Summary of Contents for ELECTRIC WHEELS EW-620
- Page 1 Assembly and Setup Instructions EW-620 Electric Wheel LLC – electricwheelstore.com - 888-305-0881 (Toll Free) - 5000 Birch St West Tower- Suite 3000, Newport Beach, CA 92660...
- Page 2 4. 6mm Allen Wrench 1. Remove the EW-620 from it’s carton. Lift the bike out of the carton, assistance will be needed. If no assistance available start by opening the top to allow access to the inside of the carton. Use a knife to cut each corner from the inside out (Figure A).
- Page 3 3. After you have placed the bike on it’s kickstand make sure you have all the components in the bike as shown in Figure C. Components included on the EW-620 A. Pedals. B. Derailleur protector. C. Basket holder frame with bolts and nuts.
- Page 4 Basket Installation Tools you will need to attach the Basket -Philips screwdriver -Basket -Part C (bolts, nuts and frame) 1. Remove bolts and nuts on each side of the steering fork (Figure A). 2. Place the Frame and tighten up with the bolts and nuts previously removed (figure B). 3.
- Page 5 5. Drop both D screws into place (Figure E). 6. Place Bracket A underneath and tighten it up (Figure E). Pedals Installation Tools you will need to attach the Pedals -15 mm Wrench 1. Make sure you insert each pedal with its correspondent side (Figure A). 2.
- Page 6 Adjusting the Seat 1. Adjust seat to desired height, tighten it by turning seat lever clockwise until secure (Figure A). Installing the Derailleur Guard Tools you will need to attach the Derailleur Guard -Philips Screwdriver 1. Remove the two screws as shown in Figure A. 2.
- Page 7 How to properly remove the Battery Pack 1. Unlock the Battery lock located at the bottom of the Battery Pack. 2. Press on the lever underneath the seat to unlock the sea (Figure A). 3. Use Battery pack handle to remove Battery Pack (Figure B). Electric Wheel LLC –...
- Page 8 Charging the Battery 1. Plug Charger into Battery Pack (Figure A). 2. Leave Battery pack charge Until green light on charger appears Warning! (1) Charge in dry and airiness place, forbidden to charge in room. (2) Charging far away clothing,, gasoline, alcohol, gas and so on the flammable things. (3) When charging, the charger must not be touched by children.
- Page 9 How to Turn the Bike on Insert Key in ignition located on Battery Pack and turn to the right (Figure A). How to Turn Headlight On/Off Locate and flip On/Off switch below the headlight (Figure B). Electric Wheel LLC – electricwheelstore.com - 888-305-0881 (Toll Free) - 5000 Birch St West Tower- Suite 3000, Newport Beach, CA 92660...
- Page 10 How to use the throttle - Turn the throttle down to start riding on electric power (Figure A). How to read the Battery Meter - Red = 0% -Green 1= 25% -Green 2= 50 % -Green 3= 75% -Green 4= 100% Electric Wheel LLC –...