Advertisement
Quick Links
OWNER'S MANUAL
KRATOS GAS FLOOR FRYERS
FLOOR FRYERS
User Manual – Installation Guide
29Y-010
29Y-011
29Y-012
(40lb, 3 Burner Fryer)
(50lb, 4 Burner Fryer)
(70-100lb, 5 Burner Fryer)
Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or
death. Read the installation, operating and maintenance instructions thoroughly before installing or
servicing this equipment.
If installing the fryer with Propane (LP) gas a Commercially Approved Regulator MUST be installed on the
fryer in addition to the tank regulator.
Units installed without an external appliance regulator will cause damage to parts and will void the
warranty.
Page 1
Revision 07/29/2021
Advertisement
Subscribe to Our Youtube Channel
Summary of Contents for KRATOS 29Y-010
- Page 1 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS FLOOR FRYERS User Manual – Installation Guide 29Y-010 29Y-011 29Y-012 (40lb, 3 Burner Fryer) (50lb, 4 Burner Fryer) (70-100lb, 5 Burner Fryer) Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.
- Page 2 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS To insure proper warranty record your information here: Date of Purchase:_________________________________ Dealer Purchase from:_________________________________ Name of Installer:________________________Phone Number:__________________________ Model Number:_________________________________ Serial Number:______________________________________ Page 2 Revision 07/29/2021...
- Page 3 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS SAFETY PRECAUTIONS Before installing and operating this equipment, be sure everyone involved in its operation is fully trained and aware of precautions. Accidents and problems can be caused by failure to follow fundamental rules and precautions.
-
Page 4: Table Of Contents
RETAIN THIS MANUAL FOR FUTURE REFERENCE. MODELS This manual is for Kratos Gas Floor Model Fryers with 35-40 pound (29Y-010), 50-55 pound (29Y- 011), and 70-100 pound (29Y-012) capacities. The capacity is described on the serial plate that is located on the inside of the front door. -
Page 5: Specifications
OWNER’S MANUAL KRATOS GAS FLOOR FRYERS PECIFICATION Dimensions Crated Width (in) Depth (in) Height (in) Connection Total Model Weight (in) BTU/Hr (lbs.) 15.5” 14.0” 30.3” 14.0” 47.2” 34.7” 6.0” 4.2” 7.0” 29Y-010 90,000 15.5” 14.0” 30.3” 14.0” 47.2” 34.7” 6.0”... -
Page 6: Installation
OWNER’S MANUAL KRATOS GAS FLOOR FRYERS Installation Installation must conform with local codes, or in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.1, Natural Gas Installation Code, CAN/CGA-B149.1, or the Propane Installation Code, CAN/CGA-B149.2, as applicable. - Page 7 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS Step #2: Install the Legs (or Casters) and Restraints A set of legs or casters is packed with the fryer. Mounting fasteners are pre- mounted on the base plates. 1. Raise fryer sufficiently to allow legs or casters to be screwed into the base plate.
- Page 8 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS Step #3: Flue Installation 1. Unpack the flue box and flue wrap 2. Slide the flue box over the flue and secure it with the two self-tapping screws using a 5/16” socket 3. Slide the flue wrap over the flue.
- Page 9 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS Step #4: Check Clearances and Ventilation Select a firm, level location for your fryer. Leave clearance, whenever possible, so that access from the rear is possible to permit cleaning. If the unit is to be set on non-combustible flooring, such as a concrete slab, 3 inches minimum toe room must be provided to prevent restriction of the air opening in the bottom of the unit.
- Page 10 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS Step #5: Gas Connection A 3/4" male NPT line for the gas connection is located near the lower right rear corner of the fryer. The serial plate (located inside the front door of the fryer) indicates the type of gas the unit is equipped to burn (natural gas or propane).
- Page 11 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS Step #5: Gas Connection (Continued) Connect the gas supply directly to the 3/4" male NPT connector located near the lower left rear corner of the fryer. When tightening the supply pipe, be sure to hold the mating connector extending from the unit securely with a wrench.
-
Page 12: Operation
OWNER’S MANUAL KRATOS GAS FLOOR FRYERS PERATION Lighting IF YOU SMELL GAS DURING THE LIGHTING PROCEDURE, IMMEDIATELY SHUT OFF THE GAS SUPPLY UNTIL THE LEAK HAS BEEN CORRECTED! Open the burner compartment door and do the following: 1. Turn thermostat to “OFF”... - Page 13 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS 6. Pack solid shortening into the zone below the tubes, all spaces between the tubes, and at least an inch above the top of the tubes before lighting the fryer. If any air spaces are left around the heat tube surfaces when the heat is turned on, the tube surfaces will become red hot, burn the solid shortening, weaken the frypot, and could result in a fire.
-
Page 14: Cooking Hints
OWNER’S MANUAL KRATOS GAS FLOOR FRYERS OOKING INTS USER TIPS • Smoking oil means that the temperature is too high, or that the oil has broken down. Time to filter or replace. • Gum in frypot denotes a need for thorough cleaning (see “Weekly Cleaning” on page 14) •... - Page 15 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS 5. Close drain valve and strain the oil back into the frypot through several thicknesses of cheesecloth, or filter it back using a filter machine. 6. Replace the basket support frame (if applicable) 7. Add oil or shortening to MIN oil level mark on rear of frypot.
-
Page 16: Parts
OWNER’S MANUAL KRATOS GAS FLOOR FRYERS 2. To keep the pilot lit, turn the gas valve to “L” in Pilot. 3. To shut off all gas to the system, including the pilot, turn the gas valve knob to OFF. EXTENDED SHUTDOWN 1. - Page 17 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS 302130104 Left Fryer Burner 302170023B Thermopile 302150057 Main Burner Orifice #39 (Natural) 302150058 Main Burner Orifice #52 (Propane) 302201337 Orifice Extension 302220073B Safety High Limit (450°F) 302130202B Pilot 3-Way (Natural) 302130201B Pilot 3-Way (Propane)
- Page 18 OWNER’S MANUAL KRATOS GAS FLOOR FRYERS 20237107071+20237035085 Flue Top 20237028020+20237044023 Flue Top 20237031038+20237034030 Flue Top 20137035013 Flue Wrap 20137058004 Flue Warp Part # Description 20137056003 Door Assembly Complete 20137058003 Door Assembly Complete 302190245 Door Magnet 6” Adjustable Leg 302090001 302090081+302090082 Caster Kit, (2 Front Swivel w/Brake, 2 Rear Fixed) Fry Basket (13.25”...
-
Page 19: Warranty
1 year Equipment Limited Warranty Kratos offers a 1 year warranty to the original purchaser of new equipment, the model of equipment will be free of defects in material and workmanship for a period of 1 year from the date of delivery.
Need help?
Do you have a question about the 29Y-010 and is the answer not in the manual?
Questions and answers