Subscribe to Our Youtube Channel
Related Manuals for Drester Boxer Triple Combi
Summary of Contents for Drester Boxer Triple Combi
- Page 1 DRESTER BOXER D33C `TRIPLE Combi` ENGLISH Original operators manual (Ref: Illustration attachment 17016) DEUTSCH Originalbetriebsanleitung (Hinweiss: Bildbeilage 17016) FRANCAIS SVENSKA...
-
Page 2: Table Of Contents
**********ENGLISH********** CONTENTS: PURPOSE OF THE MACHINE ASSEMBLY PLACING THE UNIT INSTALLATION PERMITTED SOLVENTS PERMITTED SOLVENT DRUMS COLLECTING TRAY PREPARATIONS FOR USE SERVICE SAFETY INFORMATION WARRANTY TECHNICAL DATA OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS OPERATION WITHOUT TAP WATER CONNECTION THE COAGULATION PROCESS CHANGING THE FILTER... -
Page 4: Purpose Of The Machine
PURPOSE OF THE MACHINE The machine is intended for cleaning of air-driven spray-guns that have been used for painting. The left side of the unit has two separate areas for cleaning: 1. An automatic washer (items 1A illustration 1), intended for cleaning of spray-guns with gravity fed paint-cups. In this washer either thinner-based solvents or water-based solvents can be used. - Page 5 Fit the flange for the extraction (item 3 illustration 1) with the 4 screws included Fit the glass window into place (item 13 illustration 1) The air-line on the left side of the unit (item 4 illustration 1) is during transport placed inside the unit. Take it out, and fasten it with the magnet in a suitable place on the left side.
- Page 6 Zone 1 (ref. ATEX-directive 1999/92 EC). If the DRESTER BOXER TRIPLE C is installed in locations classified as Zone 2 (or in unclassified locations), the area within a radius of 1 m from the DRESTER BOXER T RIPLE C is to be classified as Zone 1, and within a radius of an additional 2.5 m from the unit as Zone 2 (total...
-
Page 7: Permitted Solvents
It is important that all users are informed of what solvent is being used, at all times. PERMITTED SOLVENT DRUMS The DRESTER BOXER TRIPLE C can be used with different types of drums, but they must comply with the following: The drums must fit into the unit The drums must be leak-free. -
Page 8: Preparations For Use
PREPARATIONS FOR USE Remove the front panel (item 5 illustration 1) by lifting it up-and-out. Remove the foot-pedal console (items 6 illustration 1) by lifting it up and folding it out to the side (see illustration 2). Solvent drums for the left side of the unit: Two drums are needed, one drum that is empty, and one drum full of solvent. - Page 9 When changing drums: Check and if necessary clean the strainers on the suction hoses. When changing filters: Check and if necessary clean the strainer on the suction pipe. Take out the filtrate container (item 7 illustration 2) and empty it completely. Rinse it with water and wipe it off with cloth or paper.
-
Page 10: Safety Information
WARRANTY Hedson Technologies AB will replace all faulty parts on the DRESTER BOXER TRIPLE C with new parts in accordance with the “Warranty Terms for Hedson Technologies AB No. 7.2-8”. This warranty only remains valid if the machine is used in the prescribed manner, and it does not cover the cost of repairs. - Page 11 Maximum drum size: Compressed air needed: 7–12 bar (110-180 psi), 250 l/min (9 cfm) (450 l/min (16 cfm) with DRESTER AIRVENT 11660) Ventilation capacity required: 500 m3/h (310 cfm) Pump capacity: 10 l/min Solvent pressure 2 bar (30 psi) Weight...
-
Page 12: Operating Instructions
OPERATING INSTRUCTIONS Empty the spray-gun of any residual paint into a separate spills-dish. Open the main valve for compressed air (item 7 illustration 1). Open the lid for the automatic washer (make sure it `clicks` into the full open position). Place the spray-gun inside (see illustration 5). - Page 13 OPERATING INSTRUCTIONS Empty the spray-gun of any residual paint into a separate spills-dish. Open the main valve for compressed air (item 7 illustration 1). Open the lid for the manual sink. By pressing foot pedal No.10B in illustration 1, recirculating water will be fed through the cleaning brush placed in the sink (item 1 illustration 7B).
-
Page 14: The Coagulation Process
When this is done, close the drain-valve CHANGING THE FILTER N.B.: MAKE SURE THAT YOU USE ORIGINAL DRESTER FILTERS, NR. 8701 (MAIN FILTER), AND NR. 8702 (PRIMARY FILTER). THESE FILTERS HAVE BEEN TESTED AND APPROVED BY THE PAINT MANUFACTURERS. The primary filter (item 2 illustration 11) collects most of the coagulated sludge, while the main filter (item 1 illustration 11) collects the finer paint particles.
Need help?
Do you have a question about the Boxer Triple Combi and is the answer not in the manual?
Questions and answers