General Description And Application; Special Features - White Lightning M Series Operator's Manual

General Description and Application

This manual is applicable to both the M1435 and M2827 models. Model specific references in this
manual will be separated by a slash.
The M1435/M2827 Mini-GPUs are specialized switching-mode power supplies designed to provide
pilots and aviation maintenance professionals with a portable, affordable source of stable, high-current,
noise-free DC power that replicates the in-flight electrical environment. Depending upon the model, its
rated output is either 14-volts DC up to 35-amps maximum continuous current (approximately 500
watts), or 28-volts up to 27-amps (approximately 750 watts). The GPU's intended purpose is to energize
aircraft's main electrical bus without using the battery or engine. It will safely provide continuous power
for the most delicate electronics and airframe systems up to its full rated output.
Typical Uses
●
●
●
FRONT PANEL VIEW

Special Features

Color-coded, keyed SB-50 type output connections to prevent accidental voltage mismatch
●
(Yellow designates 12/14 volt compatibility, Red designates 24/28 volt compatibility)
Dual digital output meters for voltage and current load
●
Front panel status indicator LED
●
Programmable auto-shutdown timer
●
Dual USB power ports for mobile device charging
●
●
QuietFiltered™ output for interference-free COM radio operation
Auto protection/recovery from short circuit, reverse polarity, over voltage/load/temperature
●
Operating Conditions and Limitations
The M1435/2827 is internally fan-cooled and relies on unobstructed ventilation access for proper
operation. The GPU should operate on a clean, hard surface so that debris cannot be ingested. Its
design assumes a dry operating environment. If used outdoors, it is the operator's responsibility to
ensure that the unit is not exposed to moisture.
The M1435/2827 is designed to provide airframe power only. It is not a battery charger. It does not
monitor the state-of-charge of the aircraft battery. It is not suitable for engine starting.
M-Series Mini-GPU Manual P/N 752-697, Rev 20211201
power avionics for flight planning, familiarization, and training
update flight deck database and software
troubleshooting and maintenance
REAR PANEL VIEW
3