Table of Contents
Advertisement
Quick Links
I
F THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY
PROPERTY DAMAGE
-T
O PREVENT THE RISK OF PROPERTY DAMAGE
OR USE GASOLINE OR OTHER FLAMMABLE LIQUIDS OR VAPORS IN THE VICINITY FO THIS APPLIANCE
- WHAT TO DO IF YOU SMELL GAS:
I
NSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER
O
NLY PERSONNEL THAT HAVE BEEN TRAINED TO INSTALL
EQUIPMENT SPECIFIED IN THIS MANUAL SHOULD SERVICE THE EQUIPMENT
RESPONSIBLE FOR ANY INJURY OR PROPERTY DAMAGE ARISING FROM IMPROPER SERVICE OR SERVICE PROCEDURES
YOU SERVICE THIS UNIT
ADDITION
MANUAL
SERVICING OR REPAIR OF THE EQUIPMENT SPECIFIED IN THIS MANUAL
REPAIR THE EQUIPMENT SPECIFIED IN THIS MANUAL WITHOUT PROPER TRAINING MAY RESULT IN PRODUCT DAMAGE
PROPERTY DAMAGE
Installer - Affix this manual, Installation Guide, and Warranty adjacent to the appliance.
Owner - Read and keep all product literature in a safe place for future reference.
S
HOULD OVERHEATING OCCUR, OR THE GAS SUPPLY FAIL TO SHUT OFF,
SHUT OFF THE MANUAL GAS VALVE TO THE FURNACE BEFORE SHUTTING OFF
THE ELECTRICAL SUPPLY.
HI-3002A
02/2019
*PG1660 GAS-FIRED PACKAGED UNIT
USER'S INFORMATION MANUAL
USER'S INFORMATION
,
PERSONAL INJURY OR LOSS OF LIFE
- D
O NOT TRY TO LIGHT ANY APPLIANCE
- D
O NOT TOUCH ANY ELECTRICAL SWITCH
- I
MMEDIATELY CALL YOUR GAS SUPPLIER FORM A NEIGHBOR
'
.
SUPPLIER
S INSTRUCTIONS
- I
F YOU CANNOT REACH YOUR GAS SUPPLIER
,
YOU ASSUME RESPONSIBILITY FOR ANY INJURY OR PROPERTY DAMAGE WHICH MAY RESULT
,
IN JURISDICTIONS THAT REQUIRE ONE OR MORE LICENSES TO SERVICE THE EQUIPMENT SPECIFIED IN THIS
,
ONLY LICENSED PERSONNEL SHOULD SERVICE THE EQUIPMENT
,
PERSONAL INJURY OR DEATH
WARNING
RECOGNIZE THIS SYMBOL AS A SAFETY PRECAUTION.
Our continuing commitment to quality products may mean a change in specifications without notice.
© 2016, 2019 Goodman Company, L.P.
5151 San Felipe St., Suite 500, Houston, TX 77056
www.goodmanmfg.com • www.amana-hac.com
is a registered trademark of Maytag Corporation or its related companies and is used under license. All rights reserved.
,
A FIRE OR EXPLOSION MAY RESULT CAUSING
.
,
,
PERSONAL INJURY OR DEATH
DO NOT STORE COMBUSTIBLE MATERIALS
.
. D
O NOT USE ANY PHONE IN YOUR BUILDING
'
S PHONE
,
CALL THE FIRE DEPARTMENT
,
SERVICE AGENCY OR THE GAS SUPPLIER
,
,
ADJUST
SERVICE OR REPAIR
. T
HE MANUFACTURER WILL NOT BE
. I
MPROPER INSTALLATION
,
OR ATTEMPTING TO INSTALL
.
T
O AVOID PROPERTY DAMAGE, PERSONAL INJURY OR DEATH, DO NOT USE
THIS FURNACE IF ANY PART OF THE FURNACE HAS BEEN UNDER WATER.
I
MMEDIATELY CALL A QUALIFIED SERVICE TECHNICIAN TO INSPECT THE
FURNACE AND TO REPLACE ANY PART OF THE CONTROL SYSTEM AND ANY
GAS CONTROL HAVING BEEN UNDER WATER.
FOR CALIFORNIA CONSUMERS
.
.
. F
OLLOW THE GAS
.
.
(
, "
")
HEREINAFTER
SERVICE
THE
. I
F
. I
,
,
ADJUSTMENT
,
,
ADJUST
SERVICE OR
,
WARNING
PROP 65 WARNING
Cancer and Reproductive Harm
www.P65Warnings.ca.gov
N
-
0140M00517-A
Advertisement
Table of Contents
Related Manuals for Goodman PG1660
Summary of Contents for Goodman PG1660
- Page 1 0140M00517-A RECOGNIZE THIS SYMBOL AS A SAFETY PRECAUTION. Our continuing commitment to quality products may mean a change in specifications without notice. © 2016, 2019 Goodman Company, L.P. HI-3002A 02/2019 5151 San Felipe St., Suite 500, Houston, TX 77056 www.goodmanmfg.com •...
-
Page 2: Do's And Do Not's
NTRODUCTION MPORTANT WNER The intent of this bulletin is to acquaint the user with some of Your warranty certificate is supplied with the unit. Read the the mechanical features and adjustments of the rooftop gas warranty carefully and note what is covered. Keep the warranty fired air conditioning units. - Page 3 EQUIREMENTS HERMOSTAT This unit will not operate properly without a good quality, correctly installed thermostat. It is very important that the thermostat be located where it can best “sense” the average room temperature. Be sure the thermostat is not exposed to hot or cold drafts or to hot or cold spots on the wall, such as those received from outside walls, walls with pipes inside, or from openings into the attic.
- Page 4 PERATING NSTRUCTIONS FIRE OR EXPLOSION HAZARD Failure to follow safety warnings exactly could result in serious injury, death or property damage. -Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. -WHAT TO DO IF YOU SMELL GAS •...
-
Page 5: Heating Shut Down
6. This appliance is equipped with an ignition device which au- EATING tomatically lights the burners. DO NOT try to light the burner TART by hand. To put your unit into operation, follow the steps listed below. 7. Turn gas control switch “OFF”. Do not force. 1. - Page 6 AFETY IRCUITS A number of safety circuits are employed to ensure safe and proper unit operation. These circuits serve to control any potential safety hazards and, as inputs in the monitoring and diagnosis of abnormal operation. WARNING F THE SECONDARY LIMIT CONTROL SHOULD OPEN, THE REASON MUST BE RAIN BURNER SHIELD...
- Page 7 2. Check the room thermostat to see if it is correctly set. OLLOUT IMIT 3. If the room thermostat is correctly set, call a qualified servicer to determine if one of the compressor protection devices has WARNING opened. HE CAUSE OF THE ROLLOUT PROTECTION DEVICE OPENING MUST BE INVEST- IGATED BY A QUALIFIED SERVICER BEFORE ANY ATTEMPT IS MADE TO RESET HORT YCLE...
-
Page 8: Burner Flame
Maintenance is to be performed by a qualified service technician only. User maintenance is to be restricted to frequent air filter changes and to ensure the warnings and notices found else- where in this manual be followed. We recommend that at a minimum system maintenance be performed by a qualified service technician prior to the beginning of each heating season, Check the... - Page 9 ILTERS ILTERS EMOVAL Remove the filter access panel on return air side of the unit then remove filters. WARNING ILTER LEANING AND EPLACEMENT O AVOID PROPERTY DAMAGE, PERSONAL INJURY OR DEATH, DISCONNECT Remember to always replace the panels and screws before ELECTRICAL POWER BEFORE REMOVING FILTERS.
-
Page 10: For Your Safety Read Before Operating
AFETY ABELS NOTE: If safety labels are missing or illegible, contact the installing dealer or our Customer Service Department for ordering information. 2 - Stage Gas Valve FOR YOUR SAFETY READ BEFORE OPERATING WARNING: Improper If you do not follow these instructions exactly, alteration, service or a fire or explosion may result causing property maintenance can... - Page 11 WARNING HAZARD OF ELECTRIC SHOCK. DISCONNECT THE ELECTRIC POWER BEFORE SERVICING. ADVERTISSEMENT DECONNECTER DU CIRCUIT D'ALIMENTATION ELECTRIQUE AVANT L'ENTRETIEN. ADVERTENCIA PELIGRO DE CHOQUE ELECTRICO. DESCONECTE LA POTENCIA ELECTRICA ANTES DEL MANTENIMIENTO. B14933-152A...
- Page 12 ROUBLESHOOTING EFORE EQUEST A ERVICE If your unit is not operating or is performing improperly, take time to perform the following checks before requesting service. A couple of simple checks may allow you to avoid a service call. If the following steps do not resolve the problem, contact a qualified servicer for further troubleshooting and/or repairs.
Need help?
Do you have a question about the PG1660 and is the answer not in the manual?
Questions and answers