Page 1
SERVICE MANUAL SERVICE MANUAL AZ2FM AZ2FM CHASSIS CHASSIS Segment: P-2F Segment: P-2F V V e e r r s s i i o o n n D D a a t t e e S S u u b b j j e e c c t t 1 1 .
Replace these co critical for safe operation. Replace these co mponents with Sony mponents with Sony parts whose part number parts whose part numbers appear as shown in this m...
WARNINGS AND CAUTIONS USE CAUTION WHEN HANDLING THE LCD PANEL When repairing the LCD panel, be sure you are grounded by using a wrist band. When repairing the LCD panel on the wall, the LCD panel must be secured using the 4 mounting holes on the rear cover. Do not press on the panel or frame edge to avoid the risk of electric shock.
SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer: 1. Check the area of your repair for unsoldered or poorly soldered connections. Check the entire board surface for solder splashes and bridges. 2.
Page 13
SAFETY CHECK-OUT Leakage Test The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1.
SELF DIAGNOSIS FUNCTION The units in this manual contain a self-diagnostic function. If an error occurs, the STANDBY LED will automatically begin to flash. The number of times the LED flashes translates to a probable source of the problem. A definition of the STANDBY LED flash indicators is listed in the instruction manual for the user’s knowledge and reference. If an error symptom cannot be reproduced, the remote commander can be used to review the failure occurrence data stored in memory to reveal past problems and how often these problems occur.
SELF DIAGNOSIS FUNCTION DISPLAY OF STANDBY LED FLASH COUNT [ FLASH COUNT ] 6 times 8 times LED ON sec. LED OFF LED OFF sec. sec. SELF-DIAGNOSTIC SCREEN DISPLAY For errors with symptoms such as “power sometimes shuts off” or “screen sometimes goes out” that cannot be confirmed, it is possible to bring up past occurrences of failure for confirmation on the screen: [To Bring Up Screen Test] In standby mode, press buttons on the remote commander sequentially in rapid succession as shown below:...
Page 19
SELF DIAGNOSIS FUNCTION [SELF DIAGNOSTIC SCREEN DISPLAY] a) Press to select “SELF DIAGNOSIS”. b) Press to enter the menu. FACTORY MENU SELF DIAGNOSIS c) Press to returned “FACTORY MENU”. INPUT SOURCE ATV BACK << WHITE BALANCE >> AUDIO ERROR COLOR TEMP >>...
Page 21
SEC 1. DISASSEMBLY AND PART LIST • Items with no part number and no description are not stocked because they are seldom required for roution service. • The construction parts of an assembled part are indicated with a collation number in the remark colum. •...
Page 23
DISASSEMBLY AND PART LIST 1- . KLV-26BX320 1-1-1. STAND ASSY AND REAR COVER ASSY REF. No. PART No. DESCRIPT ION MARK 4-262-537-01 REAR COVER BARE (GF26) 4-158-354-01 NECK (M3B) 4-158-400-01 COVER, NECK (M3B) X-2514-986-2 BASE (M3B) ASSY T.B.D T.B.D T.B.D T.B.D...
DISASSEMBLY AND PART LIST 1-1. KLV-26BX320 1-1-3. VESA BRACKET REF. No. PART No. DESCRIPT ION MARK 4-272-462-01 BRACKET VESA (M4) 4-262-572-01 SUPPORT, PANEL (GF26) 1-489-579-11 SW ITCH UNIT 1-474-297-11 STATIC CONVERTER (TV)-G13 1-910-103-22 CONNECTOR ASSY 26 FFC 1-857-883-11 MOUNTED PW B A 1-839-056-11 POW ER-SUPPLY CORD 1.98M...
Page 27
DISASSEMBLY AND PART LIST 1-1. KLV-26BX320 1-1-5. SPEAKER AND SP BRACKET REF. No. PART No. DESCRIPT ION MARK 4-262-546-01 BRACKET, SP (GF26L) 1-858-341-11 LOUDSPEAKER (4X10CM) 4-262-547-01 BRACKET, SP (GF26R) T.B.D T.B.D T.B.D T.B.D...
Page 29
DISASSEMBLY AND PART LIST 1-1. KLV-26BX320 1-1-6. H BOARD, LCD PANEL AND BEZEL ASSY REF. No. PART No. DESCRIPT ION MARK 1-811-371-11 LCD PANEL (C26B3-L07) 4-264-371-01 BRACKET, VESA (GF26L) 4-272-483-01 BEZEL (GF26) 1-857-884-11 MOUNTED PW B H T.B.D T.B.D T.B.D T.B.D...
Page 31
DISASSEMBLY AND PART LIST 1-2. KLV-32BX320/321/323/325 1-2-1. STAND ASSY AND REAR COVER ASSY REF. No. PART No. DESCRIPT ION MARK 4-262-538-01 REAR COVER BARE (GF32) KLV-32BX320 4-262-575-01 REAR COVER BARE (CF32) KLV-32BX321/323/325 4-158-354-01 NECK (M3B) 4-158-400-01 COVER, NECK (M3B) X-2514-986-2 BASE (M3B) ASSY T.B.D T.B.D...
Page 33
DISASSEMBLY AND PART LIST 1-2. KLV-32BX320/321/323/325 1-2-3. VESA BRACKET REF. No. PART No. DESCRIPT ION MARK 4-264-374-01 BRACKET, VESA (GF32L) KLV-32BX320 4-265-974-01 BRACKET, VESA (CF32) KLV-32BX321/323/325 4-272-463-01 BRACKET VESA (M6) 4-262-572-01 SUPPORT, PANEL (GF26) 1-910-103-23 CONNECTOR ASSY 32 FFC 1-489-579-11 SW ITCH UNIT KLV-32BX320 1-489-580-11...
Page 35
DISASSEMBLY AND PART LIST 1-2. KLV-32BX320/321/323/325 1-2-5. SPEAKER AND SP BRACKET REF. No. PART No. DESCRIPT ION MARK 4-262-548-01 BRACKET, SP (GF32L) KLV-32BX320 4-262-577-01 BRACKET, SP (CF32L) KLV-32BX321/323/325 1-858-341-11 LOUDSPEAKER (4X10CM) 4-262-549-01 BRACKET, SP (GF32R) KLV-32BX320 4-262-578-01 BRACKET, SP (CF32R) KLV-32BX321/323/325 T.B.D T.B.D...
Page 37
DISASSEMBLY AND PART LIST 1-2. KLV-32BX320/321/323/325 1-2-6. H BOARD, LCD PANEL AND BEZEL ASSY REF. No. PART No. DESCRIPT ION MARK 1-811-372-11 LCD PANEL (C32B6-L03) 1-857-884-11 MOUNTED PW B H KLV-32BX320 1-857-884-21 MOUNTED PW B H KLV-32BX321/323/325 4-272-484-01 BEZEL (GF32) KLV-32BX320 4-272-537-01 BEZEL (CF32)
Page 39
DISASSEMBLY AND PART LIST 1-3. KLV-37BX320 1-3-1. STAND ASSY AND REAR COVER ASSY REF. No. PART No. DESCRIPT ION MARK 4-262-539-01 REAR COVER BARE (GF37) 4-158-355-01 NECK (ML3B) 4-158-401-01 COVER, NECK (ML3B) X-2514-987-2 BASE (ML3B) ASSY T.B.D T.B.D T.B.D T.B.D T.B.D T.B.D T.B.D...
Page 41
DISASSEMBLY AND PART LIST 1-3. KLV-37BX320 1-3-3. VESA BRACKET REF. No. PART No. DESCRIPT ION MARK 4-272-463-01 BRACKET VESA (M6) 4-262-572-01 SUPPORT, PANEL (GF26) 1-910-103-25 CONNECTOR ASSY 37 LVDS 1-489-579-11 SW ITCH UNIT 1-474-310-11 S TA TIC CONVE RTER (TV)-G14 1-857-883-21 MOUNTED PW B A 1-839-056-11...
Page 43
DISASSEMBLY AND PART LIST 1-3. KLV-37BX320 1-3-5. SPEAKER AND SP BRACKET REF. No. PART No. DESCRIPT ION MARK 4-265-972-01 BRACKET, SP (GF37L) 1-858-341-11 LOUDSPEAKER (4X10CM) 4-265-973-01 BRACKET, SP (GF37R) T.B.D T.B.D T.B.D T.B.D...
Page 45
DISASSEMBLY AND PART LIST 1-3. KLV-37BX320 1-3-6. H BOARD, LCD PANEL AND BEZEL ASSY REF. No. PART No. DESCRIPT ION MARK 1-811-290-11 LCD PANEL (C37B1-L03) 4-272-485-01 BEZEL (GF37) 1-857-884-11 MOUNTED PW B H T.B.D T.B.D T.B.D T.B.D T.B.D T.B.D T.B.D T.B.D T.B.D T.B.D...
Page 47
DISASSEMBLY AND PART LIST 1-4. KLV-40BX420/421/423/425 1-4-1. STAND ASSY AND REAR COVER ASSY REF. No. PART No. DESCRIPT ION MARK 4-262-540-01 REAR COVER BARE (GF40) KLV-40BX420 4-262-576-01 REAR COVER BARE (CF40) KLV-40BX421/423/425 4-158-355-01 NECK (ML3B) 4-158-401-01 COVER, NECK (ML3B) X-2514-987-2 BASE (ML3B) ASSY T.B.D T.B.D...
Page 49
DISASSEMBLY AND PART LIST 1-4. KLV-40BX420/421/423/425 1-4-3. VESA BRACKET REF. No. PART No. DESCRIPT ION MARK 4-264-380-01 BRACKET, VESA (GF40) KLV-40BX420 4-265-975-01 BRACKET, VESA (CF40) KLV-40BX421/423/425 4-272-463-01 BRACKET VESA (M6) 4-264-379-01 SUPPORT, PANEL (GF40) 1-910-103-24 CONNECTOR ASSY 40 FFC 1-489-579-11 SW ITCH UNIT KLV-40BX420 1-489-580-11...
Page 51
DISASSEMBLY AND PART LIST 1-4. KLV-40BX420/421/423/425 1-4-5. SPEAKER AND SP BRACKET REF. No. PART No. DESCRIPT ION MARK 4-262-550-01 BRACKET, SP (GF40L) KLV-40BX420 4-262-579-01 BRACKET, SP (CF40L) KLV-40BX421/423/425 1-858-341-11 LOUDSPEAKER (4X10CM) 4-262-551-01 BRACKET, SP (GF40R) KLV-40BX420 4-262-580-01 BRACKET, SP (CF40R) KLV-40BX421/423/425 T.B.D T.B.D...
Page 53
DISASSEMBLY AND PART LIST 1-4. KLV-40BX420/421/423/425 1-4-6. H BOARD, LCD PANEL AND BEZEL ASSY REF. No. PART No. DESCRIPT ION MARK 1-811-329-21 LCD PANEL (S40ESP) 4-273-014-01 BEZEL (GF40) KLV-40BX420 4-273-023-01 BEZEL (CF40) KLV-40BX421 4-273-023-11 BEZEL (CF40) KLV-40BX423 4-273-023-21 BEZEL (CF40) KLV-40BX425 1-857-884-11 MOUNTED PW B H...
Page 55
DISASSEMBLY AND PART LIST 1-5. OTHER PART 1-5-1. MISCELLANEOUS 1-5-2. ACCESSORIES PART No. DESCRIPTION MARK PART No. DESCRIPTION MARK 4-272-189-01 LABEL, REAR TERMINAL 1-487-911-11 REMOTE COMMANDER (RM-SA020)
SEC 2. ADJUSTMENT HOW TO ENTERING FACTORY MENU 1) Turn on the main power switch to place this set in standby mode. 2) Press the buttons on the remote commander as follows, and entering factory menu. DISPLAY Channel Volume TV POWER 3) Factory menu display.
INPUT SOURCE ATV a) Press to select “PANEL INDEX”. WHITE BALANCE >> b) Press to status change. COLOR TEMP >> KLV-26BX320 : WXGACMO26 SERVICE MODE >> KLV-32BX320/321/323/325 : WXGA CMO32 SELF DIAGNOSIS >> KLV-37BX320 : WXGA CMO37 ADC ADJ >>...
ADJUSTMENT 3. FINISH After change the setting of PANEL INDEX and FRONT BEZEL, please execute SAVE function to save changes, and then unplug and plug the AC Power cord in order to re-load the panel parameters. WHITE BLANCE ADJUSTMENT FACTORY MENU WHITE BALANCE conduct followings.
SEC 4. DIAGRAMS 4-1. BLOCK DIAGRAM TV Tuner RF IN K9655 K7262 Speaker BD5451 Amp 5W/8W Audio Video 1 Processor (MST6300) LCD Panel B S U IF Port 26”, 32”, 37”, 40” d n YPrPb E LVDS d n Digital Video o r Processor ...
Need help?
Do you have a question about the KLV-26BX320 and is the answer not in the manual?
Questions and answers