Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Summary of Contents for Hikobike ENDURO 2022
- Page 1 PLEASE READ THIS GUIDE BEFORE RIDING YOUR EBIKE ENDURO 2022 model USER GUIDE...
-
Page 2: Table Of Contents
CONTENTS GENERAL PRECAUTIONS BEFORE RIDING SPECIFICATIONS BATTERY BATTERY CHARGING BATTERY STORAGE & SUSPENSION ADJUSTMENT INSTALLING AND REMOVING THE BATTERY BATTERY WARNINGS LED DISPLAY C600 CONTROL PANEL QUICK START NORMAL OPERATION ON / OFF POWER ASSIST - PAS SELECTION HEAD LIGHT / REAR LIGHT AND BACKLIGHT DISPLAY INDICATOR CURRENT DISPLAY SET OPERATION (RIDING MODE, TRIP RESET, MAX SPEED, KM/H OR MPH) BATTERY CAPACITY INDICATOR... -
Page 3: General Precautions Before Riding
ASSEMBLY The assembly of your HIKOBIKE must be performed and safety checked by a HIKOBIKE dealer or bicycle mechanic. Assembly of the stem, handle bars, and tuning of the gears and brakes requires expert bicycle mechanic knowledge. GENERAL PRECAUTIONS BEFORE RIDING Always wear a safety bicycle helmet when riding a HIKOBIKE electric bike. -
Page 4: Battery
BATTERY HIKOBIKE ENDURO comes standard with a 48v Samsung Li-Ion battery with a built in Battery Management System (BMS). The BMS is an important component as it allows the charger to charge the Samsung cells evenly, which will maximise the life expectancy and storage power of the battery. -
Page 5: Battery Storage & Suspension Adjustment
Allowing the battery to fully discharge during long storage can destroy your battery. SUSPENSION ADJUSTMENT Your Hikobike has been set up for an average rider and so for most people will not need altering. However, you can adjust both the seat suspension and the front fork suspension for either a harder or softer ride or for heavier or lighter riders. -
Page 6: Installing And Removing The Battery
The battery is then secure BATTERY WARNINGS The Li-Ion battery is one of the major components on the HIKOBIKE e-bikes and great effort should be taken to look after it. • Always handle with great care. Do not drop or allow it to be struck. -
Page 7: Led Display C600
LED DISPLAY C600 AND CONTROL PANEL... -
Page 9: Quick Start
Pulling on either the front or rear brake level will stop the motor immediately. For optimum battery life, try to avoid riding your HIKOBIKE until the battery is completely flat. Turn off the power assist as soon as you notice the battery has lost power and pedal the bike home, charging the battery as soon as possible. -
Page 10: Normal Operation
NORMAL OPERATION ON / OFF Push ON / OFF to start the display. The display will provide power to the controller. Push ON / OFF again to operate the backlight. With the display on, press ON / OFF for 3 seconds to turn the power OFF. -
Page 11: Current Display
6 KM/HR WALK MODE This mode is handy when pushing your HIKOBIKE up a steep incline or when you just want to walk beside it. Hold the DOWN ( - ) button for 2 seconds to get into 6 KM/HR Walk mode, and keep the button pressed. -
Page 12: Set Operation (Riding Mode, Trip Reset, Max Speed, Km/H Or Mph)
SET MENU OPERATION Hold the SET button for 2 seconds and enter the setting interface. Number 0 will be displayed, and the display will flash. Click the SET to cycle from 0 to 4. Press UP or DOWN to select the desired parameter and hold the SET for 1 second to exit. -
Page 13: Battery Capacity Indicator
BATTERY CAPACITY INDICATOR The battery indicator has 5 segments each representing 20% battery capacity. When the battery is full the 5 segments all light up. When the battery is severely low the last segment will flash. It is recommended to charge the battery immediately. -
Page 14: Error Codes
ERROR CODES Error Definition Trouble Shooting code Normal Current Error or Controller Damage Check Controller Throttle Error Check Throttle Motor No Phase Position Check Motor Hall Sensor Error Check Motor Brake Error Check Brakes Under Voltage Check Battery Motor Stalling Check Battery / Motor Communication Error from Controller Check Controller Connections... -
Page 15: Torque Settings
M6 6.0-7.5 Nm Dos and Don’ts Do treat your HIKOBIKE like any bicycle you would want to last well. Keep it stored somewhere secure and away from the elements. Don’t treat your HIKOBIKE as a dirt-bike. The motor and battery are weatherproof, but not water- tight. -
Page 16: Warranty
Warranty work should only be carried out by authorised Hikobike agents and does not cover the any transport costs. Hikobike accept no liability for damage to the e-bike or parts that have arisen from: incorrect tuning of moving parts; the improper use of the e-bike; and the improper maintenance of the e-bike. This includes damage as a result of untimely replacement of parts which suffer wear and tear. -
Page 17: Contact
CONTACT United Kingdom www.hikobike.co.uk Email: hello@hikobike.co.uk New Zealand www.hikobike.co.nz Email: info@hikobike.co.nz...
Need help?
Do you have a question about the ENDURO 2022 and is the answer not in the manual?
Questions and answers