Related Manuals for Sanipex BagnoDesign BDD-SPA-GEN4.5-1-A
Summary of Contents for Sanipex BagnoDesign BDD-SPA-GEN4.5-1-A
- Page 1 BDD-SPA-GEN4.5-1-A BAGNOSPA STEAM GENERATOR 4.5KW 220V50HZ WITH DIGITAL CONTROL PANEL, BLUETOOTH MUSIC BOX, 2X SPEAKERS, WIFI BOX AND 4 RGB LIGHTS www.sanipexgroup.com...
-
Page 2: Table Of Contents
GEN4.5-1 Cataloge Prologue------------------------------------------------------------------------------1 Users instruction---------------------------------------------------------------------1 Choosing a right location------------------------------------------------------------1 Installation drawing of the steam generator---------------------------------------2 Installation of pipeline------------------------------------------------------------3-4 Blueprint for the steam engine-----------------------------------------------------5 Electric requirements---------------------------------------------------------------6 Installation of the top light----------------------------------------------------------7 Choose your type of machine-------------------------------------------------------8 Maintenance of the steam engine--------------------------------------------------8 Configuration of steam generator--------------------------------------------------9 Cleaning of the steam generator---------------------------------------------------10 Cleaning process---------------------------------------------------------------------11... -
Page 3: Prologue
GEN4.5-1 Prologue Welcome GEN4.5-1 series stream generator,this series contains a steam furnace and a controller. You can adjust the temperature of the sauna room and set the working time of steam wish. And system contains a overheat/dry- burnt protection system security valve could prevent... -
Page 4: Installation Drawing Of The Steam Generator
GEN4.5-1 Stable and horizontal.The steam generator has a hanging groove for immobility on wall. Make sure the machine is steady and horizontally installed. On both sides and the top of the steam generator need to reserve at least 12 inches space. The place where the machine is installed must be easily cleaned up and convenient for the disassembly of the machine. -
Page 5: Installation Of Pipeline
Installation of pipeline: Warning: The installation of all the pipes should be operated by qualified plumbers with corresponding operation certificate in accordanceance with national requirements: 1. Use joints when connecting pipes. 2. Use brass pipes or copper hoses only. 3. Do not use black and galvanized or PVC pipes. Water supply pipe (1/2'') 1. - Page 6 GEN4.5-1 Important: 1. Please consult your distributors of building materials like acryl, fiber glass or other anti-heat sheet about the installation position of steam nozzle. 2. In the entire steam room, it is required that steam can not leak out. The pipes, its accessories and the holes in the wall should be air proof by applying air proof glue so that no steam will enter the holes in the wall.
-
Page 7: Blueprint For The Steam Engine
GEN4.5-1 Blueprint for the steam engine 372mm 162mm 264.5mm Safety valve Steam outlet Water inlet Water drain Manual water drain 372mm 4.5KW 372mm 200mm 264.5mm Safety valve Steam outlet Water inlet Water drain Manual water drain 372mm 6KW/9KW... -
Page 8: Electric Requirements
GEN4.5-1 Electrical requirements: Electricity supply circuitry: 1. Test the voltage of electricity supply and make sure steam engine with suitable electric voltage should be used.. 2. Insulated copper wire should be used with an anti-heat temperature of 90℃ and a specified voltage of 500V. -
Page 9: Choose Your Type Of Machine
GEN4.5-1 Choose your type of machine Measure the length, width and height (foot) of the current steam shower or bathtub room. Example; L:7xW:5xH:8 = 280 Cubic Feet You would need Model s-900 (it is that simple) However, if you shower materials are; A:Natural Stone(Granite or Marble etc.) B:Exterior walls C:Celia Heights exceeding 8 FT. -
Page 10: Configuration Of Steam Generator
GEN4.5-1 Configuration of steam generator Exclosure Water drain valve Terminal block Subsidiary water tank Insulation bracket Fuse Earth wire connector Circuit board Main water tank Steam Outlet Relay Heating Element Water level sensor Pressure relief valve C Hi-limit Transformer Manual water drain Water fill valve... -
Page 11: Cleaning Of The Steam Generator
GEN4.5-1 Cleaning of steam generator Manual cleaning 1. Before cleaning the water tank, please be sure to drain water inside tank completely. 2. Power off the steam generator, put some oxalic acid (crystal state) via steam outlet, for example, GEN4.5-1 water tank need about 220g oxalic acid with 500-800ml hot water; pls be sure that the manual water drain ball valve switch off this time. -
Page 12: Cleaning Process
GEN4.5-1 Cleaning process Make sure no water in water tank Dissolve the oxalic acid with hot water put oxalic acid via steam outlet Open the cleaning mode and wait OPL shows on screen, switch off the manual water drain ball valve Finish cleaning Trouble Shooting E0: The temperature sensor open circuit. -
Page 13: Common Troubles Trouble Shooting Methods
GEN4.5-1 Common troubles trouble shooting methods To facilitate your use and maintenance of sauna room, the following common troubles trouble shooting methods are listed for identification. Causes of troubles Trouble-shooting methods Troubles 1. The fuse is burned. The machine does 1. -
Page 14: Ampere Meter
GEN4.5-1 Ampere Meter Applicable Type Electricity supply M a x . E l e c t r i c Specifications for space of the c u r r e n t ( A ) power wire room (m 220-240V (1PH/2PH) GEN4.5-1-4.5KW 12# or 4.0mm 20.5A... - Page 15 GEN4.5-1 I m p o r t a n t : The parameter listed in the table will be varied from different place and temperature,please consultate to the qualificatory designer and architect for the more detailed use. Figure(Heating element and Power line assemble illustration) Color Light / 10W aroma pump...
- Page 16 GEN4.5-1 Figure(Heating element and Power line assemble illustration) Color Light aroma pump G B VCC R Control Panel Sub-Control Panel Music box WIFI box Real time Real time 12:30 Temp1 Temp2 Horn2 Horn1 Black Yellow 2.0mm² Black Yellow Light 2.0mm² 12V~/5-20W 2.0mm²...
- Page 17 GEN4.5-1 Figure(Heating element and Power line assemble illustration) Color Light aroma pump VCC R Control Panel Sub-Control Panel Music box WIFI box Real time Real time 25 c 12:30 Temp1 Temp2 Horn2 Horn1 Black Yellow Black 2.0mm² Yellow Light 2.0mm² 12V~/5-20W 2.0mm²...
- Page 18 GEN4.5-1 Figure(Heating element and Power line assemble illustration) Color Light aroma pump G B VCC R Control Panel Sub-Control Panel Music box WIFI box Real time Real time 12:30 Temp1 Temp2 Horn2 Horn1 Black Yellow 2.0mm² Black Yellow Light 2.0mm² 12V~/5-20W 2.0mm²...
- Page 19 Note:...
- Page 20 www.sanipexgroup.com IND-SPA-GEN4.5-1-A-12-21...
Need help?
Do you have a question about the BagnoDesign BDD-SPA-GEN4.5-1-A and is the answer not in the manual?
Questions and answers