Advertisement
Quick Links
File: 091-9B-1_GEN3
Rev: A
Revised By:PS
Date: 07_06_2016
170 Cherry Avenue
West Sayville, NY 11796
www.kussmaul.com
INSTRUCTION MANUAL
AUTO-PUMP
120 VAC
AIR COMPRESSOR SYSTEM
MODEL #: 091-9B-1
MODEL #:091-9B-1
INPUT :120 volt, 50/60 Hz, 1.8 AMPS
OUTPUT: 100 PSI MAXIMUM
1YEAR WARRANTY
®
scan using your mobile
device for more information
Ph: 800-346-0857
Fax: 631-567-5826
sales@kussmaul.com
Advertisement
Related Manuals for KUSSMAUL AUTO-PUMP
Summary of Contents for KUSSMAUL AUTO-PUMP
- Page 1 INSTRUCTION MANUAL ® AUTO-PUMP 120 VAC AIR COMPRESSOR SYSTEM MODEL #: 091-9B-1 MODEL #:091-9B-1 INPUT :120 volt, 50/60 Hz, 1.8 AMPS OUTPUT: 100 PSI MAXIMUM File: 091-9B-1_GEN3 Rev: A scan using your mobile Revised By:PS 1YEAR WARRANTY device for more information...
- Page 2 INTRODUCTION The 091-9B-1 Auto-Pump Air Compressor system is a 120 volt 50/60 Hz capacitor start A.C. motor operating a single cylinder air compressor designed specifically for installation on vehicles with air brakes. During long idle periods of the vehicle when...
- Page 3 ROUTE OUTPUT PRESSURE LINE DOWNWARD FROM AUTO PUMP TO PERMIT MOISTURE TO DRAIN AWAY. WATER IN THE PUMP OUTLET WILL INDUCE FAILURE! WATER DAMAGE WILL VOID WARRANTY 170 Cherry Avenue Ph: 800-346-0857 West Sayville, NY 11796 Fax: 631-567-5826 www.kussmaul.com sales@kussmaul.com...
- Page 4 VEHICLE TUBING INSTALLATION 1. Mount all components in a suitable location, preferably in a high area above the air system. Do not mount in engine compartment or near any source of heat or dirt. The system may be connected to any point in the vehicle's air system. 2.
- Page 5 VEHICLE WIRING INSTALLATION 1. The Auto Pump is supplied with a 120 volt A.C. line cord and is ready to operate. The line cord may be plugged into an available outlet or the cord may be cut and permanently wired to the 120 volt A.C.
- Page 6 Switch Differential: 20 PSI Nominal Outlet Connection: 1/4 NPT, Female 185.77 195.91 7.31 7.71 38.10 1.50 179.84 150.99 7.08 5.94 6X, 1/4-20 121.92 2X, 1.75 TAPPED HOLES 4.80 88.90 3.50 170 Cherry Avenue Ph: 800-346-0857 West Sayville, NY 11796 Fax: 631-567-5826 www.kussmaul.com sales@kussmaul.com...
- Page 7 TEMPLATE AUTO PUMP 3.50" 17/64” DIA. HOLE 6 PLACES Note: Verify measurements before using as a template. Must set print settings to “Actual Size”.
- Page 8 ACCESSORIES MOUNTING PLATE 091-9H-1 CAUTION: WATER IN THE PUMP OUTLET WILL INDUCE FAILURE WATER DAMAGE OR OPERATING AUTO PUMP OVER 100 PSI WILL VOID WARRANTY 170 Cherry Avenue Ph: 800-346-0857 West Sayville, NY 11796 Fax: 631-567-5826 www.kussmaul.com sales@kussmaul.com...
-
Page 9: Installation Record
Equipment is to be returned, shipping charges prepaid and will be returned, after repair, shipping charges paid. Kussmaul Electronics Company, Inc. shall have no liability for damages of any kind to associated equipment arising from the installation and/or use of the Kuss- maul Electronics Company, Inc.
Need help?
Do you have a question about the AUTO-PUMP and is the answer not in the manual?
Questions and answers