent or similarly qualified persons in order to avoid a hazard.
DC Inverter U-match Series Cassette Type Unit 1 Safety Notices (Please be sure to abide) SPECIAL WARNING: Be sure to comply with national gas regulations. Do not pierce or burn. Do not use means to accelerate the defrosting process or to clean, other than those recommended by the manufacturer.
Page 6
DC Inverter U-match Series Cassette Type Unit Before installing the air conditioner, please read the instruction manual. Before repairing the air conditioner, please read the instruction manual. The figures in this manual may be different with the material objects, please refer to the material objects for reference. PROHIBITED (1) The air conditioner should be grounded to avoid electric shock.
Page 7
DC Inverter U-match Series Cassette Type Unit WARNING (6) Air conditioner should be stored with protective measures against mechanical damage caused by accident. (7) If the installation space for air conditioner pipe is too small, adopt a protective measure to prevent the pipe from physical damage. (8) During installation, use the specialized accessories and components, otherwise water leakage, electric shock or fire hazard may occur.
Page 8
DC Inverter U-match Series Cassette Type Unit NOTICE (1) Do not put a finger or other objects into the air inlet or air return grill. (2) Please adopt safety protection measures before touching the refrigerant pipe, otherwise your hands may be hurt. (3) Please arrange the drain pipe according to the instruction manual.
DC Inverter U-match Series Cassette Type Unit 2.2 Product Operating Range Cooling Heating -20~48 -20~24 Outdoor temperature DB(°C) Indoor temperature DB/WB(°C) 32/23 27/- (Maximum) 2.3 Standard Accessories Indoor Unit Accessories Name Appearance Q'ty Usage To connect with the Drain Hose hard PVC drain pipe To fix the installation Bolt with Washer...
DC Inverter U-match Series Cassette Type Unit Indoor Unit Accessories Name Appearance Q'ty Usage To prevent the communication wire from reaching out the Flannelette electric raceway(only 35/50) Connect the panel and Bolt Assembly body(only 35/50) Outdoor Unit Accessories Name Appearance Q'ty Usage To plug the unused...
Page 12
DC Inverter U-match Series Cassette Type Unit 3) Refer to the following table to check out the minimum construction area. Ceiling type Wall mounted type Floor standing type Area Area Area Weight(kg) Weight(kg) Weight (kg) — — — <1.224 <1.224 <1.224 1.224 0.956...
Page 13
DC Inverter U-match Series Cassette Type Unit shape, so please hold the base of the unit as well. During installation, be sure to use the components specified in the instruction manual. (3) Please use the charging machine specialized for R32 refrigerant; Before charging, keep the refrigerant tank in an upright position.
Page 14
DC Inverter U-match Series Cassette Type Unit (8) Indoor unit, power cord, connecting wires and communication cords should be at least 1m from television and radio. This is to prevent image interference or noise (Even at a distance of 1m, a very strong electric wave may still generate noise).
Page 15
DC Inverter U-match Series Cassette Type Unit (1) Indoor unit Drain Pipe D (Suspension bolt pitch) Liquid Pipe C (Indoor unit) Gas Pipe B (Ceiling) A(Decoration panel) NOTICE Drilling of ceiling opening and installation of air conditioner must be performed by professionals! Unit: mm Dimensions...
Page 16
DC Inverter U-match Series Cassette Type Unit (2) Outdoor unit IGZPAC35NO-1, IGZPAC50NO-1, IGZPAC71NO-1, IGZPAC85NO-1. IGZPAC100NO-1, IGZPAC125NO-1, IGZPAC140NO-1, IGZPAC100NO3-1, IGZPAC125NO3-1, IGZPAC140NO3-1.
Page 17
DC Inverter U-match Series Cassette Type Unit IGZPAC160NO3-1. Unit: mm Dimensions Model IGZPAC35NO-1 IGZPAC50NO-1 IGZPAC71NO-1 IGZPAC85NO-1 1002 IGZPAC100NO-1 IGZPAC100NO3-1 IGZPAC125NO-1 IGZPAC125NO3-1 IGZPAC140NO-1 IGZPAC140NO3-1 IGZPAC160NO3-1 1345...
Page 18
DC Inverter U-match Series Cassette Type Unit 3.1.4 Diagram of Unit Installation Space and Location (1) Diagram of installation space and location for outdoor unit (Notice: for best performance of the outdoor unit, make sure its installation space conforms to the following installation dimensions).
Page 19
DC Inverter U-match Series Cassette Type Unit 2) When two or more outdoor units are to be installed side by side. (mm) A,B,C — ≥300 ≥300 ≥1000 A,B,C,E — ≥300 ≥300 ≥1000 ≥1000 — ≥2000 — ≥2000 ≥1000 <H >H ≥300 ≥2000 ≤1/2H...
Page 20
DC Inverter U-match Series Cassette Type Unit 3) When outdoor units are installed in rows. ≥ 200 ≥ 200 ≥ 2000 ≥400 ≥400 (mm) b≥250 ≤1/2H 1/2H<H b≥300 ≤H Prohibited >H...
Page 21
DC Inverter U-match Series Cassette Type Unit 4) When outdoor units are installed one above another. Unit: mm 2000 (2) Diagram of installation location and space for indoor unit (Notice: for the best performance of indoor unit, make sure its installation space conforms to the following installation dimensions).
DC Inverter U-match Series Cassette Type Unit Model H(mm) IGZCAPS35NI-1 IGZCAPS50NI-1 IGZCAPS71NI-1 IGZCAPB85NI-1 IGZCAPB100NI-1 IGZCAPB125NI-1 IGZCAPB140NI-1 IGZCAPB160NI-1 3.2 Unit Installation 3.2.1 Indoor Unit Installation In order to make the front panel cover 20mm of the ceiling, the distance between the ceiling and the unit should be 35mm or less. If the distance between the ceiling and the unit is above 35mm, add some ceiling material to shorten the distance.
Page 23
DC Inverter U-match Series Cassette Type Unit (2) Installing the Main Body Unit. 1) Install the hoisting stand on the hoisting screw by using nuts and gaskets at both the upper and lower sides of the hoisting stand. To prevent the gasket from breaking off, a gasket anchor board can be helpful.
Page 24
DC Inverter U-match Series Cassette Type Unit 3.2.2 Outdoor Unit Installation (1) If the outdoor unit is installed on a solid ground such as concrete, use M10 screw bolts and nuts to secure the unit and make sure the unit stands erect and level.
Page 25
DC Inverter U-match Series Cassette Type Unit Installation method: Connect the connection pipes first to the indoor unit and then to the outdoor unit. When bending a connection pipe, be careful not to damage the pipe. Do not over-tighten the screw nut, otherwise leakage will occur. Besides, the outside of connection pipe should be added with a layer of insulating cotton to protect it from mechanical damage during installation, maintenance and transportation.
Page 26
DC Inverter U-match Series Cassette Type Unit Connection pipe should adopt water-proof insulating material. Its wall thickness should be 0.5-1.0mm and the pipe wall should be able to withstand 6.0MPa. The longer the connection pipe is, the worse cooling and heating performance it has. When the drop between indoor and outdoor units is larger than 10m, an oil return bend should be added every 6 meters.
Page 27
DC Inverter U-match Series Cassette Type Unit (2) Outdoor unit is above the indoor unit. It’s necessary to add oil return bend and non-return bend at the lowest and highest position of the vertical pipe, as shown below: Non-return bend Outdoor unit System gas pipe Oil return bend...
Page 28
DC Inverter U-match Series Cassette Type Unit cut surface so that the chips do not enter the pipe. (3) Remove the cut-off valve of outdoor unit and take out the flare nut from the bag of indoor unit accessories. Then fit the flare nut on the pipe and use a flaring tool to flare the mouth of connection pipe.
Page 29
DC Inverter U-match Series Cassette Type Unit 3.2.3.4 Connection Pipe of Indoor and Outdoor Units NOTICE Connect the pipe to the unit. Please follow the instructions stated in the figures ①. below. Use both spanner and torque wrench. When connecting the tapered screw nut, first apply chilled machine oil on its ②.
Page 30
DC Inverter U-match Series Cassette Type Unit Screw on the flare nut of the flaring connecting pipe on the outdoor unit valve. The method of screwing the flare nut is the same with that for indoor unit. Gas pipe Liquid pipe Pipe coupling 3-way valve...
Page 31
DC Inverter U-match Series Cassette Type Unit Notice: Only for the IGZPAC100NO-1, IGZPAC125NO-1, IGZPAC140NO-1, IGZPAC100NO3-1, IGZPAC140NO3-1, IGZPAC140NO3-1, IGZPAC160NO3-1 units. 3.2.4 Connection Pipe Vacuum Pumping and Leak Detection 3.2.4.1 Vacuum Pumping NOTICE Make sure the outlet of vacuum pump is away from fire source and is well- ventilated.
Page 32
DC Inverter U-match Series Cassette Type Unit (7) Slightly open the liquid valve and let some refrigerant go to the connection pipe to balance the pressure inside and outside of the connection pipe, so that air will not come into the connection pipe when removing the hose. Note that the gas and liquid valve can be opened fully only after the manifold valve assembly is removed.
Page 33
DC Inverter U-match Series Cassette Type Unit refrigerant and corrode the copper pipe-work. If a leak is suspected, all naked flames shall be removed/extinguished. If a leakage of refrigerant is found which requires brazing, all of the refrigerant shall be recovered from the system, or isolated (by means of shut off valves) in a part of the system remote from the leak.
Page 34
DC Inverter U-match Series Cassette Type Unit 3.2.6.1 Indoor Side Drainage Pipe (1) Keep pipe size equal to or greater than that of the connecting pipe (2) Install the drain piping as shown and take measures against condensation. Indoor unit Extension drain piping drain hose (commercially...
Page 35
DC Inverter U-match Series Cassette Type Unit Indoor Unit A mm IGZCAPS35NI-1 ≤12 IGZCAPS50NI-1 ≤12 IGZCAPS71NI-1 ≤15 IGZCAPB85NI-1 ≤15 IGZCAPB100NI-1 ≤15 IGZCAPB125NI-1 ≤15 IGZCAPB140NI-1 ≤15 IGZCAPB160NI-1 ≤15 3.2.6.2 Outdoor Side Drainage Pipe (1) If the outdoor unit is underneath the indoor unit, arrange the pipeline according to the following diagram.
Page 36
DC Inverter U-match Series Cassette Type Unit 3) Use saddles to fix the whole pipeline onto the wall. 3.2.6.3 Notice on Drain Lift Pipe (1) The drain lift pipe should be 1000mm or less away from ground, as shown below. (2) If multiple drain pipes are to be converged, please install according to the following process.
Page 37
DC Inverter U-match Series Cassette Type Unit 0~1000mm T-joint converging drain pipes Notice: Specifications of the converging drain pipes should be applicable to the operating capacity of the units. (1) Drain branch should be connected to the vertical or horizontal part of the main drain pipe.
Page 38
DC Inverter U-match Series Cassette Type Unit (2) See the following diagram for the method of water filling. Drain hose Above 100mm (3-7/8inch) 3.2.7 Installing the Front Panel As shown below, take off the 4 corner covers from the front panel and loose the hexagon screw bolts on the 4 fasteners to the maximum.
Page 39
DC Inverter U-match Series Cassette Type Unit (1) Temporarily hang the 4 fasteners on the corresponding hooks of the main body of the indoor unit (Do not let the conducting wires get involved into the sealing material). (2) Screw in the hexagon screws beneath the 4 fasteners by about 15mm (front panel will rise).
Page 40
DC Inverter U-match Series Cassette Type Unit decorative front panel, adjust the height of the unit again (as shown below). If the lifting level of indoor unit and the drain pipeline won't be affected, it's fine to adjust the height of indoor unit through the holes on the corners of the front panel.
DC Inverter U-match Series Cassette Type Unit Warning After installing the panel, the insulated protective cover with the thickness of 1mm shall be used to wrap the wiring terminal, Tighten the insulated glue cover on both sides with bonding tie to fix it. After connecting the communication wire, attach the flannelette on the foam to prevent the communication wire from reaching out the electric raceway(for 35/50).
Page 42
DC Inverter U-match Series Cassette Type Unit ④. The external power cord, connection wire of indoor and outdoor units and the communication cords must be effectively fixed. ⑤. The external power cord, connection wire of indoor and outdoor units and the communication cords can’t directly contact any hot objects.
Page 43
DC Inverter U-match Series Cassette Type Unit Min. Circuit sectional Power supply breaker area of power Model capacity cord V/Ph/Hz IGZPAC35NO-1 IGZPAC50NO-1 IGZPAC71NO-1 220V-240V ~50Hz IGZPAC85NO-1 208V-230V ~60Hz IGZPAC100NO-1 IGZPAC125NO-1 IGZPAC140NO-1 IGZPAC100NO3-1 IGZPAC125NO3-1 380V-415V 3N~50Hz/60Hz IGZPAC140NO3-1 IGZPAC160NO3-1 NOTICE: ①. Fuse is located on the main board. ②.
Page 44
DC Inverter U-match Series Cassette Type Unit Please select a proper length according to local conditions. Communication cords must not be twisted together. To be in compliance EN 55014, it is necessary to use 7.5 meters long wire. ⑧. The wire gauge of communication cord should not be less than 0.75mm². It’s recommended to use 0.75mm²...
Page 45
DC Inverter U-match Series Cassette Type Unit How to connect the connection wire and power cord. Lead the connection wire and power cord through the insulation tube. Then fix the wires with wire clamps (as shown in the following figure). Warning Before working, please check whether the indoor and outdoor units are ①.
Page 46
DC Inverter U-match Series Cassette Type Unit Wire between indoor and outdoor units. Single-phase unit: IGZPAC35NO-1, IGZPAC50NO-1, IGZPAC71NO-1, IGZPAC85NO-1. Outdoor Unit Indoor Unit Wired Controller Breaker Breaker Power:220V-240V~50Hz/208V-230V~60Hz Power:220V-240V~50Hz/208V-230V~60Hz Outdoor Unit Indoor Unit Wired Controller Breaker Power:220V-240V~50Hz/208V-230V~60Hz Power:220V-240V~50Hz/208V-230V~60Hz IGZCAPS35NI-1+IGZPAC35NO-1 IGZCAPS50NI-1+IGZPAC50NO-1 ①.
Page 47
DC Inverter U-match Series Cassette Type Unit Single-phase unit: IGZPAC100NO-1, IGZPAC125NO-1, IGZPAC140NO-1. Outdoor Unit Indoor Unit Wired Controller Breaker Breaker Power:220V-240V~50Hz/208V-230V~60Hz Power:220V-240V~50Hz/208V-230V~60Hz Outdoor Unit Indoor Unit Wired Controller Breaker Power:220V-240V~50Hz/208V-230V~60Hz Power:220V-240V~50Hz/208V-230V~60Hz IGZCAPB100NI+IGZPAC100NO-1 IGZCAPB125NI+IGZPAC125NO-1 ①. Power cord 3×4.0mm² ②. Power cord 3×1.0mm² ③.
Page 48
DC Inverter U-match Series Cassette Type Unit Three-phase unit: IGZPAC100NO3-1, IGZPAC125NO3-1, IGZPAC140NO3-1, IGZPAC160NO3-1. Outdoor Unit Indoor Unit Wired Controller Breaker Breaker Power:220V-240V~50Hz/208V-230V~60Hz Power:380V-415V 3N ~ 50Hz/60Hz Outdoor Unit Indoor Unit Wired Controller Breaker Power:220V-240V~ 50Hz/208V-230V~60Hz Power:380V-415V 3N ~ 50Hz/60Hz IGZCAPB100NI +IGZPAC100NO3-1 IGZCAPB125NI +IGZPAC125NO3-1 IGZCAPB140NI +IGZPAC140NO3-1 IGZCAPB160NI +IGZPAC160NO3-1...
Page 49
DC Inverter U-match Series Cassette Type Unit Electrical wiring of indoor unit and Electrical wiring of outdoor unit. Warning High and low voltage wires should be led through different rubber rings of the ①. electric box cover. Do not bundle up the connection wire and communication wire of wired control ②.
Page 50
DC Inverter U-match Series Cassette Type Unit 2) Outdoor side. Remove the big handle/front panel of the outdoor unit and insert one end of the communication cord and the power cord to the terminal board. Single-phase unit: IGZPAC35NO-1, IGZPAC50NO-1, IGZPAC71NO-1, IGZPAC85NO-1.
Page 51
DC Inverter U-match Series Cassette Type Unit The communication wire gets in from the upper hole The power cords of outdoor unit and indoor unit get in from the lower hole. Wire routing of unified power supply for single phase. The communication wire gets in from the upper hole The power cords of outdoor unit and...
Page 52
DC Inverter U-match Series Cassette Type Unit Three-phase unit: IGZPAC100NO3-1, IGZPAC125NO3-1, IGZPAC140NO3-1, IGZPAC160NO3-1. Wire routing of separated power supply for three phase. Only for IGZPAC160NO3-1. The communication wire gets in from the upper hole The power cords of outdoor unit and indoor unit get in from the lower hole.
Page 53
DC Inverter U-match Series Cassette Type Unit Wire routing of unified power supply for three-phase. Only for IGZPAC160NO3-1 The communication wire gets in from the upper hole The power cords of outdoor unit and indoor unit get in from the lower hole.
DC Inverter U-match Series Cassette Type Unit 3.4 Check after Installation Check Items after Installation Possible events due to improper Check items installation The unit may fall down, vibrate or Is the main body installed securely? produce noise. Cooling capacity may become Did you do water leakage test? unsatisfactory.
DC Inverter U-match Series Cassette Type Unit air conditioner immediately. Wait until the electric heating belt is heated enough, and then restart the air conditioner. (5) Feel the air flow of the indoor unit to see if it is normal. (6) Press the swing button or speed control button on remote control or wired control to see if the fan can run normally.
DC Inverter U-match Series Cassette Type Unit 5 Maintenance 5.1 Failures Not Caused by Faults of the AC (1) If your air conditioner fails to function normally, please first check the following items before maintenance: Problem Cause Corrective measure If you turn off the unit and then immediately turn it on, in order to protect the compressor and avoid...
Page 57
DC Inverter U-match Series Cassette Type Unit (2) The following situations are not operation failures. Problem Time of occurrence Cause Mist comes If the unit is running under high from the air During operation. humidity, the wet air in the room conditioner.
DC Inverter U-match Series Cassette Type Unit Notice: Check the above items and adopt the corresponding corrective measures. If the air conditioner continues to function poorly, please stop the air conditioner immediately and contact innova’s authorized local service center. Ask our professional service staff to check and repair the unit. 5.2 Error Code Warning If abnormal things (for example, awful smell) occur, please stop the unit...
Page 59
DC Inverter U-match Series Cassette Type Unit Error Number Error code Compressor overload protection Overload IPM protection DC fan error Driver out-of-step protection Pfc protection Startup failure Compressor phase-sequence protection Power protection IDU and ODU unmatched 4–way valve switch-over error Driver reset protection Over-current protection Master control and driver communication error...
DC Inverter U-match Series Cassette Type Unit 5.3 Unit Maintenance Warning Only professionals are allowed to carry on daily maintenance. ①. Before contacting any wire, make sure power is cut off. ②. Do not let any inflammable objects near the unit. ③.
Page 61
DC Inverter U-match Series Cassette Type Unit 5.3.1 Clean Air Filter If the air conditioner is used at a dusty place, clean the air filter regularly. (Once every half a year) How to clean the air filter 1) Open the air intake grill. Push the clasps outward and then open the air intake grill.
Page 62
DC Inverter U-match Series Cassette Type Unit 5.3.2 Clean Air Intake Grill How to clean the air intake grill 1) Open the air intake grill. Same with step 1 in “Clean Air Filter”. 2) Take out the air filter. Same with step 2 in “Clean Air Filter”. 3) Take out the air intake grill.
DC Inverter U-match Series Cassette Type Unit 5.3.5 Notices at the Beginning of the Using Season (1) Check if the air inlet/outlet of indoor/outdoor unit is blocked. (2) Check if the ground connection is reliable. (3) Check if the battery of remote controller is replaced. (4) Check if the air filter screen is properly installed.
Page 64
DC Inverter U-match Series Cassette Type Unit 5.4.1.2 Work Procedure Work shall be undertaken under a controlled procedure so as to minimize the risk of a flammable gas or vapour being present while the work is being performed. 5.4.1.3 General Work Area All maintenance staff and others working in the local area shall be instructed on the nature of work being carried out.
Page 65
DC Inverter U-match Series Cassette Type Unit 5.4.1.7 Ventilated area Ensure that the area is in the open or that it is adequately ventilated before breaking into the system or conducting any hot work. A degree of ventilation shall continue during the period that the work is carried out. The ventilation should safely disperse any released refrigerant and preferably expel it externally into the atmosphere.
Page 66
DC Inverter U-match Series Cassette Type Unit used. This shall be reported to the owner of the equipment so all parties are advised. Initial safety checks shall include: (1) That capacitors are discharged: this shall be done in a safe manner to avoid possibility of sparking.
Page 67
DC Inverter U-match Series Cassette Type Unit 5.4.3 Repair to Intrinsically Safe Components Do not apply any permanent inductive or capacitance loads to the circuit without ensuring that this will not exceed the permissible voltage and current permitted for the equipment in use. Intrinsically safe components are the only types that can be worked on while live in the presence of a flammable atmosphere.
Page 68
DC Inverter U-match Series Cassette Type Unit and continuing to fill until the working pressure is achieved, then venting to atmosphere, and finally pulling down to a vacuum. This process shall be repeated until no refrigerant is within the system. When the final OFN charge is used, the system shall be vented down to atmospheric pressure to enable work to take place.
Page 69
DC Inverter U-match Series Cassette Type Unit (3) Before attempting the procedure ensure that: 1) Mechanical handling equipment is available, if required, for handling refrigerant cylinders; 2) All personal protective equipment is available and being used correctly 3) The recovery process is supervised at all times by a competent person 4) Recovery equipment and cylinders conform to the appropriate standards.
DC Inverter U-match Series Cassette Type Unit Cylinders shall be complete with pressure relief valve and associated shut-off valves in good working order. Empty recovery cylinders are evacuated and, if possible, cooled before recovery occurs. The recovery equipment shall be in good working order with a set of instructions concerning the equipment that is at hand and shall be suitable for the recovery of flammable refrigerants.
Page 72
Ahlsell Sverige AB Business Area Kyl Myrangatan 10 SE-745 36 Enköping Sweden Internet. www.ahlsell.com www.kcc.se...
Need help?
Do you have a question about the Innova IGZCAPS35NI-1 and is the answer not in the manual?
Questions and answers