Congratulations! By choosing the Island Clean Air Duster 3000, you have acquired a lifetime of clean air! The Duster 3000 was developed after years of research and development to find a solution to the problem of poor indoor air quality. Constructed of only the highest stage filtration process represent a dramatic breakthrough in the application of modern air cleaning technology.
This machine is not to be used in hazardous locations, where explosive, combustible, corrosive, or conductive dust, vapors, or gases are present. Use of the Duster 3000 without filters or with non-ICA branded filters will void the warranty. Duster 3000 Setup Step 1: Uncrate the Duster 3000 Remove all front wooden panels with a #2 Philips screwdriver or power tool.
Page 4
The yellow light indicates that the filters are dirty and need cleaning or replacing. The Duster 3000 will automatically shut down when the yellow light comes on to prevent permanent damage to the motor. The yellow light has been factory preset to go off around 2300 CFM or lower.
Page 5
Using non-ICA branded filters in the Duster 3000 will: not seal properly, impede airflow, jeopardize employee safety, int void the warranty. Be sure to turn the Duster 3000 off before removing or cleaning any filters. *** Proper Cleaning & Maintenance...
Top Filters The Duster 3000 has two options for the top filter. The standard unit has the MP85 Top Filter and the Fume Control unit has the AC24 Activated Carbon Top Filter for additional fume absorption. MP85 Top Filter (Part #11602) Filters smaller particles down to 0.3 microns.
Troubleshooting The Duster 3000 is designed to run when connected to an adequate power supply and with all filters installed and cleaned. Most issues can be solved by: Ensuring adequate power is supplied to the unit (15A at 110V). We highly suggest using an isolated circuit so that the unit does not have to share power with other equipment.
Page 8
ISLAND CLEAN AIR INC. #101 - 326 E. Kent Avenue South Southbridge Business Park, Vancouver, BC, V5X 4N6, Canada Tel: (604) 322- -8674 www.islandcleanair.com Committed to Green ATEX Approved CSA Certified Air Resources Board Printed in Canada Specifications subject to change without notice May 2020...
Need help?
Do you have a question about the Duster 3000 and is the answer not in the manual?
Questions and answers