Summary of Contents for Barbeques Galore Arrosto
- Page 1 ARROSTO PIZZA OVEN ASSEMBLY AND OPERATION INSTRUCTIONS ARROSTO FOR OUTDOOR USE ONLY ITEM CODE: ARRPIZGAS ARROSTO GAS PIZZA OVEN-Manual_v5.indd 1 19/12/17 1:28 pm...
- Page 2 ARROSTO GAS PIZZA OVEN-Manual_v5.indd 2 19/12/17 1:28 pm...
- Page 3 WARRANTY AND CONSUMER GUARANTEE Barbeques Galore Warranty is provided in addition to other rights and remedies as set out below under ‘Consumer Guarantees’. Warranty Term Subject to the conditions set out below, this product is warranted to the purchaser to be free from defects in workmanship and materials from the date of purchase for the terms specified below.
- Page 4 Service Contact Point – Please contact your place of purchase for warranty repairs or service. BRANCHES AUSTRALIA WIDE Barbeques Galore Limited, Building A2, Campus Business Park, 350-374 Parramatta Road, Homebush, NSW 2140 Telephone 1300 301 392 e-mail: CSR1@bbqgalore.com.au Website: www.bbqgalore.com.au ARROSTO GAS PIZZA OVEN-Manual_v5.indd 2 19/12/17 1:28 pm...
- Page 5 • in this manual. Do not modify this appliance and do not use • Do not place articles on or against this appliance. unauthorised spare parts. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 3 19/12/17 1:28 pm...
- Page 6 DO NOT USE OR STORE FLAMMABLE MATERIALS IN OR NEAR THIS APPLIANCE. DO NOT PLACE ARTICLES ON OR AGAINST THIS APPLIANCE. DO NOT MODIFY THIS APPLIANCE. USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR PIZZA OVEN. SAVE THESE INSTRUCTIONS ARROSTO GAS PIZZA OVEN-Manual_v5.indd 4 19/12/17 1:28 pm...
-
Page 7: Hardware Pack
Find a large, clean area in which to assemble your pizza oven. Please refer to the parts list and assembly diagram as necessary. Ensure any transit protection or packaging is removed. Do not throw out any packaging until pizza oven is fully assembled in case parts are still enclosed. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 5 19/12/17 1:28 pm... -
Page 8: Parts List
Roast racks HKGP11d Leg (back right) HKGP06 Pizza stone HKGP12 Storage shelf HKGP07 Wire support grid HKGP13 Gas bottle shelf HKGP08 Igniter HKGP14 Hose & regulator HKGP09 Control knob HKGP15 Heat shield ARROSTO GAS PIZZA OVEN-Manual_v5.indd 6 19/12/17 1:28 pm... - Page 9 STEP 2 ATTACH SMOKE CHIMNEY — Attach the smoke chimney (1) to the ring on the top of the oven body (2) using 3 x M5x12mm screws as shown below. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 7 19/12/17 1:28 pm...
- Page 10 Slide a spacer onto each screw and then a M6 washer onto each screw. Fasten all screws and the shield to the oven body. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 8 19/12/17 1:28 pm...
- Page 11 Note, the position of each leg tab, must be at the top and facing the correct direction as shown above. Make sure all the screws are tightly assembled. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 9 19/12/17 1:28 pm...
- Page 12 — Place the wire roast racks (5) onto the support shelves inside the pizza oven above the pizza stone as shown below. Your Arrosto Outdoor Gas Pizza Oven is now ready to use. PLEASE READ THE LIGHTING INSTRUCTIONS CAREFULLY BEFORE USE! ARROSTO GAS PIZZA OVEN-Manual_v5.indd 10 19/12/17 1:28 pm...
-
Page 13: The Gas System
— Firmly hand tighten and then be sure to check for leaks at all gas connections. BE SURE TO CHECK FOR LEAKS AT ALL CONNECTIONS P.O.L. LEFT HAND THREAD 7/16" - 20 UNF THREAD ARROSTO GAS PIZZA OVEN-Manual_v5.indd 11 19/12/17 1:28 pm... -
Page 14: Installation
Should minimum clearances not be adhered to severe flare up may be experienced due to a lack of airflow around the pizza oven, thus voiding manufacture’s warranty. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 12 19/12/17 1:28 pm... - Page 15 — Use protective gloves when cooking or handling any parts of the pizza oven while in use. — In the event of a gas leak, shut off gas supply immediately and extinguish any flames. Contact the customer service line -1300 301 392. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 13 19/12/17 1:28 pm...
- Page 16 WARNING: IF THE BURNER FAILS TO IGNITE, TURN THE CONTROL KNOB OFF (CLOCKWISE) AND ALSO TURN THE CYLINDER VALVE OFF, WAIT FOR 5 MINUTES BEFORE OPENING THE DOOR, AND REPEAT THE LIGHTING PROCEDURE. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 14 19/12/17 1:28 pm...
-
Page 17: Troubleshooting
FFD device is faulty. Replace FFD. IF YOU HAVE ANY QUESTIONS OR QUERIES ABOUT THE OPERATION OR MAINTENANCE OF YOUR GAS PIZZA OVEN PLEASE CALL THE CUSTOMER SERVICE NUMBER ON 1300 301 392. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 15 19/12/17 1:28 pm... - Page 18 This is easily done by loosening the two nuts on either side and moving the sensor up or down and then retightening to fix in place. Loosen the two nuts to the thermocouple sensor, then adjust the height to correct position. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 16 19/12/17 1:28 pm...
-
Page 19: Care And Maintenance
This will allow the pizza toppings to cook through first before placing the pizza on the stone to crisp the base. Also recommend the use of pizza trays if you have them. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 17 19/12/17 1:28 pm... - Page 20 It is recommended that your Gas Pizza Oven is serviced by an authorised gas technician every 24 months. DO NOT MODIFY THE PIZZA OVEN OR USE UNAUTHORISED PARTS. ANY SERVICING SHALL BE CARRIED OUT BY AUTHORISED PERSONNEL. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 18 19/12/17 1:28 pm...
- Page 21 Figure 1 Outdoor Area, Example 1 — Within a partial enclosure that includes an overhead cover and not more than two walls. (Refer to example 2). Figure 2 Outdoor Area, Example 2 ARROSTO GAS PIZZA OVEN-Manual_v5.indd 19 19/12/17 1:28 pm...
- Page 22 Open side at least 25% of the total wall area — In the case of balconies, at least 20% of the total side, back and front wall areas shall remain open and unrestricted. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 20 19/12/17 1:28 pm...
-
Page 23: Replacement Parts
Call 1300 301 392 for your nearest store and for after sales service and support. After Sales Support YEAR Distributed by Barbeques Galore WARRANTY Call 1300 301 392 for your nearest store and for after sales service and support. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 21 19/12/17 1:28 pm... - Page 24 ARROSTO Distributed by Barbeques Galore Call 1300 301 392 for your nearest store and for after sales service and support. ARROSTO GAS PIZZA OVEN-Manual_v5.indd 22 19/12/17 1:28 pm...